IllustrationFRAME RUST. *TR
1999 Isuzu Rodeo
Owner reports · Recalls · Investigations
More warning signs than most Rodeo years
Owner complaints for the 1999 Isuzu Rodeo are substantially higher than the model-year median of 89.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rodeo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
3725–50K
6750–75K
2875–100K
59100–150K
43150K+
253 reports with mileage · 297 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 193 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 85 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
76 crash reports8 fire reports24 injury reports
Suspension complaints
85 reportsFUEL SENDING UNIT/GAS GAUGE LIGHT FLASHING EMPTY WHEN CAR IS FULL OF GAS. ABS LIGHT NEVER GOES OUT ...HAD RECALL REPAIRED DASH LIGHTS..CAR IS IN PARK BUT LIGHT ON DASH IS IN (N)..LIGHT ON GEAR SHIFT IS DEAD REAR WINSHIELD WIPER JUST STOPPED WORKING RUBBER SEAL AROUND REAR HATCHBACK WINDOW DRY ROTTED CAUSING WINDOW TO SHATTER A…
Read full complaint
FUEL SENDING UNIT/GAS GAUGE LIGHT FLASHING EMPTY WHEN CAR IS FULL OF GAS. ABS LIGHT NEVER GOES OUT ...HAD RECALL REPAIRED DASH LIGHTS..CAR IS IN PARK BUT LIGHT ON DASH IS IN (N)..LIGHT ON GEAR SHIFT IS DEAD REAR WINSHIELD WIPER JUST STOPPED WORKING RUBBER SEAL AROUND REAR HATCHBACK WINDOW DRY ROTTED CAUSING WINDOW TO SHATTER AND BREAK WHILE CAR WAS SITTING IN DRIVEWAY. THIS IS DANGEROUS. CAR SLIDING THROUGH STOP LIGHT WHEN APPLYING BRAKES TO STOP OR WHEN SITTING STILL CAR WILL IDLE AND CAUSE CAR TO MOVE WHILE FOOT IS ON BRAKES. HUMMING/RATTLING SOUND COMING FROM UNDERCARRIAGE OF THESE COMPLAINTS ARE POSTED ON SEVERAL COMPLAINT WEBSITES AND THEY ALL PERTAIN TO MY 1999 RODEO AS WELL AS THOUSANDS OF OTHERS. MY RODEO WAS PURCHASED IN 2003 AND I WAS NOT AWARE OF ANY RECALLS EXCEPT FOR THE ABS ONE AND I LEARNED ABOUT THAT FROM A RELATIVE WHO HAS THE SAME VEHICLE. IF SOMETHING BREAKS DOWN OR STOPS WORKING ON HERS I CAN EXPECT IT TO OCCUR WITH MINE OR VISA VERSA. SOMETHING NEEDS TO BE DONE..I WILL NEVER RECOMMEND ANYONE TO PURCHASE AN ISIZU RODEO IF MY LIFE DEPENDED ON IT. EVERYTIME I TAKE IT TO A MECHANIC THERE IS A RODEO IN THE GARAGE WAITING TO BE WORKED ON. THE MECHANIC SHAKES HIS HEAD.. *TR
DT: THE CONTACT S OWNS A 1999 ISUZU RODEO. HE RECEIVED A RECALL ON 10-14-05 REGARDING THE BRAKES ON THE VEHICLE. THE CONTACT HAS NOT TAKEN THE CAR ITO DEALER TO HAVE THE RECALL REPAIR WORK DONE. THE CONTACT'S VEHICLE WAS INVOLVED IN AN ACCIDENT ONE YEAR AGO. A CHILD RAN O IN FRONT OF VEHICLE, HE SWERVED TO MISS THE CHILD, HI…
Read full complaint
DT: THE CONTACT S OWNS A 1999 ISUZU RODEO. HE RECEIVED A RECALL ON 10-14-05 REGARDING THE BRAKES ON THE VEHICLE. THE CONTACT HAS NOT TAKEN THE CAR ITO DEALER TO HAVE THE RECALL REPAIR WORK DONE. THE CONTACT'S VEHICLE WAS INVOLVED IN AN ACCIDENT ONE YEAR AGO. A CHILD RAN O IN FRONT OF VEHICLE, HE SWERVED TO MISS THE CHILD, HIT THE BRAK THEY DID NOT WORK, AND THE VEHICLE HIT A TELEPHONE POLE. A POLICE REPORT WAS TAKEN. HE FELT THAT THE ACCIDENT CAUSED OTHER DAMAGE TO THE CAR, SUCH AS TRANSMISSION SLIPPING. HE NOTICED THE TRANSMISSION SLIPPING ABOUT FIVE MONTHS AGO. HAD TO DO A LOT OF REPAIR WORK TO THE FRONT END OF THE VEHICLE ABOUT FIVE MONTHS AGO AIR BAGS DEPLOYED ,AND HE HAS NOT HAD THEM INSTALLED AGAIN.*AK
WHILE DRIVING A LOUD KNOCKING NOISE WAS HEARD COMING FROM THE FRONT. CONSUMER PULLED OVER. BUT THE NOISE WAS NOT DUPLICATED WHILE THE VEHICLE WAS PARKED AND RUNNING. CONSUMER DROVE THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE DRIVER AND PASSENGER UPPER BALL JOINTS NEEDED TO BE REPLACED. *AK
SIGNIFICANT VIBRATION IN STEERING WHEEL AT HIGHWAY SPEEDS. *AK
I PURCHASED A NEW 1999 RODEO WHICH CURRENTLY HAS APPROX. 50,745 MILES. 2ND DAY OF OWNING THE VEHICLE, CHECK ENGINE LIGHT STAYED ON, TOOK IT TO THE DEALERSHIP WHICH "FIXED" THE PROBLEM; DRIVING OUT OF THE LOT FOR THE SECOND TIME, LIGHT CAME BACK ON, TOOK THE DEALERSHIP 1 WEEK TO TRY AND FIGURE OUT WHAT WAS WRONG WITH THE CAR. FOR…
Read full complaint
I PURCHASED A NEW 1999 RODEO WHICH CURRENTLY HAS APPROX. 50,745 MILES. 2ND DAY OF OWNING THE VEHICLE, CHECK ENGINE LIGHT STAYED ON, TOOK IT TO THE DEALERSHIP WHICH "FIXED" THE PROBLEM; DRIVING OUT OF THE LOT FOR THE SECOND TIME, LIGHT CAME BACK ON, TOOK THE DEALERSHIP 1 WEEK TO TRY AND FIGURE OUT WHAT WAS WRONG WITH THE CAR. FORTUNATELY, THAT PROBLEM WAS CORRECTED. NOW, THE FUEL GAUGE INDICATOR LIGHT CONTINUOUSLY FLASHES OR STAYS ON WHEN TANK IS FULL, MAKING IT VERY DIFFICULT TO KNOW HOW MUCH GAS IS REALLY IN THE TANK. NOT TO MENTION THE ANXIETY TRYING TO REMEMBER WHEN I LAST FILLED THE TANK AND HOW MUCH FUEL IT TOOK.CAR VIBRATES AT SPEEDS HIGHER THAN 55MPH STEERING WHEEL JUST SHAKES. PROBLEM WITH THE ANTI LOCK BRAKING SYSTEM. WHILE DRIVING OVER WET SURFACES OR BUMPS, ANTI LOCK BRAKES SEEM TO SLIDE CAUSING VEHICLE TO CONTINUE TO MOVE AFTER BRAKE HAS BEEN APPLIED. TIMING BELT WAS CRACKED AND HAD TO BE REPLACED WITHOUT EVER RECEIVING ANY NOTIFICATION FROM ISUZU THEREFORE, I HAD TO ABSORB THE COST OF REPLACING A DEFECTIVE ITEM ORIGINALLY INSTALLED BY THE MANUFACTURER. HOPING ISUZU WILL REIMBURSE. I HAVE NOT RECEIVED ANY RECALL NOTICES SINCE I PURCHASED THE VEHICLE IN 1999. *AK
THIS CAR IS A LEMON. THERE SEEM TO BE MAJOR ELECTRICAL ISSUES. THE DASH LIGHTS ARE GOING OUT, THERE IS A PROBLEM WITH THE POWER SHIFT INDICATOR - THE CAR CAN BE IN "DRIVE", YET THE INDICATOR WILL HAVE "NEUTRAL" DISPLAYED. THIS CAUSES THE CAR TO JERK WHILE SHIFTING. THE REAR SUSPENSION HAS A VIBRATING SOUND NO ONE HAS FIGURED…
Read full complaint
THIS CAR IS A LEMON. THERE SEEM TO BE MAJOR ELECTRICAL ISSUES. THE DASH LIGHTS ARE GOING OUT, THERE IS A PROBLEM WITH THE POWER SHIFT INDICATOR - THE CAR CAN BE IN "DRIVE", YET THE INDICATOR WILL HAVE "NEUTRAL" DISPLAYED. THIS CAUSES THE CAR TO JERK WHILE SHIFTING. THE REAR SUSPENSION HAS A VIBRATING SOUND NO ONE HAS FIGURED OUT......THE DEALER CLAIMS THE SUSPENSION IS FINE. IN ADDITTION, THE REAR DRUM BRAKES CONTINUALLY GO OUT.*AK
WHEN TURNING OFF ENGINE, CONSUMER STATES' ABS PUMP CONTINUES TO RUN. CONSUMER HAS TO DISCONNECT PUMP IN ORDER FOR PUMP TO STOP RUNNING. TOOK TO DEALER AND THE DEALER DISCONNECTED THE ABS MODULATOR. NOW THE ABS LIGHT IS ON. PLEASE PROVIDE ANY FURTHER INFORMATION. MR
VEHICLE SHIMMIES AT 60+ MPH, HAS CONTINUALLY PULLED TO THE LEFT. THE TIRES HAVE BEEN BALANCED AND THE FRONT END ALIGNED NUMEROUS TIMES. PROBLEM STILL EXISTS. CAUSES SEVERE AND UNEVEN WEAR ON TIRES. HUMMING NOISE OCCURS WHEN VEHICLE DRIVEN IN EXCESS OF 20+ MINUTES. PRIVATE MECHANIC STATED IT WAS THE FUEL PUMP. WHEN TAKEN TO THE D…
Read full complaint
VEHICLE SHIMMIES AT 60+ MPH, HAS CONTINUALLY PULLED TO THE LEFT. THE TIRES HAVE BEEN BALANCED AND THE FRONT END ALIGNED NUMEROUS TIMES. PROBLEM STILL EXISTS. CAUSES SEVERE AND UNEVEN WEAR ON TIRES. HUMMING NOISE OCCURS WHEN VEHICLE DRIVEN IN EXCESS OF 20+ MINUTES. PRIVATE MECHANIC STATED IT WAS THE FUEL PUMP. WHEN TAKEN TO THE DEALER, SEVERAL TIMES, NOTHING WAS FOUND.*AK
VEHICLE SHIMMIES AT 60-65, TIRES WERE REPLACED AND WHEELS BALANCED, DID NOT REMEDY THE PROBLEM.*AK
Official recalls
310V436000 · Suspension:rear
Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
00V121001 · Structure:body
Apr 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE PERFORMANCE REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, PERSONAL INJURY COULD OCCUR.
Remedy: DEALERS WILL MODIFY THE INTERIOR OF YOUR VEHICLE.
00V058000 · Suspension:rear
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available