THIS WAS THE THIRD TURBO FAILURE SINCE OUR PURCHASE OF THIS RV VEHICLE: 2006 ITASCA NAVION, WITH THE DODGE/MERCEDES BENZ SPRINTER. THE FIRST FAILURE WAS IN SEPT. , '05, ABOUT 1 1/2 MONTHS AFTER OUR PURCHASE. THE SECOND WAS IN AUGUST, '06. EACH TIME, IT LOST POWER SUDDENLY, WHILE WE WERE ON A MAJOR HIGHWAY, DECREASING OUR SPEE…
Read full complaint
THIS WAS THE THIRD TURBO FAILURE SINCE OUR PURCHASE OF THIS RV VEHICLE: 2006 ITASCA NAVION, WITH THE DODGE/MERCEDES BENZ SPRINTER. THE FIRST FAILURE WAS IN SEPT. , '05, ABOUT 1 1/2 MONTHS AFTER OUR PURCHASE. THE SECOND WAS IN AUGUST, '06. EACH TIME, IT LOST POWER SUDDENLY, WHILE WE WERE ON A MAJOR HIGHWAY, DECREASING OUR SPEED IMMEDIATELY TO APPROXIMATELY 30-35 MPH IF ON A DOWNHILL OR STRAIGHT ROAD. IT HAD NO POWER TO CLIMB EVEN A SLIGHT INCLINE. EACH TIME, THE RESONATOR HAD TO BE REPLACED. WE HAVE MET OTHER OWNERS OF THE SAME TYPE OF VEHICLE WHO HAVE HAD SIMILAR EXPERIENCES. ALL HAVE BEEN TOLD BY MECHANICS THAT THIS MOTOR WAS A POOR DESIGN; THAT WE COULD PURCHASE AND CARRY A SPARE RESONATOR WITH US FOR FUTURE FAILURES. THIS IS NOT ACCEPTABLE AND WILL CERTAINLY NOT KEEP US SAFE ON THE ROADS. *TR
WINNEBAGO IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 WINNEBAGO VIEW AND ITASCA NAVION MOTOR HOMES BECAUSE THE DINETTE AREA SEAT BELT RESTRAINTS ON THOSE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." IN A COLLISION, THE GENERATED CRASH FORCES CAN CAUSE THE RESTRAINT'S ATTACHMENT TO TEAR AND ALLOW THE ANCHOR TO SEPARATE FROM THE BODY OF THE VEHICLE.
Consequence & remedy
Consequence: IF THE RESTRAINT SEPARATES FROM THE VEHICLE DURING A CRASH, THE BELT WILL NOT PROPERLY RESTRAIN THE SEAT OCCUPANT, INCREASING THE RISK OF INJURY OR DEATH TO THE OCCUPANT.
Remedy: WINNEBAGO WILL ADD ADDITIONAL SEAT BELT ANCHORAGES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 12, 2010. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.
ON CERTAIN MOTOR HOMES, THE EXTERIOR SLIDEOUT STORAGE DRAWER CAN INADVERTENTLY SLIDE OUT DURING NORMAL HIGHWAY OPERATION.
Consequence & remedy
Consequence: THIS COULD IMPACT NEARBY PERSONS OR OBJECTS RESULTING IN PERSONAL INJURY AND/;OR VEHICLE AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A SECONDARY CATCH ON THESE MOTOR HOMES. THE RECALL BEGAN ON JUNE 15, 2007. OWNERS MAY CONTACT WINNEBAGO AT 1-614-585-3535.
ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC STEPS, THE STEPS MAY HAVE BEEN MANUFACTURED WITH DEFECTIVE STEP CONTROL UNITS.
Consequence & remedy
Consequence: THE DEFECTIVE CONTROL UNITS COULD DEVELOP AN ELECTRICAL SHORT ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE, POSSIBLY RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT THE KWIKEE STEP AND REPLACE THE STEP CONTROL UNIT, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 23, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.
ON CERTAIN MOTOR HOMES EQUIPPED WITH OPTIONAL REAR SUSPENSION AIR BAGS, THE UPPER MOUNT CAN MOVE AND CONTACT THE TIRE.
Consequence & remedy
Consequence: THIS COULD DAMAGE THE TIRE AND CAUSE VEHICLE INSTABILITY WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A REAR SUSPENSION AIR BAG UPPER MOUNT REINFORCEMENT KIT. THE RECALL BEGAN ON JUNE 17, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-6939.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE10048 · Hitch Receiver Fracture
Opened Dec 7, 2010 · Closed Dec 3, 2013
Status: closed (inferred from source dates) · Trailer Hitches
During this investigation, ODI identified 29 reports of cracked and/or fractured hitch receiver assemblies installed on the subject vehicles.The majority (27 of 29) of the reported hitch incidents occurred prior to the initiation of PE10-048 in December, 2010.This investigation has been characterized by (1) Scant forensic samples available for inspection and review since most of the reported incidents occurred prior to ODI?s investigation and pertinent material has been scrapped; (2) Uncertainty regarding the contributory role of issues such as unintended hitch contact with road surfaces, use of hitches with offsets that exceed Winnebago recommendations; and (3) Other usage factors.Based on reported failures, the indicated failure rate for detected and reported cracking /fracture incidents associated with the estimated population of subject vehicles was found to be 0.10% after the vehicles had been in service for between 6 and 8 years.Reports were higher in calendar year 2007 (9 reports) than in succeeding years 2008-2010 (3-5 reports per year) and 2011 (2 reports) and appear likely to decline further due to diminished use associated with vehicle aging.ODI is aware of only one consumer complaint (ODI# 10368002) in its files describing a hitch receiver malfunction in Winnebago-Itasca vehicles.As of September 2013, Winnebago has reported that there have been no additional incidents of cracked or fractured hitch receivers reported since the most recent incident reported in May 2011.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.For more detailed information, see the attached closing report.
PE06058 · Cargo Door Extending During Travel
Opened Dec 14, 2006 · Closed Apr 18, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages
WINNEBAGO HAS FILED DEFECT REPORT 07V-163 WHICH OUTLINES WINNEBAGO'S INTENTION TO INSTALL SECONDARY LATCHES ON THE AFFECTED CARGO DOORS OF THE AFFECTED VEHICLES.ODI BELIEVES THAT THE PROPOSED SECONDARY LATCH WILL PROVIDE A MORE RELIABLE LATCHING SYSTEM (1) FOR OWNERS WHO MAY INADVERTENTLY FAIL TO SECURE THE PRIMARY LATCH AND/OR (2) AS A REDUNDANT RETENTION MEANS FOR SITUATIONS IN WHICH A CARGO DOOR BECOMES MISALIGNED, DISTORTED, AND/OR DAMAGED IN A WAY THAT COMPROMISES THE INTEGRITY OF THE PRIMARY LATCH SYSTEM.
2006 Itasca Navion Problems, Complaints & Recalls | Skip That Year
Illustration