NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
478 reports6,500 miles · Jun 29, 2003
Visibility
1998 ISUZU RODEO LS. WITHIN A PERIOD OF 3 MONTHS, BOTH OF THE SWIVEL TYPE SIDE REAR VIEW MIRROR ASSEMBLIES HAVE SHOWN A DEFECT WHICH CAUSES THE INTERNAL SPRING MECHANISM TO FAIL AND RENDER THE UNITS INOPERABLE. THE MIRROR CASES COME LOOSE TO THE POINT OF NEARLY FALLING OFF THE BASE UNIT THAT IS ATTACHED TO THE DOOR. THE LEFT S…
Read full complaint
1998 ISUZU RODEO LS. WITHIN A PERIOD OF 3 MONTHS, BOTH OF THE SWIVEL TYPE SIDE REAR VIEW MIRROR ASSEMBLIES HAVE SHOWN A DEFECT WHICH CAUSES THE INTERNAL SPRING MECHANISM TO FAIL AND RENDER THE UNITS INOPERABLE. THE MIRROR CASES COME LOOSE TO THE POINT OF NEARLY FALLING OFF THE BASE UNIT THAT IS ATTACHED TO THE DOOR. THE LEFT SIDE WAS REPLACED 3 MONTHS AGO. RECENTLY THE SAME FAILURE HAS HAPPENED TO THE RIGHT SIDE ASSEMBLY. *NLM
NHTSA ODI #10025149
Mileage unknown · Jun 27, 2003
Latches/locks/linkagesService Brakes, HydraulicStructure
1998 ISUZU RODEO EXPERIENCED BRAKE FAILURE. *MR THE BRAKES WERE INTERMITTENT. THE BRAKE PEDAL WOULD GO TO THE FLOOR AND LOCK UP. A FEW DAYS LATER THE ABS LIGHT HAD COME ON. THE PROBLEM WAS DIAGNOSED AS A REAR BRAKE SENSOR AND WAS REPLACED. THE MOLDING ON THE DRIVER DOOR WAS LOOSE, THE LATCH ON THE CONSOLE HAD BROKEN, THE…
Read full complaint
1998 ISUZU RODEO EXPERIENCED BRAKE FAILURE. *MR THE BRAKES WERE INTERMITTENT. THE BRAKE PEDAL WOULD GO TO THE FLOOR AND LOCK UP. A FEW DAYS LATER THE ABS LIGHT HAD COME ON. THE PROBLEM WAS DIAGNOSED AS A REAR BRAKE SENSOR AND WAS REPLACED. THE MOLDING ON THE DRIVER DOOR WAS LOOSE, THE LATCH ON THE CONSOLE HAD BROKEN, THE SUNVISOR ON THE PASSENGER SIDE HAD FALLEN DOWN, AND THE CENTER CAPS ON THE FRONT WHEELS HAD PITTED. THE CONSUMER REQUESTED A BUY BACK AND OR TRADE IN. *SCC *JB
NHTSA ODI #10026402
Mileage unknown · Jun 27, 2003
Service Brakes, Hydraulic
THE ABS LIGHT ILLUMINATED AND STAYED ON . THE BRAKES SQUEAKED WHILE DRIVING. THE DEALER REPAIRED THE BRAAKES BUT THE LIGHT REMAINED ILLUMINATED. *NLM
NHTSA ODI #10025128
78,000 miles · Jun 25, 2003
Fuel System, Gasoline
FUEL SENDING UNIT INTERMITTENT AFTER FILL-UP, DURING DAILY DRIVING. GAS GAUGE READS EMPTY NEARLY ALL THE TIME REGARDLESS OF LEVEL OF FUEL. AFTER FILLING TANK GAUGE WILL RISE TO 1/2 THEN AS YOU DRIVE DAILY IT WILL READ EMPTY W/LOW FUEL WARNING ON OR IT WILL STAY AT 1/2 TANK THEN NEXT DAY DROP TO EMPTY. *NLM
NHTSA ODI #10023795
Mileage unknown · Jun 23, 2003
Service Brakes, HydraulicCrash
ANTI-LOCK BRAKES DO NOT WORK PROPERLY WHEN ONE TIRE HITS A SLIPPERY SURFACE CAUSING EXTENDED BRAKING DISTANCE. *NLM
NHTSA ODI #10023591
64,000 miles · Jun 23, 2003
Engine And Engine Cooling
PISTON ROD FAILURE. THE FIRST INCIDENT OCCURRED IN OR ABOUT JANUARY, 2003. THE ENGINE ON MY 1998 ISUZU RODEO BEGAN MAKING A LOUD CLANKING NOISE AND THE "CHECK OIL" LIGHT CAME ON. I ADDED A QUART AND THE NOISE SUBSIDED. I HAD THE OIL CHANGED THE NEXT DAY. A FEW MONTHS LATER, THE NOISE RETURNED AND I ADDED TWO QUARTS OF OIL…
Read full complaint
PISTON ROD FAILURE. THE FIRST INCIDENT OCCURRED IN OR ABOUT JANUARY, 2003. THE ENGINE ON MY 1998 ISUZU RODEO BEGAN MAKING A LOUD CLANKING NOISE AND THE "CHECK OIL" LIGHT CAME ON. I ADDED A QUART AND THE NOISE SUBSIDED. I HAD THE OIL CHANGED THE NEXT DAY. A FEW MONTHS LATER, THE NOISE RETURNED AND I ADDED TWO QUARTS OF OIL. THE NOISE DID NOT SUBSIDE AND I TOOK THE VEHICLE IN FOR ITS REGULARLY SCHEDULED OIL CHANGE THE NEXT DAY. THE OIL CHANGE MECHANIC TOLD ME THAT THERE WERE ONLY TWO QUARTS OF OIL IN THE ENGINE. I TOOK THE VEHICLE TO ANOTHER LOCAL MECHANIC TO REPAIR THE PROBLEM AND HE TOLD ME THE NO. 1 PISTON ROD HAD FAILED. WHEN HE CALLED HIS PARTS DISTRIBUTOR FOR A QUOTE ON A NEW OR REBUILT ENGINE, THE DISTRIBUTOR SAID, "'98 RODEO ENGINE? LET ME GUESS, IT'S THE NO.1 ROD" AND STATED THAT THIS WAS A VERY COMMON PROBLEM. I HAD THE CAR TOWED TO THE ISUZU DEALER WHERE I HAD PURCHASED THE CAR AND HAD ALMOST ALL REGULAR MAINTENANCE AND REPAIRS PERFORMED. THE DEALER WAS UNABLE TO GET THE ISUZU DISTRICT MANAGER TO OFFER ANY "GOOD FAITH" ASSISTANCE. THE CAR HAS APPROXIMATELY 64,000 MILES ON IT. I HAVE GENERALLY CHANGED THE OIL EVERY 3,000 MILES, ALTHOUGH ISUZU RECOMMENDS CHANGING IT EVERY 5,000 MILES. I HAVE FULL SERVICE RECORDS AND ALMOST ALL MAINTENANCE (EXCEPT FOR SOME OIL CHANGES) WAS DONE AT THE DEALER. *NLM
NHTSA ODI #10023583
Mileage unknown · Jun 19, 2003
Service Brakes, Hydraulic
CONSUMER RECEIVED A RECALL NOTICE # 02I002000 SUBJECT: ABS. CONSUMER CALLED THE DEALER AND MADE AN APPOINTMENT. WHEN THE CONSUMER GOT TO THE DEALER, THERE WERE NO PARTS AVAILABLE. THE DEALER SAID THEY WOULD CALL WHEN THE PARTS BECAME AVAILABLE. IT HAS BEEN TWO WEEKS AND THE CONSUMER HAS NOT RECEIVED A CALL.*AK
NHTSA ODI #10024427
Mileage unknown · Jun 18, 2003
Service Brakes, HydraulicCrash
WHILE PULLING INSIDE OF THE PARKING LOT APPLIED BRAKES AND RAN INTO THE VEHICLE FROM BEHIND. BRAKE PEDAL DID NOT HOLD, AND WENT ALL THE WAY DOWN TO THE FLOOR. *AK
NHTSA ODI #10024387
Mileage unknown · Jun 18, 2003
Service Brakes, Hydraulic
ABS LIGHT IS FLASHING CONSTANTLY, AND THERE IS A DELAY IN STOPPING WHEN BRAKES ARE APPLIED. *AK
NHTSA ODI #10024376
Mileage unknown · Jun 18, 2003
Steering
WHILE DRIVING AND WITHOUT WARNING LOST STEERING CONTROL. DEALER NOTIFIED. *AK
NHTSA ODI #10024286
Official recalls
4Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Jul 24, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Nov 13, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequence & remedy
Consequence: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: ISUZU IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE98054 · Broken Accelerator Pedal
Opened Oct 9, 1998 · Closed Feb 18, 1999
Status: closed (inferred from source dates) · Power Train
COMPLAINTS ALLE THAT THE HONDA PASSPORT (THE HONDA PASSPORT AND ISUZU RODEO ARE SIMILAR VEHICLES, BOTH MANUFACTURED BY ISUZU) ACCELERATOR PEDAL SEPARATES FROM THE PEDAL LINKAGE.
PE98051 · Braking System/abs
Opened Sep 23, 1998 · Closed Mar 31, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration