Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Gasoline. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports1 injury reports
What owners actually said
1 reports
Mileage unknown · Sep 6, 2002
Fuel System, GasolineFireInjury
THE INJECTORS LEAKED INTO THE RADIATOR THEN TO THE RESERVOIR, IT OVERFLOWED AND WATER AND DIESEL FUEL LEAKED ONTO THE MANIFOLD AND THE TURBO AND THEN THE FIRE STARTED. THE DRIVERS BARELY GOT OUT OF THE CAB OF THE TRUCK BEFORE IT FULLY IGNITED BURNING THE COMPLETE CAB RESULTING IN A TOTAL LOSS. THE DRIVERS INJURED TRYING TO GET O…
Read full complaint
THE INJECTORS LEAKED INTO THE RADIATOR THEN TO THE RESERVOIR, IT OVERFLOWED AND WATER AND DIESEL FUEL LEAKED ONTO THE MANIFOLD AND THE TURBO AND THEN THE FIRE STARTED. THE DRIVERS BARELY GOT OUT OF THE CAB OF THE TRUCK BEFORE IT FULLY IGNITED BURNING THE COMPLETE CAB RESULTING IN A TOTAL LOSS. THE DRIVERS INJURED TRYING TO GET OUT OF CAB.ALL PERSONEL BELONGINGS WERE DESTROYED.
ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Consequence & remedy
Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURNING, AND IN AN UNDERHOOD FIRE.
Remedy: FORD IS CONDUCTING THIS RECALL (PLEASE SEE 06V286) AND WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR JAYCO AT 1-800-283-8267.
VEHICLE DESCRIPTION: FOLD DOWN TRAILERS WHICH USE GAS/ELECTRIC ABSORPTION REFRIGERATORS SUPPLIED BY NORCOLD. THE SWIVEL NUT WHICH IS AN INTEGRAL CONNECTION COMPONENT OF A PRESSURE TAP DEVICE HAS "STRESS CORROSION CRACKING."
Consequence & remedy
Consequence: THIS CRACKING CAN LEAD TO AN OPEN FRACTURE IN THE BRASS NUT, POTENTIALLY ALLOWING PROPANE GAS TO LEAK.
Remedy: DEALERS WILL REMOVE THE SWIVEL NUT/PRESSURE TAP COMPONENT AND REPLACE WITH A REMEDY KIT.
VEHICLE DESCRIPTION: MINI-MOTOR HOMES, TRAVEL TRAILERS, AND FIFTH WHEELS EQUIPPED WITH A PRINTED CIRCUIT (PC) BOARD HOUSED IN THE ELECTRICAL CONTROL BOX ASSEMBLY EQUIPPED WITH THE VEHICLE'S AIR CONDITIONING UNIT. AN ELECTRICAL RELAY ON THE PC BOARD WILL FAIL TO ACTIVATE. WHEN THE RELAY FAILS TO ACTIVATE, OTHER ELECTRICAL COMPONENTS, AND THE PC BOARD ITSELF, ARE REQUIRED TO CARRY EXCESS ELECTRICAL CURRENT.
Consequence & remedy
Consequence: THE ELECTRICAL COMPONENTS AND THE PC BOARD CAN OVERHEAT, CHAR AND PRODUCE SMOKE, POSSIBLY RESULTING IN A FIRE.
Remedy: RV PRODUCTS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY CAMPAIGN FOR THIS RECALL. OWNERS WILL RECEIVE A REPLACEMENT ELECTRICAL CONTROL BOX AND INSTALLATION INSTRUCTIONS. IF AN OWNER SO DESIRES, THEY CAN HAVE THEIR DEALER INSTALL THIS CONTROL BOX.
VEHICLE DESCRIPTION: TRAVEL TRAILERS EQUIPPED WITH 20 LB. LPG CYLINDERS SUPPLIED BY MANCHESTER TANK. THESE CYLINDERS ARE EQUIPPED WITH AN OVERFILL PROTECTION. THE OVERFILL PROTECTION DEVICE MAY NOT FUNCTION PROPERLY.
Consequence & remedy
Consequence: IF A CYLINDER IS OVERFILLED, AND SOME OF THE GAS LEAKS OUT, THE VAPORS COULD IGNITE IF THERE WAS A SOURCE OF IGNITION PRESENT.
Remedy: MANCHESTER TANK IS PERFORMING THE OWNER NOTIFICATION AND REMEDY CAMPAIGN FOR THIS RECALL. MANCHESTER WILL REPLACE THESE LPG CYLINDERS.
VEHICLE DESCRIPTION: TRAVEL AND FOLDING TRAILERS EQUIPPED WITH DEXTER AXLES. THE WHEEL BEARINGS USED IN SOME OF THESE AXLES HAVE A METALLURGICAL DEFECT CAUSING EARLY FAILURE.
Consequence & remedy
Consequence: A WHEEL BEARING FAILURE COULD RESULT IN THE LOSS OF THE WHEEL END FROM THE AXLE INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEXTER AXLE IS CONDUCTING THE NOTIFICATION AND REMEDY FOR THIS RECALL. DEALERS WILL INSPECT THE AXLES AND REPLACE THE WHEEL BEARINGS IF NECESSARY.
VEHICLE DESCRIPTION: FIFTH WHEEL AND TRAVEL TRAILERS. RIVETS USED TO SECURE THE STEP RISERS ON THESE VEHICLES ARE THE WRONG SIZE. THE RIVETS ARE TOO SHORT IN LENGTH AND UNDER STRESS CAN ALLOW THE STEP TREADS TO BECOME UNATTACHED FROM THE MOUNTING BRACKET.
Consequence & remedy
Consequence: IF THE STEP RISER FALLS FROM THE MOUNTING BRACKET WHILE A PERSON IS STEPPING ON IT, PERSONAL INJURY COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE STEP RISER ASSEMBLY.
AN IN-LINE FUSE TO THE AUXILIARY BATTERY WAS OMITTED.
Consequence & remedy
Consequence: IF A SHORT OCCURRED IN THE POWER LINE FROM THE BATTERY WITHOUT THE PRESENCE OF OVER-CURRENT PROTECTION, THE 12 VOLT LINE CAN OVERHEAT, INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL AN IN-LINE FUSE TO THE AUXILIARY BATTERY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1997 Jayco Eagle Problems, Complaints & Recalls | Skip That Year
Illustration