Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
1 reports
2,500 miles · Nov 12, 2004
Engine And Engine Cooling
REGARDING A MODEL YEAR 2005 WINNEBAGO ITASCA MOTORHOME (SERIAL NO. 70467F241566C) UTILIZING A MODEL YEAR 2004 FORD E450 CHASSIS. WHILE SLEEPING AN ALARM WENT OFF INSIDE THE MOBILE HOME. THE LOCAL FIRE DEPARTMENT ARRIVED ON LOCATION AND FOUND A SLIDE OUT SHIELD WAS BLOCKING THE GENERATOR EXHAUST SYSTEM, IN WHICH THE CARBON MONOX…
Read full complaint
REGARDING A MODEL YEAR 2005 WINNEBAGO ITASCA MOTORHOME (SERIAL NO. 70467F241566C) UTILIZING A MODEL YEAR 2004 FORD E450 CHASSIS. WHILE SLEEPING AN ALARM WENT OFF INSIDE THE MOBILE HOME. THE LOCAL FIRE DEPARTMENT ARRIVED ON LOCATION AND FOUND A SLIDE OUT SHIELD WAS BLOCKING THE GENERATOR EXHAUST SYSTEM, IN WHICH THE CARBON MONOXIDE WAS SETTING OFF THE ALARM. CONSUMER WAS NOTIFIED.*AK WHEN THE EMERGENCY RESPONSE TEAM ARRIVED THEY TOOK A CARBON MONOXIDE READING OF 33 P.P.M. INSIDE THE MOTOR HOME. *TC *MJJ
ON CERTAIN MOTOR HOMES EQUIPPED WITH FRONT OVERHEAD TELEVISIONS, INCORRECT FASTENERS WERE USED TO SECURE THE TELEVISION LOCATED IN THE FRONT OVERHEAD AREA OF THE MOTOR HOME.
Consequence & remedy
Consequence: THE TELEVISION MAY BECOME LOOSE AND POSSIBLY FALL FROM ITS POSITION WHICH HAS THE POTENTIAL TO IMPACT THE DRIVER OR PASSENGERS, RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT THE VEHICLE TO ASSURE THE CORRECT FASTENERS (BOLTS) WERE USED IN THE TV RETENTION STRAP. THE RECALL BEGAN ON DECEMBER 15, 2006. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.
ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE FASTENERS HOLDING THE FUEL TANK MOUNTING STRAPS MAY NOT HAVE BEEN PROPERLY TIGHTENED, ALLOWING THE POSSIBILITY FOR THE FUEL TANK TO LOOSEN AND FALL.
Consequence & remedy
Consequence: IF THE FUEL TANK FALLS, THERE IS THE POTENTIAL FOR THE TANK TO IGNITE, RESULTING IN PERSONAL INJURY, VEHICLE AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT AND PROPERLY TIGHTEN THE FASTENERS TO THE FUEL TANK STRAPS. THE RECALL BEGAN ON OCTOBER 15, 2005. OWNERS MAY CONTACT WINNEBAGO AT 614-585-6939.
ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS AND EQUIPPED WITH GAS ENGINES, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT.
Consequence & remedy
Consequence: THE ELECTRICAL SHORT MAY CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, OR THE MODULE MAY OVERHEAT RESULTING IN A BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS BEING DRIVEN OR UNATTENDED.
Remedy: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSTALL A NEW FUSE IN THE ABS CIRCUIT AND INSTALL A HEAT SHIELD OVER THE ABS MODULE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR WINNEBAGO AT 641-585-3535.
ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.
Consequence & remedy
Consequence: THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.
Remedy: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR WINNEBAGO AT 641-585-3535.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Itasca Sundancer Problems, Complaints & Recalls | Skip That Year
Illustration