Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Trailer Hitches. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reports
19,000 miles · Nov 21, 2003
Trailer Hitches
CONSUMER STATES THAT "THE KING PIN HITCH ASSEMBLY WAS BREAKING LOOSE AND COMING APART. THE 6 INCH SEA CHANNEL ACROSS THE FRONT OF THE FIFTH WHEEL BROKE IN HALF, DOWN THE CENTER. THE BEDROOM FLOOR AREA DROPPED 4 INCHES." THE MANUFACTURER OF THE FRAME IS PROVIDING NO ASSISTANCE. *NLM THE KING PIN HITCH ASSEMBLY ON TRAILER B…
Read full complaint
CONSUMER STATES THAT "THE KING PIN HITCH ASSEMBLY WAS BREAKING LOOSE AND COMING APART. THE 6 INCH SEA CHANNEL ACROSS THE FRONT OF THE FIFTH WHEEL BROKE IN HALF, DOWN THE CENTER. THE BEDROOM FLOOR AREA DROPPED 4 INCHES." THE MANUFACTURER OF THE FRAME IS PROVIDING NO ASSISTANCE. *NLM THE KING PIN HITCH ASSEMBLY ON TRAILER BROKE LOOSE. THE EXTENSION FRAME WAS REPLACED TO CORRECT THE PROBLEM.*MR
NHTSA ODI #10048452
Mileage unknown · Sep 10, 2002
SuspensionTrailer Hitches
THERE WAS A CRACK IN THE FRONT BEAM, WHICH WAS CAUSED BY DRILLING TO PUT OTHER COMPONENTS INTO THE VEHICLE. *AK THE CONSUMER STATES THAT THE CRACK IS A RESULT OF A TOO LIGHT CHANNEL IRON AND THE DRILL HOLE COMBINED, WHEN THE RV DEALER INSTALLED A LELAND ENGINEERING EXTENDED HITCH ON A NEW SHORT BED PICKUP THIS WAS POSSIBLY THE…
Read full complaint
THERE WAS A CRACK IN THE FRONT BEAM, WHICH WAS CAUSED BY DRILLING TO PUT OTHER COMPONENTS INTO THE VEHICLE. *AK THE CONSUMER STATES THAT THE CRACK IS A RESULT OF A TOO LIGHT CHANNEL IRON AND THE DRILL HOLE COMBINED, WHEN THE RV DEALER INSTALLED A LELAND ENGINEERING EXTENDED HITCH ON A NEW SHORT BED PICKUP THIS WAS POSSIBLY THE FACTOR IN THE CRACK/BREAK. *SCC
ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Consequence & remedy
Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURNING, AND IN AN UNDERHOOD FIRE.
Remedy: FORD IS CONDUCTING THIS RECALL (PLEASE SEE 06V286) AND WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR JAYCO AT 1-800-283-8267.
VEHICLE DESCRIPTION: TRAVEL AND FIFTH WHEEL TRAILERS. THE FASTENERS USED ON THE UNDERFLOOR CAN EITHER COME LOOSE OR PULL THROUGH THE UNDERFLOOR CAUSING PORTIONS OR ALL OF A SECTION OF UNDERFLOOR TO DETACH FROM THE VEHICLE.
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SECTION COULD FALL TO THE PAVEMENT, POTENTIALLY CAUSING A CRASH FOR FOLLOWING VEHICLES.
Remedy: DEALERS WILL ADD OR REPLACE FASTENERS. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT JAYCO AT 1-219-825-5861.
Illustration