Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Tires. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reports
12,113 miles · Nov 20, 2014
Structure
WHILE DRIVING NORTH ON I-15 BETWEEN HESPERIA AND BARSTOW, CALIFORNIA, THE FIBERGLASS SKIN ON THE ROOF OF OUR RV STARTED BLOWING OFF. BY THE TIME WE WERE ABLE TO SAFELY PULL TO THE SIDE OF THE FREEWAY, 80% OF THE ROOF SKIN HAD SEPARATED FROM THE FRAME AND LARGE PARTS WERE FLYING THROUGH THE AIR. FORTUNATELY THE WIND WAS BLOWING …
Read full complaint
WHILE DRIVING NORTH ON I-15 BETWEEN HESPERIA AND BARSTOW, CALIFORNIA, THE FIBERGLASS SKIN ON THE ROOF OF OUR RV STARTED BLOWING OFF. BY THE TIME WE WERE ABLE TO SAFELY PULL TO THE SIDE OF THE FREEWAY, 80% OF THE ROOF SKIN HAD SEPARATED FROM THE FRAME AND LARGE PARTS WERE FLYING THROUGH THE AIR. FORTUNATELY THE WIND WAS BLOWING TOWARDS THE SHOULDER AND MOST OF THE FLYING DEBRIS LANDED ON THE SIDE OF THE ROAD AS WE WERE IN THE LANE CLOSEST TO THE SHOULDER. THE DEBRIS INCLUDED THE LAVATORY EXHAUST FAN, FIBERGLASS STYREFOAM, WOOD PANELING AND POSSIBLY COULD HAVE BROUGHT THE AIR CONDITIONER AND SATELLITE DOWN. AFTER TALKING TO SEVERAL REPAIR SHOPS AND READING ONLINE, THIS HAS BEEN AN ONGOING PROBLEM WITH THESE VEHICLES AND NO ONE FROM WINNEBEGO/ITASCA NOTIFIED US OF THIS POTENFIAL FAILURE. I BELIEVE THAT SERIOUS INJURIES OR DEATHS COULD RESULT FROM THIS. *TR
NHTSA ODI #10659757
1,500 miles · Nov 3, 2009
Tires
TL* THE CONTACT OWNS A 2006 ITASCA SUNOVA RV WITH GOODYEAR TIRES DOT# MJ93-MAHW, SIZE 245/70/ R19. WHILE DRIVING 50 MPH SHE HEARD A PECULIAR NOISE FROM THE REAR END OF THE VEHICLE. UPON VEHICLE INSPECTION SHE NOTICED THAT THE INSIDE OF DRIVER-SIDE REAR TIRE HAD EXPLODED. THE TIRE WAS TAKEN TO A DEALERSHIP WHERE THE CONTACT WA…
Read full complaint
TL* THE CONTACT OWNS A 2006 ITASCA SUNOVA RV WITH GOODYEAR TIRES DOT# MJ93-MAHW, SIZE 245/70/ R19. WHILE DRIVING 50 MPH SHE HEARD A PECULIAR NOISE FROM THE REAR END OF THE VEHICLE. UPON VEHICLE INSPECTION SHE NOTICED THAT THE INSIDE OF DRIVER-SIDE REAR TIRE HAD EXPLODED. THE TIRE WAS TAKEN TO A DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE INNER MESH LINING OF THE TIRE HAD CORRODED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 19500. UPDATED 12/07/09. *LJ THE CONSUMER HAD EXPERIENCED 4 TIRE BLOWOUTS. GOODYEAR DID NOT OFFER ANY ASSISTANCE. UPDATED 12/08/09
WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
Consequence & remedy
Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.
WINNEBAGO IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2009 WINNEBAGO SIGHTSEER AND ITASCA SUNOVA MOTOR HOMES BECAUSE THE DINETTE AREA SEAT BELT RESTRAINTS ON THOSE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." IN A COLLISION, THE GENERATED CRASH FORCES CAN CAUSE THE RESTRAINT'S ATTACHMENT TO TEAR AND ALLOW THE ANCHOR TO SEPARATE FROM THE BODY OF THE VEHICLE.
Consequence & remedy
Consequence: IF THE RESTRAINT SEPARATES FROM THE VEHICLE DURING A CRASH, THE BELT WILL NOT PROPERLY RESTRAIN THE SEAT OCCUPANT, INCREASING THE RISK OF INJURY OR DEATH TO THE OCCUPANT.
Remedy: WINNEBAGO WILL NOTIFY OWNERS A DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.
WINNEBAGO IS RECALLING 717 MY 2006-2009 SIGHTSEER AND VISTA, ITASCA SUNOVA AND SUNSTAR MOTOR HOMES BUILT ON WORKHORSE CHASSIS. THE CASTLE NUT THAT RETAINS THE STEERING DRAG LINK TO THE PITMAN ARM MAY HAVE BEEN IMPROPERLY TORQUED DURING ASSEMBLY. THE IMPROPER TORQUE MAY HAVE DAMAGED THE CASTLE NUT AND COMPROMISED THE INTEGRITY OF THE CONNECTION.
Consequence & remedy
Consequence: IF THE DRAG LINK WERE TO SEPARATE FROM THE PITMAN ARM, THE DRIVER WOULD NOT HAVE DIRECTIONAL CONTROL OF THE VEHICLE POSSIBLY CAUSING A CRASH.
Remedy: WINNEBAGO IS WORKING WITH WORKHORSE TO REPLACE AND PROPERLY TIGHTEN THE CASTLE NUT THAT RETAINS THE STEERING DRAG LINK TO THE PITMAN ARM (PLEASE SEE 08V442). OWNERS MAY CONTACT WORKHORSE AT 1-877-946-7731 OR WINNEBAGO AT 1-641-585-3535.
CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE STEERING COULD BECOME LOOSE AT THE STEERING BOX DURING TIGHT STEERING MANEUVERS.
Consequence & remedy
Consequence: THIS STEERING CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: WORKHORSE IS CONDUCTING THIS RECALL (PLEASE SEE 06V148000) AND WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFT. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6883 OR WINNEBAGO AT 1-641-585-3535.
ON CERTAIN MOTOR HOMES, THE FLAME ON THE COOKING RANGE MAY BE FORCED DOWNWARD OVER THE BURNER OR FLAME OUTAGE MAY OCCUR WHEN THE COOKING RANGE AND FURNACE ARE OPERATED AT THE SAME TIME. THIS CONDITION IS DUE TO THE POSSIBILITY OF A MISSING CABINET PANEL THAT ISOLATES THE FURNACE RETURN AIR.
Consequence & remedy
Consequence: IF THE FURNACE IS OPERATED AT THE SAME TIME AS THE STOVE AND THE CABINET PANEL IS MISSING, THE STOVE FLAME MAY GO OUT AND THE PROPANE GAS WILL CONTINUE TO FLOW, WHICH HAS THE POTENTIAL TO IGNITE RESULTING IN PERSONAL INJURY OR VEHICLE AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT THE CABINET ASSEMBLY FOR A CABINET PANEL AND INSTALL ONE IF NECESSARY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON JUNE 2, 2006. OWNERS MAY CONTACT WINNEBAGO AT 641-585-6939.
ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC STEPS, THE STEPS MAY HAVE BEEN MANUFACTURED WITH DEFECTIVE STEP CONTROL UNITS.
Consequence & remedy
Consequence: THE DEFECTIVE CONTROL UNITS COULD DEVELOP AN ELECTRICAL SHORT ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE, POSSIBLY RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT THE KWIKEE STEP AND REPLACE THE STEP CONTROL UNIT, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 23, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.
ON CERTAIN MOTOR HOMES WITH THE OPTIONAL GALLEY UPGRADE PACKAGE, KNIVES STORED IN THE GALLEY KNIFE HOLDER MAY INTERFERE WITH THE PROPANE GAS LINE TO THE STOVE.
Consequence & remedy
Consequence: THE KNIVES COULD DAMAGE THE PROPANE GAS LINE ALLOWING PROPANE GAS TO ESCAPE, WHICH HAS THE POTENTIAL TO IGNITE, RESULTING IN PERSONAL INJURY OR VEHICLE PROPERTY DAMAGE.
Remedy: DEALERS WILL PROPERLY ROUTE THE PROPANE GAS LINE AND INSTALL A KNIFE SHIELD. THE RECALL BEGAN ON NOVEMBER 11, 2005. OWNERS MAY CONTACT WINNEBAGO AT 641-585-6939.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE10048 · Hitch Receiver Fracture
Opened Dec 7, 2010 · Closed Dec 3, 2013
Status: closed (inferred from source dates) · Trailer Hitches
During this investigation, ODI identified 29 reports of cracked and/or fractured hitch receiver assemblies installed on the subject vehicles.The majority (27 of 29) of the reported hitch incidents occurred prior to the initiation of PE10-048 in December, 2010.This investigation has been characterized by (1) Scant forensic samples available for inspection and review since most of the reported incidents occurred prior to ODI?s investigation and pertinent material has been scrapped; (2) Uncertainty regarding the contributory role of issues such as unintended hitch contact with road surfaces, use of hitches with offsets that exceed Winnebago recommendations; and (3) Other usage factors.Based on reported failures, the indicated failure rate for detected and reported cracking /fracture incidents associated with the estimated population of subject vehicles was found to be 0.10% after the vehicles had been in service for between 6 and 8 years.Reports were higher in calendar year 2007 (9 reports) than in succeeding years 2008-2010 (3-5 reports per year) and 2011 (2 reports) and appear likely to decline further due to diminished use associated with vehicle aging.ODI is aware of only one consumer complaint (ODI# 10368002) in its files describing a hitch receiver malfunction in Winnebago-Itasca vehicles.As of September 2013, Winnebago has reported that there have been no additional incidents of cracked or fractured hitch receivers reported since the most recent incident reported in May 2011.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.For more detailed information, see the attached closing report.
2006 Itasca Sunova Problems, Complaints & Recalls | Skip That Year
Illustration