Illustration1998 ISUZU RODEO TRUCK WAS VIBRATING AND THE RIGHT FRONT TIRE CAME OFF. *NJ THE CONSUMER STRUCK THE PAVEMENT WITH THE RIGHT FRONT WHEEL HUB. THE POLICE REPORTED STATED THE LUG NUTS WERE NOT SECURED PROPERLY ON THE HUB STUDS. (OHIO TRAFFIC CRASH REPORT # 10-0519-91) *JB LETTER UPDATED 03/17/10*BF
1998 Isuzu Rodeo
Owner reports · Recalls · Investigations
More warning signs than most Rodeo years
Owner complaints for the 1998 Isuzu Rodeo are substantially higher than the model-year median of 89.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rodeo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
1025–50K
2650–75K
2975–100K
51100–150K
24150K+
148 reports with mileage · 330 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 211 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
81 crash reports2 fire reports24 injury reports
Wheels complaints
12 reportsVERY DISSATISFIED WITH VEHICLE. IT''S HAS MANY PROBLEMS FROM START. WHILE DRIVING THE VEHICLE AND GOING INTO GEARS THE VEHICLE SURGES FORWARD. CAR SHIMMY'S WITH NO AVAILABLE FIX. VEHICLE HAS STRONG SUSPENSION VIBRATION AND BECOME MORE PRONOUNCED AS SPEED INCREASES. THE ABS LIGHT ILLUMINATED AND STAYED ON. THE BRAKE PEDAL N…
Read full complaint
VERY DISSATISFIED WITH VEHICLE. IT''S HAS MANY PROBLEMS FROM START. WHILE DRIVING THE VEHICLE AND GOING INTO GEARS THE VEHICLE SURGES FORWARD. CAR SHIMMY'S WITH NO AVAILABLE FIX. VEHICLE HAS STRONG SUSPENSION VIBRATION AND BECOME MORE PRONOUNCED AS SPEED INCREASES. THE ABS LIGHT ILLUMINATED AND STAYED ON. THE BRAKE PEDAL NEVER SEEMS TO GO TO THE FLOOR, IT JUST GETS SPONGING AND YOU FEEL THE ABS PULSATING THRU THE PEDAL AND THE VEHICLE DOESNT SLOW DOWN, CAUSING EXTENDED STOPPING DISTANCE. FUEL SENDING UNIT IS OPERATING ERRATICALLY. GAS GAUGE READS EMPTY NEARLY ALL THE TIME REGARDLESS OF LEVEL OF FUEL. AFTER FILLING TANK GAUGE WILL RISE TO 1/2 THEN AS YOU DRIVE A FEW MILES IT WILL DROP AND READ EMPTY. PASSENGER SIDE AIR BAG ASSEMBLY MOUNTS HAVE COME LOOSE WHICH CAUSES AIR BAG ASSEMBLY TO MOVE AROUND BEHIND DASH. THIS RATTLE IS VERY BOTHERSOME. PAID A LOT OF MONEY FOR THE DEALERSHIP TO FIX PROBLEM, BUT THE RATTLE WAS BACK SOON AFTER. THE BOLTS CAME LOOSE ON PASSENGER'S SIDE FRONT DOOR. WHEEL STUDS ON 1998 ISUZU RODEO STRIP OFF. GLOVE BOX IN 1998 ISUZU RODEO STICKS AND HARD TO OPEN.
WHEEL STUDS ON 1998 ISUZU RODEO STRIP OFF, CAUSING WEEL TO FALL OFF WHILE DRIVING. ISUZU SAYS IT IS A COMMON PROBLEM BUT WOUNT COVER IT DUE TO BEING OFF WARRANTY. *AK
I PURCHASED A 1998 ISUZU RODEO FROM "VAN TROW" MOTORS, IN JACKSON, MISSISSIPPI, IN SEPTEMBER 2003. THE RIGHT REAR TIRE HAD A LUG NUT MISSING. THE DEALER SAID TO JUST REPLACE THE LUG BOLT, THAT IT HAD STRIPPED. ON 04 JULY, 2004, I HAD A FLAT ON THE LEFT REAR. REPLACING THE TIRE, ANOTHER ONE LUG BOLT STRIPPED, AND A LUG NUT FR…
Read full complaint
I PURCHASED A 1998 ISUZU RODEO FROM "VAN TROW" MOTORS, IN JACKSON, MISSISSIPPI, IN SEPTEMBER 2003. THE RIGHT REAR TIRE HAD A LUG NUT MISSING. THE DEALER SAID TO JUST REPLACE THE LUG BOLT, THAT IT HAD STRIPPED. ON 04 JULY, 2004, I HAD A FLAT ON THE LEFT REAR. REPLACING THE TIRE, ANOTHER ONE LUG BOLT STRIPPED, AND A LUG NUT FROM A DIFFERENT LUG BOLT STRIPPED. I TOOK MY FLAT TIRE TO WALMART TO HAVE THE FLAT REPAIRED. THEY REFUSED TO WORK ON THE TIRE, STATING WALMART IS NOT ALLOWED TO DO ANY REPAIRS OF ANY KIND ON RODEOS DUE TO LUG BOLTS AND LUG NUTS STRIPPING TO SUCH AN EXTENT THEY CAN NOT BE HELD LIABLE AND THIS WAS A SAFETY ISSUE. 1998 ISUZU RODEOS HAVE AN INHERENT DEFECT IN THE WHEEL LUG BOLTS. EITHER THE LUGS OR THE LUG NUTS STRIP OUT WHEN TIGHTENED BY AIR TOOLS OR HAND TIGHTENING, CAUSING THE TIRES TO BE DRIVEN ON LESS THEN SIX LUGS TIGHTENED. ISUZU IS AWARE OF THIS, AS WALMART HAS A MEMO AT EVERY STORE, STATING NOT TO DO ANY REPAIR WORK ON ISUZU RODEOS DUE TO THE LUGS STRIPPING. THIS IS A MAJOR SAFETY HAZARD, AND THE LUGS SHOULD BE RECALLED AND REPLACED.*AK
LUG NUT BOLT SHEARED OFF. I SAW WHERE OTHERS HAD SAME PROBLEM SO IT MAY NOT HAVE BEEN THE DEALER WHO BROKE IT. THE DEALER REPLACED IT BUT USED A LUG NUT WHICH HAS ALREADY RUSTED. I HAVEN'T TRIED TO TAKE THE RUSTY LUG NUT OFF SO I DON'T KNOW IF THE BOLT IS RUSTED TOO. I WILL HAVE TO REPLACE THE LUG NUT, AT LEAST, BEFORE IT RU…
Read full complaint
LUG NUT BOLT SHEARED OFF. I SAW WHERE OTHERS HAD SAME PROBLEM SO IT MAY NOT HAVE BEEN THE DEALER WHO BROKE IT. THE DEALER REPLACED IT BUT USED A LUG NUT WHICH HAS ALREADY RUSTED. I HAVEN'T TRIED TO TAKE THE RUSTY LUG NUT OFF SO I DON'T KNOW IF THE BOLT IS RUSTED TOO. I WILL HAVE TO REPLACE THE LUG NUT, AT LEAST, BEFORE IT RUSTS ONTO BOLT. THIS SOUNDS VERY DANGEROUS AND NOW I AM SO PARANOID ABOUT ONE OF MY WHEELS FALLING OFF WHILE I AM DRIVING IT THAT I HAVE TO CHECK ALL FOUR TIRES EVERY TIME I DRIVE THE VEHICLE. WITH ALL THE PROBLEMS I'VE HAD WITH THIS VEHICLE, I AM AFRAID TO TAKE IT ANY FURTHER THAN THE LOCAL AREA AND AFTER ONLY 45,000 MILES, I FEEL THIS VEHICLE IS A MONEY PIT THAT IS ALREADY USED UP. *JB
THE ORIGINAL AND THE REPLACEMENT TIRES DEVELOPED CRACKS IN THE SIDEWALL AT LOW MILEAGE. ALSO, VEHICLE EXPERIENCED STRIPPING OF THE LUG, NUTS AND STUDS UPON TIRE REPLACEMENT.*AK
STATE INSPECTION FOUND ALL FOUR WHEEL LUGS:NUTS CRACKED OR BROKEN. AS A RESULT, VEHICLE DIDN'T PASS LOCAL INSPECTION. DEALER STATED THIS WAS A COMMON PROBLEM FOR THIS TYPE OF VEHICLE. *AK
1998 ISUZU RODEO EXPERIENCED BRAKE FAILURE. *MR THE BRAKES WERE INTERMITTENT. THE BRAKE PEDAL WOULD GO TO THE FLOOR AND LOCK UP. A FEW DAYS LATER THE ABS LIGHT HAD COME ON. THE PROBLEM WAS DIAGNOSED AS A REAR BRAKE SENSOR AND WAS REPLACED. THE MOLDING ON THE DRIVER DOOR WAS LOOSE, THE LATCH ON THE CONSOLE HAD BROKEN, THE…
Read full complaint
1998 ISUZU RODEO EXPERIENCED BRAKE FAILURE. *MR THE BRAKES WERE INTERMITTENT. THE BRAKE PEDAL WOULD GO TO THE FLOOR AND LOCK UP. A FEW DAYS LATER THE ABS LIGHT HAD COME ON. THE PROBLEM WAS DIAGNOSED AS A REAR BRAKE SENSOR AND WAS REPLACED. THE MOLDING ON THE DRIVER DOOR WAS LOOSE, THE LATCH ON THE CONSOLE HAD BROKEN, THE SUNVISOR ON THE PASSENGER SIDE HAD FALLEN DOWN, AND THE CENTER CAPS ON THE FRONT WHEELS HAD PITTED. THE CONSUMER REQUESTED A BUY BACK AND OR TRADE IN. *SCC *JB
THE TIRE LUG NUTS CAME OF THE TIRES AND CAUSED THE TIRE TO WOBBLE. THE EALER WAS NOTIFIED. *NLM
CANNOT REPLACE TIRES ON THE VEHICLE BECAUSE THE ORIGINAL LUGS: NUTS AND POSTS ARE DEFECTIVE. *AK
Official recalls
410V436000 · Suspension:rear
Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
00V058000 · Suspension:rear
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
98V170000 · Electrical System:wiring:front Underhood
Jul 24, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
97V206001 · Unknown Or Other
Nov 13, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequence & remedy
Consequence: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: ISUZU IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE98054 · Broken Accelerator Pedal
Opened Oct 9, 1998 · Closed Feb 18, 1999
Status: closed (inferred from source dates) · Power Train
COMPLAINTS ALLE THAT THE HONDA PASSPORT (THE HONDA PASSPORT AND ISUZU RODEO ARE SIMILAR VEHICLES, BOTH MANUFACTURED BY ISUZU) ACCELERATOR PEDAL SEPARATES FROM THE PEDAL LINKAGE.
PE98051 · Braking System/abs
Opened Sep 23, 1998 · Closed Mar 31, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.