TL* THE CONTACT OWNS A 1999 ISUZU RODEO. THE CONTACT STATED THAT THERE WAS EXTENSIVE RUST AND CORROSION ON THE UNDERCARRIAGE OF THE FRAME. IN ADDITION, THE CONTROL ARMS ON THE REAR OF THE VEHICLE EXHIBITED THE SAME CONDITION. THE DEALER (MANCARI'S CHRYSLER, DODGE, JEEP, RAM, 708-423-0910, LOCATED AT 4630 W 95TH STREET, OAK LAWN,…
Read full complaint
TL* THE CONTACT OWNS A 1999 ISUZU RODEO. THE CONTACT STATED THAT THERE WAS EXTENSIVE RUST AND CORROSION ON THE UNDERCARRIAGE OF THE FRAME. IN ADDITION, THE CONTROL ARMS ON THE REAR OF THE VEHICLE EXHIBITED THE SAME CONDITION. THE DEALER (MANCARI'S CHRYSLER, DODGE, JEEP, RAM, 708-423-0910, LOCATED AT 4630 W 95TH STREET, OAK LAWN, IL 60453) WAS CONTACTED AND INDICATED THAT THEY WERE NO LONGER AUTHORIZED TO SERVICE ISUZU VEHICLES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS WAITING TO RECEIVE A RECOMMENDED DEALER TO DIAGNOSE AND REPAIR THE VEHICLE. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
NHTSA ODI #11133276
201,000 miles · Aug 6, 2018
Suspension
I HAD JUST COME OFF THE HIGHWAY IN MY RODEO AND COME TO A SLOWDOWN ON THE ENTRANCE RAMP TO THE MAIN ROAD AND WHEN I WENT TO TAKE OFF MY TORSION BAR THAT HOLDS MY REAR AXLE IN ON THE DRIVER SIDE COMPLETELY BROKE OFF FROM RUST AND THERE ARE SEVERAL BIG HOLES OF RUST ON THE FRAME OF THIS VEHICLE I HAVE NOTICED BY SEARCHING ON THE I…
Read full complaint
I HAD JUST COME OFF THE HIGHWAY IN MY RODEO AND COME TO A SLOWDOWN ON THE ENTRANCE RAMP TO THE MAIN ROAD AND WHEN I WENT TO TAKE OFF MY TORSION BAR THAT HOLDS MY REAR AXLE IN ON THE DRIVER SIDE COMPLETELY BROKE OFF FROM RUST AND THERE ARE SEVERAL BIG HOLES OF RUST ON THE FRAME OF THIS VEHICLE I HAVE NOTICED BY SEARCHING ON THE INTERNET THAT THIS IS A MAJOR PROBLEM WITH THESE VEHICLES WHICH SHOULD BE RECALLED AND A PAYMENT GIVEN IN FAIRNESS TO THE OWNERS OF THESE VEHICLES FORD HAD THE SAME PROBLEMS WITH THE EARLY 2000S WIND STARS AND I OWN ONE OF THESE WHEN IT WAS TAKEN INTO FORD BECAUSE I RECEIVED A LETTER FROM FORD THEY WOULD NOT RELEASE THE VEHICLE BACK TO ME AND PAID ME FOR THE VEHICLE THIS IS ONLY FAIR THAT ISUZU DOES THIS TO GET THESE UNSAFE VEHICLES OFF THE ROAD I AM SO SURPRISED SOMEONE HAS NOT BEEN KILLED
NHTSA ODI #11118178
169,000 miles · Apr 3, 2017
Suspension
TL* THE CONTACT OWNS A 1999 ISUZU RODEO. WHILE DRIVING 40 MPH, THE VEHICLE FISHTAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT NOTIFIED THE POLICE, BUT A POLICE REPORT WAS NOT FILED. THE CONTACT BELIEVED THAT NHTSA CAMPAIGN NUMBER: 10V4360…
Read full complaint
TL* THE CONTACT OWNS A 1999 ISUZU RODEO. WHILE DRIVING 40 MPH, THE VEHICLE FISHTAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT NOTIFIED THE POLICE, BUT A POLICE REPORT WAS NOT FILED. THE CONTACT BELIEVED THAT NHTSA CAMPAIGN NUMBER: 10V436000 (SUSPENSION) SHOULD APPLY TO THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER ADVISED THE CONTACT THAT HE DID NOT MEET THE GUIDELINES FOR THE RECALL. THE FAILURE MILEAGE WAS 169,000.
NHTSA ODI #10970161
Mileage unknown · Jun 22, 2016
Suspension
FRAME IS DANGEROUSLY RUSTED COMPLETELY.
NHTSA ODI #10875862
99,000 miles · Sep 19, 2015
Suspension
THE FRAME IS RUSTED ON MY VEHICLE AND HAS BROKE. I UNDERSTAND THERE IS A RECALL ON THIS VEHICLE
NHTSA ODI #10765306
130,000 miles · Jun 25, 2015
Suspension
TL* THE CONTACT OWNS A 1999 IZUZU RODEO. WHILE DRIVING 30 MPH, THE FORWARD MOUNTING BRACKET FOR THE REAR SUSPENSION ON THE DRIVER SIDE DETACHED FROM THE VEHICLE, CAUSING IT TO VEER TO THE RIGHT. THE CONTACT ALSO NOTICED CORROSION AROUND THE DETACHMENT AREA. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DI…
Read full complaint
TL* THE CONTACT OWNS A 1999 IZUZU RODEO. WHILE DRIVING 30 MPH, THE FORWARD MOUNTING BRACKET FOR THE REAR SUSPENSION ON THE DRIVER SIDE DETACHED FROM THE VEHICLE, CAUSING IT TO VEER TO THE RIGHT. THE CONTACT ALSO NOTICED CORROSION AROUND THE DETACHMENT AREA. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.
NHTSA ODI #10730317
130,000 miles · Jul 10, 2014
Electrical SystemSuspension
TL- THE CONTACT OWNS A 1999 ISUZU RODEO. THE CONTACT STATED THAT THE VEHICLE STALLED AND THE KEY FAILED TO TURN IN THE IGNITION SPORADICALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE STARTER WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. IN A…
Read full complaint
TL- THE CONTACT OWNS A 1999 ISUZU RODEO. THE CONTACT STATED THAT THE VEHICLE STALLED AND THE KEY FAILED TO TURN IN THE IGNITION SPORADICALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE STARTER WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. IN ADDITION, THE CONTACT MENTIONED THAT THE SUSPENSION WAS CAUSING THE VEHICLE TO SWAY INTERMITTENTLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION). THE APPROXIMATE FAILURE MILEAGE WAS 130,000. PAM
NHTSA ODI #10609577
124,000 miles · Apr 14, 2014
Suspension
FOUND THE FRAME IS ROTTED AT THE REAR MOUNT FOR THE REAR SUSPENSION, CAR IS NOT USABLE. I HAD SOLD THE CAR AND IT WAS RETURNED THE RUST IS SO BAD. *JS
NHTSA ODI #10579597
151,000 miles · Apr 2, 2014
StructureSuspension
WHILE SLOWLY DRIVING ON OUR HOME STREET I WENT OVER A SMALL BUMP IN THE ROAD AND HEARD A LOUD NOISE FROM UNDER THE VEHICLE. OUR MECHANIC ADVISED US THE REAR DRIVER SIDE OF THE FRAME HAD SNAPPED. THE REAR SHOCK ON THAT SIDE PULLED OFF THE FRAME DUE TO THE EXCESSIVE RUST. THE OTHER SIDE SHOWS SIGNS OF EXCESSIVE RUST ALSO. THE …
Read full complaint
WHILE SLOWLY DRIVING ON OUR HOME STREET I WENT OVER A SMALL BUMP IN THE ROAD AND HEARD A LOUD NOISE FROM UNDER THE VEHICLE. OUR MECHANIC ADVISED US THE REAR DRIVER SIDE OF THE FRAME HAD SNAPPED. THE REAR SHOCK ON THAT SIDE PULLED OFF THE FRAME DUE TO THE EXCESSIVE RUST. THE OTHER SIDE SHOWS SIGNS OF EXCESSIVE RUST ALSO. THE CAR IS NOW NOT PASSABLE FOR VEHICLE INSPECTION AND IS UNSAFE TO DRIVE. THE REST OF THE CAR LOOKS GREAT. *TR
NHTSA ODI #10576695
Mileage unknown · Mar 29, 2014
StructureSuspension
[ I BOUGHT A 1999 RODEO FROM TRADER MIKE'S AUTO SALE'S. THE RODEO HAS A RUSTED OUT FRAME WHICH IS UNSAFE FOR DRIVING. I PAID 1,643.75 FOR THE 1999 RODEO AND DEALER PUT 700.00 ON TITLE. I'VE SPENT OVER 1,200 IN IT BEFORE I FOUND THE FRAME RUSTED AND BROKE. I TRY ASKING HIM NICELY TO REFUND MY MONEY FOR THE1999 RODEO VIN-[X…
Read full complaint
[ I BOUGHT A 1999 RODEO FROM TRADER MIKE'S AUTO SALE'S. THE RODEO HAS A RUSTED OUT FRAME WHICH IS UNSAFE FOR DRIVING. I PAID 1,643.75 FOR THE 1999 RODEO AND DEALER PUT 700.00 ON TITLE. I'VE SPENT OVER 1,200 IN IT BEFORE I FOUND THE FRAME RUSTED AND BROKE. I TRY ASKING HIM NICELY TO REFUND MY MONEY FOR THE1999 RODEO VIN-[XXX] AND THE MONEY I SPENT ON THIS UNSAFE 1999 RODEO. I DIDNT SIGN THE OTHER AS IS FORM FROM DEALERSHIP, JUST THE BILL OF SALE'S BILL OF SALE'S GIVE ONE PRICE AND TITLE SAYS ANOTHER. SO NOT ONLY I GOT HURT IN THE SALE SO DID THE V M B . IT'S NOT THE WAY TO DO GOOD BUSSNESS. HE OWES ME 2,843.75 FOR HIS JUNK 1999 RODEO HE SOLD ME FEB.17TH 2014. NOT MY FAULT HE SOLD IT TO ME AND SAID IT WAS A GOOD 1999 RODEO YOU DONT SELL A DEATH TRAP RUSTED OUT FRAME 1999 RODEO 4X4 TO SOMEONE WHO'S DISABLE, OR ANYONE ELSE YOU NEED TO CHECK THINGS OUT BEFORE YOU SELL IT. HE SAID HE WOULD HAVE TO JUNK IT IF HE TOOK IT BACK. AND HE WONT, I GUESS BETTER SOMEONE ELSE THAN HIM BE OUT. TRADER MIKE'S AUTO SALE'S 634 EAST ELM STREET , WASHINGTON COURT HOUSE OHIO. 740-333-1709 CELL [XXX]. DEALER'S PERMIT [XXX] - VENDOR'S [XXX] . NEED HIM TO RESOLVED THIS MATTER. MARCH 8TH 2014 THANKYOU 1,643.75 FOR 1999 RODEO 1,200 FOR PARTS FOR RODEO INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE PERFORMANCE REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, PERSONAL INJURY COULD OCCUR.
Remedy: DEALERS WILL MODIFY THE INTERIOR OF YOUR VEHICLE.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
1999 Isuzu Rodeo Problems, Complaints & Recalls | Skip That Year
Illustration