NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
69 reportsClear category filter169,585 miles · Aug 1, 2012
StructureSuspension
I WAS DRIVING VEHICLE ON STATE ROUTE. BEGAN HEARING WHAT SOUNDED LIKE SMALL ROCKS OR CINDERS. NOW ON THE ROAD THOUGH. THEN THE CAR STARTED TO SWAY SOME AS I WENT AROUND A TURN. I PULLED OVER AND LOOKED UNDER VEHICLE AND FOUND MY RIGHT REAR SWAY BAR BRACKET HAD RUSTED THROUGH AND THE BAR WAS HANGING ON THAT SIDE TRIED TO WELD …
Read full complaint
I WAS DRIVING VEHICLE ON STATE ROUTE. BEGAN HEARING WHAT SOUNDED LIKE SMALL ROCKS OR CINDERS. NOW ON THE ROAD THOUGH. THEN THE CAR STARTED TO SWAY SOME AS I WENT AROUND A TURN. I PULLED OVER AND LOOKED UNDER VEHICLE AND FOUND MY RIGHT REAR SWAY BAR BRACKET HAD RUSTED THROUGH AND THE BAR WAS HANGING ON THAT SIDE TRIED TO WELD A PIECE OF METAL TO FRAME TO MAKE A NEW BRACKET AND DISCOVERED THE FRAME IS ALSO RUSTED THROUGH IN PLACES. MY CAR IS UNSAFE TO DRIVE NOW AND IS BASICALLY TOTALED. I HAVE NO OTHER VEHICLE TO DRIVE. CALLED ISUZU AND WAS INFORMED IT WAS MY PROBLEM NOT THEIRS. *TR
NHTSA ODI #10468856
117,000 miles · Jul 31, 2012
StructureSuspension
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT THE UNDER CARRIAGE WAS SEVERELY CORRODED AND EXHIBITED A LOUD NOISE WHEN DRIVING. IN ADDITION, THE FRAME FELT AS IT WAS SEPARATING FROM THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE CONTACT STATED THAT REPAIRS WERE MADE TO THE VEHICLE UNDER NHTSA CAMPA…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT THE UNDER CARRIAGE WAS SEVERELY CORRODED AND EXHIBITED A LOUD NOISE WHEN DRIVING. IN ADDITION, THE FRAME FELT AS IT WAS SEPARATING FROM THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE CONTACT STATED THAT REPAIRS WERE MADE TO THE VEHICLE UNDER NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION: REAR) WAS PERFORMED ON THE VEHICLE IN 2010. THE CONTACT BELIEVED THAT THE REPAIR DID NOT CORRECT THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 117,000 AND THE CURRENT MILEAGE WAS 250,000. UPDATED 8/31/12 *CN UPDATED 09/11/2012 *JS
NHTSA ODI #10468474
177,332 miles · Apr 9, 2012
StructureSuspension
FRAME RUSTED CAUSING REAR LOWER CONTROL ARM TO FALL OFF ALMOST CAUSING A SERIOUS ACCIDENT VEHICLE PURCHASED 8/22/11 WANT TO KNOW WHY THESE VEWHICLES ARE STILL BE ALLOWED TO BE SOLD. IT IS A KNOWN PROBLEM AND THE RECALL STARTED IN 2010 AND ONLY GOOD FOR 1 YEAR SO I HAVE TO JUNK A OTHERWISE DECENT CAR BECAUSE THE FRAMES ARE JUNK. …
Read full complaint
FRAME RUSTED CAUSING REAR LOWER CONTROL ARM TO FALL OFF ALMOST CAUSING A SERIOUS ACCIDENT VEHICLE PURCHASED 8/22/11 WANT TO KNOW WHY THESE VEWHICLES ARE STILL BE ALLOWED TO BE SOLD. IT IS A KNOWN PROBLEM AND THE RECALL STARTED IN 2010 AND ONLY GOOD FOR 1 YEAR SO I HAVE TO JUNK A OTHERWISE DECENT CAR BECAUSE THE FRAMES ARE JUNK. THESE VEHICLES NEED TO BE TAKEN OFF THE ROADS FOR EVERYONES SAFETY!!!!!!!!!!!!! *TR
NHTSA ODI #10454511
Mileage unknown · Apr 4, 2012
StructureSuspension
OCTOBER 17, 2011, I TOOK MY RODEO TO, HAVE IT SERVICED FOR THE SUSPENSION:REAR RECALL. AFTER SERVICE THE MECHANICS INSPECTION REPORT NOTED THAT: "FRAME CORRODED BADLY, R/F HUB LOOSE, REAR SHOCK HANGING, FRAME ROTTED THRU" AND THAT THE FRONT C/V JOINT HAD RUSTED OFF. THE SERVICE DEPARTMENT, DID NOT ADVISE ME TO DRIVE THE CA…
Read full complaint
OCTOBER 17, 2011, I TOOK MY RODEO TO, HAVE IT SERVICED FOR THE SUSPENSION:REAR RECALL. AFTER SERVICE THE MECHANICS INSPECTION REPORT NOTED THAT: "FRAME CORRODED BADLY, R/F HUB LOOSE, REAR SHOCK HANGING, FRAME ROTTED THRU" AND THAT THE FRONT C/V JOINT HAD RUSTED OFF. THE SERVICE DEPARTMENT, DID NOT ADVISE ME TO DRIVE THE CAR HOME, AS IT WAS A SAFETY ISSUE. OVER THE YEARS I HAVE HAD THE EXHAUST REPAIRED, A NUMBER OF TIMES DUE TO RUST. THIS VEHICLE HAS NEVER BEEN OFF-ROAD, AND HAS ONLY BEEN USED AS TRANSPORTATION TO WORK(ALL HIGHWAY DRIVING). *TR
NHTSA ODI #10454153
215,303 miles · Jan 6, 2012
Structure
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT WHILE CHANGING A FLAT TIRE, CORROSION WAS DISCOVERED ALONG THE ENTIRE FRAME OF THE VEHICLE. THE WAS THEN TAKEN TO A LOCAL REPAIR SHOP. THE REPAIR SHOP STATED THAT THERE WAS CORROSION ON THE LOWER BRACKETS AND THE FRAME. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WA…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT WHILE CHANGING A FLAT TIRE, CORROSION WAS DISCOVERED ALONG THE ENTIRE FRAME OF THE VEHICLE. THE WAS THEN TAKEN TO A LOCAL REPAIR SHOP. THE REPAIR SHOP STATED THAT THERE WAS CORROSION ON THE LOWER BRACKETS AND THE FRAME. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 215,303 AND THE CURRENT MILEAGE WAS 219,695.
NHTSA ODI #10442631
126,000 miles · Dec 7, 2011
StructureSuspension
WAS DRIVING THE VEHICLE AT 30 MPH WHEN A POP IN THE BACK WAS HEARD AND ALL STEERING CONTROL WAS LOST. WHEN I LOOKED UNDER THE VEHICLE, THE BRACKET THAT HOLDS THE REAR AXLE (LEFT SIDE) HAD BROKEN OFF. FRAME IS GROSSLY RUSTED. WHEN ISUZU WAS CALLED REGARDING THE CURRENT RECALL, WAS TOLD THAT THE NEAREST SERVICE CENTER WAS OVER …
Read full complaint
WAS DRIVING THE VEHICLE AT 30 MPH WHEN A POP IN THE BACK WAS HEARD AND ALL STEERING CONTROL WAS LOST. WHEN I LOOKED UNDER THE VEHICLE, THE BRACKET THAT HOLDS THE REAR AXLE (LEFT SIDE) HAD BROKEN OFF. FRAME IS GROSSLY RUSTED. WHEN ISUZU WAS CALLED REGARDING THE CURRENT RECALL, WAS TOLD THAT THE NEAREST SERVICE CENTER WAS OVER 3 HOURS AWAY. I AM CURRENTLY IN THE PROCESS OF GETTING THE VEHICLE TO THE SERVICE CENTER, BUT DUE TO DISTANCE THIS IS AN ISSUE. *TR
NHTSA ODI #10438838
100,000 miles · Nov 19, 2011
Structure
FRAME BASICALLY FELL APART DUE TO SEVERE RUST, WAS GOING 40 MPH AT THE TIME AND THE VEHICLE SWIRVED OUT OF CONTROL INTO THE ONCOMING LANE, LUCKILY FOR ME THERE WASN'T ANYONE USING THE OTHER LANE. *TR
NHTSA ODI #10436469
61,000 miles · Sep 6, 2011
Structure
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT WHILE HAVING REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION:REAR), SHE WAS NOTIFIED THAT THE VEHICLE FRAME WAS COMPLETELY CORRODED. THE DEALER STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE SINCE THE CORROSION DAMAGE WAS EXTENSIVE. THE MANUFACTURER WAS …
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT WHILE HAVING REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION:REAR), SHE WAS NOTIFIED THAT THE VEHICLE FRAME WAS COMPLETELY CORRODED. THE DEALER STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE SINCE THE CORROSION DAMAGE WAS EXTENSIVE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 61,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10423987
149,000 miles · Aug 29, 2011
StructureSuspension
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT TOOK HIS VEHICLE TO A PRIVATE MECHANIC FOR ROUTINE MAINTENANCE AND WAS INFORMED THE ENTIRE REAR FRAME WAS COVERED WITH RUST. THE DEALER DID NOT OFFER ANY ASSISTANCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE NOR WAS THE VEHICLE REPAIRED. THE CURRENT MILEAGE WAS 155,00…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT TOOK HIS VEHICLE TO A PRIVATE MECHANIC FOR ROUTINE MAINTENANCE AND WAS INFORMED THE ENTIRE REAR FRAME WAS COVERED WITH RUST. THE DEALER DID NOT OFFER ANY ASSISTANCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE NOR WAS THE VEHICLE REPAIRED. THE CURRENT MILEAGE WAS 155,000. THE APPROXIMATE FAILURE MILEAGE WAS 149,000. .. UPDATED 09/21/11 *BF UPDATED 09/30/11.*JB
NHTSA ODI #10422396
125,000 miles · Jul 19, 2011
Structure
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TO BE REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 00V058000 (SUSPENSION: REAR). THE DEALER STATED THAT THE BOLTS AND NUTS FOR THE REAR AXLE COULD NOT BE REPLACED BECAUSE THE SUBFRAME WAS SEVERELY CORRODED AND THE VEHICLE WO…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TO BE REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 00V058000 (SUSPENSION: REAR). THE DEALER STATED THAT THE BOLTS AND NUTS FOR THE REAR AXLE COULD NOT BE REPLACED BECAUSE THE SUBFRAME WAS SEVERELY CORRODED AND THE VEHICLE WOULD BE UNSAFE TO DRIVE. THE FAILURE AND CURRENT MILEAGES WERE 125,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10413589
Official recalls
4Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Jul 24, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Nov 13, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequence & remedy
Consequence: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: ISUZU IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE98054 · Broken Accelerator Pedal
Opened Oct 9, 1998 · Closed Feb 18, 1999
Status: closed (inferred from source dates) · Power Train
COMPLAINTS ALLE THAT THE HONDA PASSPORT (THE HONDA PASSPORT AND ISUZU RODEO ARE SIMILAR VEHICLES, BOTH MANUFACTURED BY ISUZU) ACCELERATOR PEDAL SEPARATES FROM THE PEDAL LINKAGE.
PE98051 · Braking System/abs
Opened Sep 23, 1998 · Closed Mar 31, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration