Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 9 of 9 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports0 injury reports
What owners actually said
9 reports
50,000 miles · Feb 16, 2018
Service Brakes
I RESPONDED TO A RECALL NOTICE (S91) ABS BRAKE LIGHT INDICATOR LIGHT MALFUNCTION. I WAS ADVISED THAT THIS IS DONE AS A SOFTWARE UPDATE TO THE COMPUTER ON MY SPRINTER MOTOR HOME. THE WORK WAS DONE BY ARRIGO DODGE.. HOWEVER, THE NEXT TIME I USED THE MOTOR HOME, THE ABS BREAK SYSTEM FAILED (WHILE EVACUATING HURRICANE IRMA) THUS C…
Read full complaint
I RESPONDED TO A RECALL NOTICE (S91) ABS BRAKE LIGHT INDICATOR LIGHT MALFUNCTION. I WAS ADVISED THAT THIS IS DONE AS A SOFTWARE UPDATE TO THE COMPUTER ON MY SPRINTER MOTOR HOME. THE WORK WAS DONE BY ARRIGO DODGE.. HOWEVER, THE NEXT TIME I USED THE MOTOR HOME, THE ABS BREAK SYSTEM FAILED (WHILE EVACUATING HURRICANE IRMA) THUS CAUSING THE MOTOR HOME TO GET STUCK IN 2ND GEAR WITH NO ABS BRAKES.. THE TOTAL BILL FOR PARTS AND LABOR WAS $5,054.26. THE GRAND TOTAL WAS $7678.49 AFTER ALL OTHER EXPENSES. AT THIS TIME, THE MOTOR HOME DOES NOT HAVE A WORKING ABS BRAKE SYSTEM WHICH IS A SAFETY ISSUE. THE REPAIR PEOPLE ADVISED ME THAT IF I PUT THE UPDATED SOFTWARE INTO THE NEW COMPUTER, THERE IS A 1 IN 3 CHANCE IT WOULD BLOW OUT THE COMPUTER AGAIN. MY MECHANIC STATED, IN WRITING, THAT THE REPAIR WAS DIRECTLY CAUSED BY UPDATE. AFTER SPEAKING TO JOHN ARRIGO AND ADVISING HIM OF PROBLEM, MR. ARRIGO DENIED ANY RESPONSIBILITY FOR THE PROBLEM. HE REFUSED TO CORRECT THE PROBLEM OR MAKE GOOD. MR. ARRIGO STATED HE DID NOT WRITE THE FAULTY SOFTWARE AND THEREFORE IS NOT RESPONSIBLE. THIS ATTITUDE PRESENTS AS UNPROFESSIONAL AND IS A SERIOUS SAFETY DANGER FOR CUSTOMERS AS WELL AS THE PUBLIC. ALL OTHER COMPANY'S CONTACTED REFUSED RESPONSIBILITIES INCLUDING DEALERS AND ALL PARTS MANUFACTURES OF THE MOTORHOME.
NHTSA ODI #11073252
31,853 miles · Oct 20, 2007
Electrical System
THIS WAS THE THIRD TURBO FAILURE SINCE OUR PURCHASE OF THIS RV VEHICLE: 2006 ITASCA NAVION, WITH THE DODGE/MERCEDES BENZ SPRINTER. THE FIRST FAILURE WAS IN SEPT. , '05, ABOUT 1 1/2 MONTHS AFTER OUR PURCHASE. THE SECOND WAS IN AUGUST, '06. EACH TIME, IT LOST POWER SUDDENLY, WHILE WE WERE ON A MAJOR HIGHWAY, DECREASING OUR SPEE…
Read full complaint
THIS WAS THE THIRD TURBO FAILURE SINCE OUR PURCHASE OF THIS RV VEHICLE: 2006 ITASCA NAVION, WITH THE DODGE/MERCEDES BENZ SPRINTER. THE FIRST FAILURE WAS IN SEPT. , '05, ABOUT 1 1/2 MONTHS AFTER OUR PURCHASE. THE SECOND WAS IN AUGUST, '06. EACH TIME, IT LOST POWER SUDDENLY, WHILE WE WERE ON A MAJOR HIGHWAY, DECREASING OUR SPEED IMMEDIATELY TO APPROXIMATELY 30-35 MPH IF ON A DOWNHILL OR STRAIGHT ROAD. IT HAD NO POWER TO CLIMB EVEN A SLIGHT INCLINE. EACH TIME, THE RESONATOR HAD TO BE REPLACED. WE HAVE MET OTHER OWNERS OF THE SAME TYPE OF VEHICLE WHO HAVE HAD SIMILAR EXPERIENCES. ALL HAVE BEEN TOLD BY MECHANICS THAT THIS MOTOR WAS A POOR DESIGN; THAT WE COULD PURCHASE AND CARRY A SPARE RESONATOR WITH US FOR FUTURE FAILURES. THIS IS NOT ACCEPTABLE AND WILL CERTAINLY NOT KEEP US SAFE ON THE ROADS. *TR
NHTSA ODI #10206392
6,858 miles · Sep 14, 2007
Engine And Engine Cooling
CRACKED TURBO RESONATOR TUBE RESULTS IN LOSS OF POWER. VEHICLE GOES INTO "LIMP HOME MODE" RESULTING IN VEHICLE SLOW DOWN AND SPEED BELOW POSTED MINIMUMS, PARTICULARLY ON UPHILL EXPRESSWAY GRADES. *TR
NHTSA ODI #10203001
1,745 miles · Sep 14, 2007
Engine And Engine Cooling
CRACKED TURBO RESONATOR TUBE RESULTS IN LOSS OF POWER. VEHICLE GOES INTO "LIMP HOME MODE" RESULTING IN VEHICLE SLOW DOWN AND SPEED BELOW POSTED MINIMUM ON UPHILL EXPRESSWAY GRADES. *TR
NHTSA ODI #10202996
4,500 miles · Aug 23, 2007
Engine And Engine Cooling
THE TURBO RESONATOR/MANIFOLD OF MY ITASCA NAVION MOTORHOME FAILED CAUSING IMMEDIATE LOSS OF POWER AND INABILITY TO SHIFT THE TRANSMISSION. THIS FAILURE IS CAUSED BY A CRACK IN THE PLASTIC RESONATOR PART. WHEN THEFAILURE OCCURS (RANDOMLY) THE IMMEDIATE LOSS OF POWER MAY PLACE THE MOVING VEHICLE IN DANGER OF BEING REAR ENDED OR HE…
Read full complaint
THE TURBO RESONATOR/MANIFOLD OF MY ITASCA NAVION MOTORHOME FAILED CAUSING IMMEDIATE LOSS OF POWER AND INABILITY TO SHIFT THE TRANSMISSION. THIS FAILURE IS CAUSED BY A CRACK IN THE PLASTIC RESONATOR PART. WHEN THEFAILURE OCCURS (RANDOMLY) THE IMMEDIATE LOSS OF POWER MAY PLACE THE MOVING VEHICLE IN DANGER OF BEING REAR ENDED OR HEAD ON COLLISION IF IN THE ACT PF PASSING ANOTHER VEHICLE. THERE ARE MANY CASES OF THIS FAILURE REPORTED ON THE INTERNET AT "TOPIX" AND "DODGE FORUM". I AM UNABLE TO GET ANY SUPPORT OR HELP FROM THE VEHICLE MANUFACTURER (WINNEBAGO ITASCA) OR FROM DODGE CUSTOMER SERVICE. THE FAILURE IS EPIDEMIC AND BECOMING A HAZARD UNLESS A FIX IS DESIGNED TO RETROFIT THIS FAILING PART. PLEASE ADVISE AS TO WHAT ACTIONS I CAN TAKE AS A CONSUMER AND WHAT ACTIONS IF ANY THAT THE NHTSA CAN TAKE. THANKYOU *TR
NHTSA ODI #10200616
15,000 miles · Dec 31, 2006
Engine And Engine Cooling
DODGE SPRINTER IT IS A WINNEBAGO NAVION (MOTOR HOME) THE TURBO RESONATOR FAILED AND I WAS ON THE INTERSTATE AND I LOST A LOT OF POWER ON A HILL IT WAS VERY DANGEROUS TO DRIVE BECAUSE OF LOSS OF POWER. *NM
NHTSA ODI #10177431
2,900 miles · Jun 8, 2006
Latches/locks/linkages
THE 100LB OUTSIDE STORAGE CONTAINER LOCATED OM THE PASSENGER SIDE OF MY ITASCA NAVION, H MODEL HAS SLID OUT TO THE OPEN POSITION TWICE WHILE DRIVING. THIS IS A SAFETY ISSUE THAT REQUIRES A FIX BEFORE SOMEONE IS SERIOUSLY INJURED. *JB
NHTSA ODI #10159324
1,647 miles · Apr 16, 2006
Latches/locks/linkagesCrash
2006 ITASCA NAVION UNDERCARRIAGE STORAGE BIN LATCH DID NOT HOLD WHILE DRIVING. BIN SLID OPEN AND HIT TREE, SHEARING OFF THE STORAGE BIN AND LOWER SIDE PANELS. *NM
NHTSA ODI #10155428
3,000 miles · Nov 1, 2005
Latches/locks/linkagesCrash
THERE IS NO VISUAL INDICATION WHETHER THE EXTERIOR "COOLER" STORAGE AREA IS LATCHED OR UNLATCHED. IF UNLATCHED, STORAGE AREA CAN EXTEND WHILE DRIVING, ENDANGERING PEDESTRIANS, BICYCLISTS, OR CAUSING PROPERTY DAMAGE. *NM
WINNEBAGO IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 WINNEBAGO VIEW AND ITASCA NAVION MOTOR HOMES BECAUSE THE DINETTE AREA SEAT BELT RESTRAINTS ON THOSE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." IN A COLLISION, THE GENERATED CRASH FORCES CAN CAUSE THE RESTRAINT'S ATTACHMENT TO TEAR AND ALLOW THE ANCHOR TO SEPARATE FROM THE BODY OF THE VEHICLE.
Consequence & remedy
Consequence: IF THE RESTRAINT SEPARATES FROM THE VEHICLE DURING A CRASH, THE BELT WILL NOT PROPERLY RESTRAIN THE SEAT OCCUPANT, INCREASING THE RISK OF INJURY OR DEATH TO THE OCCUPANT.
Remedy: WINNEBAGO WILL ADD ADDITIONAL SEAT BELT ANCHORAGES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 12, 2010. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.
ON CERTAIN MOTOR HOMES, THE EXTERIOR SLIDEOUT STORAGE DRAWER CAN INADVERTENTLY SLIDE OUT DURING NORMAL HIGHWAY OPERATION.
Consequence & remedy
Consequence: THIS COULD IMPACT NEARBY PERSONS OR OBJECTS RESULTING IN PERSONAL INJURY AND/;OR VEHICLE AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A SECONDARY CATCH ON THESE MOTOR HOMES. THE RECALL BEGAN ON JUNE 15, 2007. OWNERS MAY CONTACT WINNEBAGO AT 1-614-585-3535.
ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC STEPS, THE STEPS MAY HAVE BEEN MANUFACTURED WITH DEFECTIVE STEP CONTROL UNITS.
Consequence & remedy
Consequence: THE DEFECTIVE CONTROL UNITS COULD DEVELOP AN ELECTRICAL SHORT ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE, POSSIBLY RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT THE KWIKEE STEP AND REPLACE THE STEP CONTROL UNIT, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 23, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.
ON CERTAIN MOTOR HOMES EQUIPPED WITH OPTIONAL REAR SUSPENSION AIR BAGS, THE UPPER MOUNT CAN MOVE AND CONTACT THE TIRE.
Consequence & remedy
Consequence: THIS COULD DAMAGE THE TIRE AND CAUSE VEHICLE INSTABILITY WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A REAR SUSPENSION AIR BAG UPPER MOUNT REINFORCEMENT KIT. THE RECALL BEGAN ON JUNE 17, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-6939.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE10048 · Hitch Receiver Fracture
Opened Dec 7, 2010 · Closed Dec 3, 2013
Status: closed (inferred from source dates) · Trailer Hitches
During this investigation, ODI identified 29 reports of cracked and/or fractured hitch receiver assemblies installed on the subject vehicles.The majority (27 of 29) of the reported hitch incidents occurred prior to the initiation of PE10-048 in December, 2010.This investigation has been characterized by (1) Scant forensic samples available for inspection and review since most of the reported incidents occurred prior to ODI?s investigation and pertinent material has been scrapped; (2) Uncertainty regarding the contributory role of issues such as unintended hitch contact with road surfaces, use of hitches with offsets that exceed Winnebago recommendations; and (3) Other usage factors.Based on reported failures, the indicated failure rate for detected and reported cracking /fracture incidents associated with the estimated population of subject vehicles was found to be 0.10% after the vehicles had been in service for between 6 and 8 years.Reports were higher in calendar year 2007 (9 reports) than in succeeding years 2008-2010 (3-5 reports per year) and 2011 (2 reports) and appear likely to decline further due to diminished use associated with vehicle aging.ODI is aware of only one consumer complaint (ODI# 10368002) in its files describing a hitch receiver malfunction in Winnebago-Itasca vehicles.As of September 2013, Winnebago has reported that there have been no additional incidents of cracked or fractured hitch receivers reported since the most recent incident reported in May 2011.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.For more detailed information, see the attached closing report.
PE06058 · Cargo Door Extending During Travel
Opened Dec 14, 2006 · Closed Apr 18, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages
WINNEBAGO HAS FILED DEFECT REPORT 07V-163 WHICH OUTLINES WINNEBAGO'S INTENTION TO INSTALL SECONDARY LATCHES ON THE AFFECTED CARGO DOORS OF THE AFFECTED VEHICLES.ODI BELIEVES THAT THE PROPOSED SECONDARY LATCH WILL PROVIDE A MORE RELIABLE LATCHING SYSTEM (1) FOR OWNERS WHO MAY INADVERTENTLY FAIL TO SECURE THE PRIMARY LATCH AND/OR (2) AS A REDUNDANT RETENTION MEANS FOR SITUATIONS IN WHICH A CARGO DOOR BECOMES MISALIGNED, DISTORTED, AND/OR DAMAGED IN A WAY THAT COMPROMISES THE INTEGRITY OF THE PRIMARY LATCH SYSTEM.
2006 Itasca Navion Problems, Complaints & Recalls | Skip That Year
Illustration