IllustrationFUEL TANK MOUNTS RUSTED AND FAILED. REAR SUSPENSION.STABILIZER.BRACKETS RUSTED AND FAILED REAR AXLE SHIFT DUE RUSTED MOUNTS AND REAR FRAME RUST. *TR
1998 Isuzu Rodeo
Owner reports · Recalls · Investigations
More warning signs than most Rodeo years
Owner complaints for the 1998 Isuzu Rodeo are substantially higher than the model-year median of 89.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rodeo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
1025–50K
2650–75K
2975–100K
51100–150K
24150K+
148 reports with mileage · 330 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 211 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
81 crash reports2 fire reports24 injury reports
What owners actually said
478 reportsTL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT THE ELECTRONIC DOOR LOCKS INTERMITTENTLY LOCKED THE CONTACT OUT OF THE VEHICLE. THE FRONT DRIVER'S SIDE AND REAR DRIVER'S SIDE DOORS FAILED TO UNLOCK ELECTRONICALLY OR MANUALLY. THE CONTACT MENTIONED THAT THE KEY WAS USED IN ORDER TO UNLOCK THE FRONT PASSENGAR'S AN…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT THE ELECTRONIC DOOR LOCKS INTERMITTENTLY LOCKED THE CONTACT OUT OF THE VEHICLE. THE FRONT DRIVER'S SIDE AND REAR DRIVER'S SIDE DOORS FAILED TO UNLOCK ELECTRONICALLY OR MANUALLY. THE CONTACT MENTIONED THAT THE KEY WAS USED IN ORDER TO UNLOCK THE FRONT PASSENGAR'S AND REAR PASSENGAR'S SIDE DOORS MANUALLY. THE CONTACT ENTERED THE VEHICLE FROM THE FRONT PASSENGERS SIDE OCASSIONALLY. IN ADDITION, THE CONTACT HAD NOTICED THAT THE REAR END OF THE FRAME HAD RUSTED AND CORRODED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 143,000.
I TOOK MY VEHICLE TO THE CERTIFIED ISUZU DEALERSHIP FOR REPAIR DURING THE 2010 RECALL FOR PREMATURE RUST (NHTSA ACTION NUMBER : EA09018) ACCORDING TO THEM MY VEHICLE DID NOT REQUIRE THE BRACKET TO BE INSTALLED. THEY TREATED THE PART WITH THE PREVENTIVE COMPOUND. DURING RECENT MAINTENANCE TO MY TRUCK WE NOTICE THE ENTIRE FRA…
Read full complaint
I TOOK MY VEHICLE TO THE CERTIFIED ISUZU DEALERSHIP FOR REPAIR DURING THE 2010 RECALL FOR PREMATURE RUST (NHTSA ACTION NUMBER : EA09018) ACCORDING TO THEM MY VEHICLE DID NOT REQUIRE THE BRACKET TO BE INSTALLED. THEY TREATED THE PART WITH THE PREVENTIVE COMPOUND. DURING RECENT MAINTENANCE TO MY TRUCK WE NOTICE THE ENTIRE FRAME IS COMPLETELY RUSTED, TO A POINT THAT YOU A EASILY POKE YOUR FINGER THROUGH THE CHASIS IN MULTIPLE AREAS. I TOOK IT BACK TO HYUNDAI OF LOUISVILLE TO BE INSPECTED. THEY INFORMED ME THAT THE REAR SUSPENSION LOWER LINK BRACKET (WHICH WAS THE ONLY PART RECALLED) NEEDED TO HAVE THE BRACKET INSTALLED BECAUSE IT DOES CURRENTLY SHOW DAMAGE. AFTER CONTACTING ISUZU THEY INFORM ME THAT SINCE THE RECALL HAS EXPIRED THEY WILL NOT COVER INSTALLATION OF THE BRACKET. SO I AM NOW STUCK WITH A FAMILY VEHICLE THAT IS UNSAFE TO DRIVE! I DID EVERYTHING REQUIRED OF ME DURING THE RECALL. THIS IS UNBELIEVABLE!!! WHAT AM I TO DO NOW??? *TR
AFTER RECEIVING RECALL INFO IN 2010 ISUZU DEALER INSPECTED VEHICLE AND TREATED THE FRAME WITH CHEMICAL TO PREVENT FURTHER EROSION. JUST HAD MY TRUCK IN REPAIR SHOP WHEN THEY NOTIFIED ME OF THE UNSAFE CONDITION OF PASSENGER SIDE REAR FRAME. YOU CAN STICK YOUR FINGER THROUGH THE FRAME, BECAUSE IT HAS RUSTED THROUGH. CONTACTED IS…
Read full complaint
AFTER RECEIVING RECALL INFO IN 2010 ISUZU DEALER INSPECTED VEHICLE AND TREATED THE FRAME WITH CHEMICAL TO PREVENT FURTHER EROSION. JUST HAD MY TRUCK IN REPAIR SHOP WHEN THEY NOTIFIED ME OF THE UNSAFE CONDITION OF PASSENGER SIDE REAR FRAME. YOU CAN STICK YOUR FINGER THROUGH THE FRAME, BECAUSE IT HAS RUSTED THROUGH. CONTACTED ISUZU TODAY AND THEY REFUSE TO LOOK AT IT. *TR
EXCESSIVE CORROSION RESULT IN THE RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH. *TR
SHOCK BRACKET BROKE AWAY FROM THE FRAME. THE UNDERNEATH IS RUSTED SO BADLY NOT TO SURE IF A NEW BRACKET CAN BE INSTALLED. *TR
VEHICLE WILL NOT PASS INSPECTION THIS YEAR BECAUSE OF FRAME RUSTING OUT AND OTHER ISSUES WITH THE SPRING BRACKETS AND STABILIZER BAR....ALL ARE RUSTED OUT....RODEO IS NOW WORTHLESS....ISUZU HAD TO KNOW THE FRAME WAS INFERIOR MATERIAL FOR VEHICLES 1998-2002...AND DID NOTHING EXCEPT A WORTHLESS RECALL IN 2011 AND IGNORED THE REST …
Read full complaint
VEHICLE WILL NOT PASS INSPECTION THIS YEAR BECAUSE OF FRAME RUSTING OUT AND OTHER ISSUES WITH THE SPRING BRACKETS AND STABILIZER BAR....ALL ARE RUSTED OUT....RODEO IS NOW WORTHLESS....ISUZU HAD TO KNOW THE FRAME WAS INFERIOR MATERIAL FOR VEHICLES 1998-2002...AND DID NOTHING EXCEPT A WORTHLESS RECALL IN 2011 AND IGNORED THE REST OF THE FRAME OF THE VEHICLE...CONTACTED ISUZU ABOUT THE PROBLEM AND SPOKE TO TWO REPS....BOTH BASICALLY BLEW ME OFF....I ASKED TO SPEAK TO THEIR MANAGER AND WAS TOLD THAT THIS IS AS FAR AS IT GOES....AND THAT IT AIN`T HAPPENING...GREAT CUSTOMER SERVICE!!HOPEFULLY SOMETHING WILL BE DONE ABOUT THIS....I SEE THAT THERE ARE MANY OTHER RODEO AND PASSPORT OWNERS OUT THERE WITH THE SAME PROBLEM...THIS IS A SAFETY ISSUE...SOMEONE IS GOING TO GET KILLED.... *TR
1998 ISUZU RODEO. CONSUMER WRITES IN REGARDS TO REAR SUSPENSION BRACKET CORROSION RECALL NOTICE. *SMD THE CONSUMER STATED SHE RECEIVED A RECALL NOTICE IN JULY 2011 FROM ISUZU FOR INSPECTION AND REPAIR OF A POSSIBLE CORROSION ISSUE AT THE REAR SUSPENSION BRACKET. IN NOVEMBER 2011, THE CONSUMER TOOK THE VEHICLE TO THE DEALER …
Read full complaint
1998 ISUZU RODEO. CONSUMER WRITES IN REGARDS TO REAR SUSPENSION BRACKET CORROSION RECALL NOTICE. *SMD THE CONSUMER STATED SHE RECEIVED A RECALL NOTICE IN JULY 2011 FROM ISUZU FOR INSPECTION AND REPAIR OF A POSSIBLE CORROSION ISSUE AT THE REAR SUSPENSION BRACKET. IN NOVEMBER 2011, THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR AN INSPECTION TO PERFORMED. THE REPAIR FACILITY SPRAYED AN ANTI- CORROSION AS A FIX. ON JANUARY 12, 2013, THE CONSUMER TOOK THE VEHICLE FOR AN OIL CHANGE. AT THAT TIME, SHE WAS INFORMED THERE WAS A SERIOUS AND DANGEROUS CONDITION. THE TECHNICIAN INDICATED THE REAR STABILIZER FRAME MOUNT WAS DESTROYED AND THE FRAME WAS RUSTED OUT. THE TECHNICIAN SUGGESTED THE CONSUMER SEEK AN EVALUATION FROM ANOTHER REPAIR FACILITY. THE CONSUMER WENT TO ANOTHER FACILITY TO HAVE THE VEHICLE INSPECTED. THE TECHNICIAN FOUND THE REAR LATERAL LINK FOR THE REAR AXLE MOUNT HAD ROTTED AWAY, MAKING THE REAR UNSTABLE. THEY ALSO STATED THE VEHICLE WAS NOT ROAD WORTHY. IN THE TECHNICIAN'S OPINION, THE VEHICLE WAS TOTALED, AS A RESULT OF THE CORROSION OF THE FRAME. THE CONSUMER CALLED ISUZU AND THEY ADVISED HER TO RETURN TO THE REPAIR FACILITY FOR ANOTHER EVALUATION. THE REPAIR SHOP EXAMINED THE VEHICLE AGAIN. THE REPAIR FACILITY LISTED ON THE INVOICE AS THE LATERAL LINK BEING BROKEN, WHICH WAS NOT PART OF THE RECALL. THE AREA THAT WAS PREVIOUSLY SPRAYED, WAS STILL IN GOOD CONDITION.
VEHICLE HAS BEEN FEELING UNSTABLE LATELY TO THE POINT OF ALMOST LOSING CONTROL. CLIMBED UNDER THE VEHICLE TO SEE IF I COULD SPOT AN ISSUE AN FOUND THE FRAME TO COMPLETELY ROTTED THROUGH ON THE REAR DRIVER SIDE UPPER SPRING PERCH, WHICH IS COMING THROUGH THE CARGO COMPARTMENT FLOORBOARD. FRAME CAN ALSO BE CRUMBLED WITH THE SLIGH…
Read full complaint
VEHICLE HAS BEEN FEELING UNSTABLE LATELY TO THE POINT OF ALMOST LOSING CONTROL. CLIMBED UNDER THE VEHICLE TO SEE IF I COULD SPOT AN ISSUE AN FOUND THE FRAME TO COMPLETELY ROTTED THROUGH ON THE REAR DRIVER SIDE UPPER SPRING PERCH, WHICH IS COMING THROUGH THE CARGO COMPARTMENT FLOORBOARD. FRAME CAN ALSO BE CRUMBLED WITH THE SLIGHT PUSH OF A SCREWDRIVER AT THE REAR FRAME SECTION. *TR
I WAS DRIVING VEHICLE ON STATE ROUTE. BEGAN HEARING WHAT SOUNDED LIKE SMALL ROCKS OR CINDERS. NOW ON THE ROAD THOUGH. THEN THE CAR STARTED TO SWAY SOME AS I WENT AROUND A TURN. I PULLED OVER AND LOOKED UNDER VEHICLE AND FOUND MY RIGHT REAR SWAY BAR BRACKET HAD RUSTED THROUGH AND THE BAR WAS HANGING ON THAT SIDE TRIED TO WELD …
Read full complaint
I WAS DRIVING VEHICLE ON STATE ROUTE. BEGAN HEARING WHAT SOUNDED LIKE SMALL ROCKS OR CINDERS. NOW ON THE ROAD THOUGH. THEN THE CAR STARTED TO SWAY SOME AS I WENT AROUND A TURN. I PULLED OVER AND LOOKED UNDER VEHICLE AND FOUND MY RIGHT REAR SWAY BAR BRACKET HAD RUSTED THROUGH AND THE BAR WAS HANGING ON THAT SIDE TRIED TO WELD A PIECE OF METAL TO FRAME TO MAKE A NEW BRACKET AND DISCOVERED THE FRAME IS ALSO RUSTED THROUGH IN PLACES. MY CAR IS UNSAFE TO DRIVE NOW AND IS BASICALLY TOTALED. I HAVE NO OTHER VEHICLE TO DRIVE. CALLED ISUZU AND WAS INFORMED IT WAS MY PROBLEM NOT THEIRS. *TR
Official recalls
410V436000 · Suspension:rear
Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
00V058000 · Suspension:rear
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
98V170000 · Electrical System:wiring:front Underhood
Jul 24, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
97V206001 · Unknown Or Other
Nov 13, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequence & remedy
Consequence: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: ISUZU IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE98054 · Broken Accelerator Pedal
Opened Oct 9, 1998 · Closed Feb 18, 1999
Status: closed (inferred from source dates) · Power Train
COMPLAINTS ALLE THAT THE HONDA PASSPORT (THE HONDA PASSPORT AND ISUZU RODEO ARE SIMILAR VEHICLES, BOTH MANUFACTURED BY ISUZU) ACCELERATOR PEDAL SEPARATES FROM THE PEDAL LINKAGE.
PE98051 · Braking System/abs
Opened Sep 23, 1998 · Closed Mar 31, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.