IllustrationTHE DEALER INDICATED THAT THE PARTS FOR BRAKE RECALL 02I- 002000 WOULD NOT BE AVAILABLE IN A REASONABLE AMOUNT OF TIME. *NLM
1999 Isuzu Rodeo
Owner reports · Recalls · Investigations
More warning signs than most Rodeo years
Owner complaints for the 1999 Isuzu Rodeo are substantially higher than the model-year median of 89.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rodeo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
3725–50K
6750–75K
2875–100K
59100–150K
43150K+
253 reports with mileage · 297 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 193 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 85 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
76 crash reports8 fire reports24 injury reports
Service Brakes, Hydraulic complaints
193 reportsMULTIPLE OCCURRENCES OF BRAKE/ABS MALFUNCTION WHEN APPLYING BRAKES, WITH THE VEHICLE IN MOTION AT RELATIVELY LOW SPEEDS - APPROX LESS THAN 20 MPH. IN EACH OCCURRENCE THE BRAKE PEDAL STRONGLY RESISTS FOOT PRESSURE, BRAKING ACTION IS MINIMAL-TO-NONEXISTENT, AND THE ABS UNIT EMITS A GROANING/GRINDING SOUND FROM VICINITY OF THE ENG…
Read full complaint
MULTIPLE OCCURRENCES OF BRAKE/ABS MALFUNCTION WHEN APPLYING BRAKES, WITH THE VEHICLE IN MOTION AT RELATIVELY LOW SPEEDS - APPROX LESS THAN 20 MPH. IN EACH OCCURRENCE THE BRAKE PEDAL STRONGLY RESISTS FOOT PRESSURE, BRAKING ACTION IS MINIMAL-TO-NONEXISTENT, AND THE ABS UNIT EMITS A GROANING/GRINDING SOUND FROM VICINITY OF THE ENGINE COMPARTMENT. IN THESE SITUATIONS THERE IS A HIGH RISK OF COLLISION WITH STATIONARY VEHICLES AHEAD IN TRAFFIC. AS GREATER PRESSURE IS APPLIED TO THE BRAKE PEDAL IN AN ATTEMPT TO STOP THE VEHICLE, IN SOME INSTANCES THE FAULTY ABS ACTION ABRUPTLY ENDS - CAUSING THE VEHICLE TO JERK TO A SUDDEN STOP. THIS BEHAVIOR RISKS CAUSING A COLLISION BY CLOSELY FOLLOWING VEHICLES. AFTER EACH OF THESE MALFUNCTIONS, THE ABS LIGHT ON THE CONSOLE APPEARS AND THERE ARE NO FURTHER MALFUNCTIONS DURING THAT PARTICULAR TRIP. DRIVER HAS REMOVED THE ABS FUSE TO PREVENT THE PROBLEM FROM RE- OCCURRING. *NLM
THE ABS LIGHT ILLUMINATED, DEALER REPLACED THE MODULE, HOWEVER THE LIGHT REMAINED ON. *JB
THE BRAKES LOCKED UP, WHEN THEY WERE APPLIED, WHICH CAUSED THE VEHICLE TO EXPERIENCE EXTENDED STOPPING DISTANCE. *JB
I WAS NEVER INFORMED OF SOME RECALLS ON MY 1999 ISUZU RODEO. I AM HAVING SOME OF THE PROBLEMS STATED IN THE DESCRIPTION OF THE RECALLS. MY ABS BRAKE LIGHT IS GOING ON AND OFF AND I AM HAVING SOME TROUBLE STOPPING. MY CHECK ENGINE LIGHT IS COMING ON AND WHEN SITTING STILL THE CAR ACTS AS THOUGH IT IS GOING TO CUT OFF. IT IS R…
Read full complaint
I WAS NEVER INFORMED OF SOME RECALLS ON MY 1999 ISUZU RODEO. I AM HAVING SOME OF THE PROBLEMS STATED IN THE DESCRIPTION OF THE RECALLS. MY ABS BRAKE LIGHT IS GOING ON AND OFF AND I AM HAVING SOME TROUBLE STOPPING. MY CHECK ENGINE LIGHT IS COMING ON AND WHEN SITTING STILL THE CAR ACTS AS THOUGH IT IS GOING TO CUT OFF. IT IS RUNNING REALLY HARD WHEN I COME TO A STOP. I BELIEVE THAT THESE HAVE TO DO WITH THE RECALL. ANOTHER PROBLEM THAT I AM HAVING IS MY GAS GAUGE IS NOT REGISTERING HOW MUCH GAS IS IN THE CAR AND THE GAS LIGHT STAYS ON CONSTANTLY. I KNOW THAT IT IS FULL BECAUSE THE GAS PUMP STOPS. *NLM
THURSDAY, APRIL 3, 2003 MY 1999 ISUZU RODEO BEGAN MAKING UNUSUAL SOUNDS FROM INSIDE THE HOOD AND THE ABS LIGHT LIT UP ON THE DASHBOARD. UPON LOOKING UNDER THE HOOD, I DISCOVERED THE BRAKE MODULE WAS RUNNING DESPITE TURNING THE CAR OFF AND REMOVING THE KEY. THE ONLY WAY TO STOP THE MODULE FROM RUNNING WAS TO REMOVE THE NEGATIVE…
Read full complaint
THURSDAY, APRIL 3, 2003 MY 1999 ISUZU RODEO BEGAN MAKING UNUSUAL SOUNDS FROM INSIDE THE HOOD AND THE ABS LIGHT LIT UP ON THE DASHBOARD. UPON LOOKING UNDER THE HOOD, I DISCOVERED THE BRAKE MODULE WAS RUNNING DESPITE TURNING THE CAR OFF AND REMOVING THE KEY. THE ONLY WAY TO STOP THE MODULE FROM RUNNING WAS TO REMOVE THE NEGATIVE CABLE FROM THE BATTERY. I IMMEDIATELY CALLED THE CREST ISUZU DEALERSHIP IN PLANO, TEXAS AND SPOKE THE SERVICE DEPARTMENT ABOUT THE PROBLEM. THE TECHNICIAN'S FIRST RESPONSE WAS THAT I MAY QUALIFY FOR A FREE REPLACEMENT BECAUSE THERE WAS A "MANUFACTURER'S INSTALLATION PROBLEM" ON SOME OF THE RODEOS COMING FROM CERTAIN PLANTS. I GAVE HIM MY VIN NUMBER AND HE CAME BACK AND TOLD ME MY VIN NUMBER WAS NOT ON THE LIST. I FOUND IT ODD THAT ISUZU WOULD RECOGNIZE THAT SOME PARTS WERE DEFECTIVE, BUT NOT RESPOND TO MINE. MY NEXT STEP WAS TO CONTACT THE OWNER RELATIONS DEPARTMENT OF AMERICAN ISUZU MOTORS, INC. I INITIALLY SPOKE WITH DON WHO INFORMED ME THAT IN JULY, ISUZU WAS LAUNCHING A CAMPAIGN TO REPLACE ALL BRAKE MODULES IN 1999 ISUZU RODEOS. I WAS TOLD THIS WAS A SAFETY UPGRADE AND DID NOT MEAN THAT THE PART HAD ANY PROBLEMS. I WAS TOLD THAT I WOULD HAVE TO PAY FOR THE REPLACEMENT OF MY MODULE BECAUSE IT WAS NOT YET JULY. I AM BEING TOLD TWO SEPARATE STORIES FROM ISUZU EMPLOYEES. I NEED A WRITTEN RESPONSE FROM ISUZU EXPLAINING HOW MY DEFECTIVE BRAKE MODULE IS NOT RELATED TO THE CAMPAIGN TO REPLACE ALL BRAKE MODULES IN JULY. I DON'T THINK ISUZU WANTS TO BE RESPONSIBLE FOR ANY ACCIDENTS THAT MAY RESULT IN THE NEXT 3 MONTHS BECAUSE MY DEFECTIVE BRAKE MODULE WAS NOT ATTENDED TO. *NLM
I HAVE 1999 ISUZU RODEO. I GOT THE ABS KEEP RUNNING AND GOT A LIGHT ON PROBLEM RECENTLY AND I GOT THE ABS DIAGNOSTIC AT DEALER AND THEY SAID I HAVE ABS SHORT AND NEED TO REPLACE ABS MODULE. I CHECKED THE RECALL ON THIS VEHICLE AND FOUND ABS RECALL STARTING 1998 MODEL. I ALREADY HAVE THREE ACCIDENTS FROM EXTENDED STOPPING DIS…
Read full complaint
I HAVE 1999 ISUZU RODEO. I GOT THE ABS KEEP RUNNING AND GOT A LIGHT ON PROBLEM RECENTLY AND I GOT THE ABS DIAGNOSTIC AT DEALER AND THEY SAID I HAVE ABS SHORT AND NEED TO REPLACE ABS MODULE. I CHECKED THE RECALL ON THIS VEHICLE AND FOUND ABS RECALL STARTING 1998 MODEL. I ALREADY HAVE THREE ACCIDENTS FROM EXTENDED STOPPING DISTANCES BEFORE. IS IT POSSIBLE TO GET MINE TO GET THE RECALL SERVICE? *NLM
ABS INDICATOR ASSOCIATED WITH WIRE HARNESS. THIS PROBLEM WAS ASSOCIATED WITH 1998 MODELS AND SHOULD BE REVIEWED FOR 1999 MODELS TOO. ABS MODULE NEEDING REPLACING AT APPROXIMATELY 30,000 MILES. ALSO EXPERIENCE DELAY OR LAPSE TIME FOR VEHICLE TO STOP.
THE VEHICLE EXPERIENCED EXTENDED STOPPING DISTANCE. *NLM
IN AUGUST OF 2002 , I WAS DRIVING MY 1999 RODEO THAT I HAD LEASED NEW IN 2002 AND THIS RUNNING NOISE CONTINUED AFTER I TURNED OFF THE ENGINE. IT WAS THE ABS MODULE. IT HAD TO BE UNPLUGGED TO KEEP THE BATTERY FROM BEING RUN DOWN. THE REPAIR IS ABOUT $500.00 AND ISUZU WANTS TO IGNORE THAT THERE IS A PROBLEM WITH THIS COMPONENT. BE…
Read full complaint
IN AUGUST OF 2002 , I WAS DRIVING MY 1999 RODEO THAT I HAD LEASED NEW IN 2002 AND THIS RUNNING NOISE CONTINUED AFTER I TURNED OFF THE ENGINE. IT WAS THE ABS MODULE. IT HAD TO BE UNPLUGGED TO KEEP THE BATTERY FROM BEING RUN DOWN. THE REPAIR IS ABOUT $500.00 AND ISUZU WANTS TO IGNORE THAT THERE IS A PROBLEM WITH THIS COMPONENT. BEFORE THE NOISE STARTED,THE STOPPING DISTANCE WAS VERY LONG AND THERE WAS A POPPING FEELING IN THE BRAKE PEDAL. I TOOK IT IN TO THE DEALER AND WAS TOLD "NOTHING WAS WRONG AND THAT WAS THE WAY ANTI-LOCK BRAKES FELT" THE ABS LIGHT CAME ON. ALL OF THIS STARTED WITH 40,000 MILES ON THE VEHICLE. THERE IS A PROBLEM WITH THE RODEO THAT NEEDS TO BE ADDRESSED AND RECALLED BY ISUZU WITHOUT THE COST OF LIFE OR MONEY TO THE CONSUMER. *JB
Official recalls
310V436000 · Suspension:rear
Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
00V121001 · Structure:body
Apr 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE PERFORMANCE REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, PERSONAL INJURY COULD OCCUR.
Remedy: DEALERS WILL MODIFY THE INTERIOR OF YOUR VEHICLE.
00V058000 · Suspension:rear
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available