NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
211 reportsClear category filter3,549 miles · Oct 26, 2005
Service Brakes, HydraulicCrashInjury
DT: THE CONTACT RECEIVED A MANUFACTURER'S RECALL 021-002 CONCERNING ABS BRAKES. WHEN SHE CONTACTED THE DEALER, THEY SAID THEY DID NOT HAVE THE PART. LATER, SHE SCHEDULED AN APPOINTMENT AND HAD TO CANCEL IT. WHEN SHE CALLED TO RESCHEDULE THE APPOINTMENT THEY TOLD HER THEY HAD THE PART. BEFORE THE APPOINTMENT THEY HAD T…
Read full complaint
DT: THE CONTACT RECEIVED A MANUFACTURER'S RECALL 021-002 CONCERNING ABS BRAKES. WHEN SHE CONTACTED THE DEALER, THEY SAID THEY DID NOT HAVE THE PART. LATER, SHE SCHEDULED AN APPOINTMENT AND HAD TO CANCEL IT. WHEN SHE CALLED TO RESCHEDULE THE APPOINTMENT THEY TOLD HER THEY HAD THE PART. BEFORE THE APPOINTMENT THEY HAD TO REORDER THE PART. BEFORE THE REPAIR COULD BE MADE SHE WAS INVOLVED IN AN ACCIDENT BECAUSE OF ABS. FAILURE. THE CONTACT WAS BACKING OUT OF HER DRIVEWAY WHEN THE VEHICLE CRASHED INTO A FENCE. THE CONTACT SUSTAINED A, FRACTURE D DISC, AND THE ROOT OF HER FRONT TOOTH BROKE. THERE ARE MEDICAL RECORDS FOR THE INJURIES. THE VEHICLE WAS TOWED. THE MANUFACTURER SAID THEY WOULD SEND SOMEONE TO INSPECT THE VEHICLE AND DID NOT DO IT. *AK
NHTSA ODI #10140867
96,000 miles · Oct 6, 2005
Service Brakes, HydraulicCrash
DT: THE CONSUMER COMPLAINED ABOUT AN ABS BRAKE PROBLEM. THE BRAKES DID NOT HOLD. THE ABS LIGHT CAME ON SINCE JUNE OF 2005. ON JULY 15, 2005 THE BRAKES FAILED, CAUSING CONSUMER'S VEHICLE TO LIGHTLY HIT ANOTHER VEHICLE. NO POLICE REPORT WAS TAKEN.. WHEN SHE TOOK VEHICLE TO THE DEALERSHIP , THEY CLEANED THE ABS SENSOR …
Read full complaint
DT: THE CONSUMER COMPLAINED ABOUT AN ABS BRAKE PROBLEM. THE BRAKES DID NOT HOLD. THE ABS LIGHT CAME ON SINCE JUNE OF 2005. ON JULY 15, 2005 THE BRAKES FAILED, CAUSING CONSUMER'S VEHICLE TO LIGHTLY HIT ANOTHER VEHICLE. NO POLICE REPORT WAS TAKEN.. WHEN SHE TOOK VEHICLE TO THE DEALERSHIP , THEY CLEANED THE ABS SENSOR BECAUSE IT WAS CORRODED. THE ABS LIGHT WENT OFF, AND THE BRAKES WORKED FINE UNTIL SEPTEMBER 29. 2005, AND IT ALMOST CAUSED ANOTHER ACCIDENT. AFTER SHE TOOK IT TO THE DEALER TO BE CHECKED AGAIN, THEY SAID THAT IT WAS A PROBLEM WITH THE ABS. *AK
NHTSA ODI #10138777
105,000 miles · Aug 19, 2005
Service Brakes, HydraulicCrashInjury
MY ELDERLY FATHER WAS DRIVING THE 1998 ISUZU RODEO ON I-78 WEST BOUND WHEN THE BREAKS FAILED. MY FATHER SAID IT WAS AS IF THE ABS CAME ON AND PREVENTED THE BRAKES FROM WORKING. THE BRAKE FALIUR RESULTED IN A COLLISION WITH THE THE CAR INFRONT TWICE. AT THE TIME NO INJURIES WERE REPORTED HOWEVER MY FATHER HAS EXPERIENCED PAIN IN…
Read full complaint
MY ELDERLY FATHER WAS DRIVING THE 1998 ISUZU RODEO ON I-78 WEST BOUND WHEN THE BREAKS FAILED. MY FATHER SAID IT WAS AS IF THE ABS CAME ON AND PREVENTED THE BRAKES FROM WORKING. THE BRAKE FALIUR RESULTED IN A COLLISION WITH THE THE CAR INFRONT TWICE. AT THE TIME NO INJURIES WERE REPORTED HOWEVER MY FATHER HAS EXPERIENCED PAIN IN HIS SHOULDERS. AFTER INVESTIGATING HOW THE BRAKES COULD FAIL ON THE INTERNET I CAME TO LEARN THAT THIS PARTICULAR MODEL OF ISUZU RODEO HAD BEEN RECALLED DUE TO ABS BRAKE FALIUR. THIS WAS THE WAY I CAME TO LEARN OF THE RECALL. TO THIS DATE ISUZU HAS NEVER CONTACTED ME REGARDING THIS RECALL. I HAVE MADE MULITPLE ATTEMPTS TO CONTACT CLODE AT ISUZU CUSTOMER RELATIONS HIS PHONE NUMBER IS 1800 255 6727 EXT 7417. WE HAVE EXCHANGED PHONE MESSAGES BUT HAVE NOT BEE ABLE TO SPEAK. I WISH CLODE WOULD MAKE AN EFFORT TO REACH ME. WE MADE AN APPOINTMENT WITH BUHLER ISUZU AT VALL HOMES NJ TO HAVE THE PROBLEM RESOLVED. WE TOOK THE CAR TO THIS DEALER TODAY HOWEVER THEY ARE UNABLE TO REPAIR IT DUE TO LACK OF PROPER EQUIPMENT ON THEIR PART. I AM FILING THIS COMLAINT AFTER MAKING MULTIPLE GOOD FAITH ATTEMPTS TO RESOLVE THIS PROBLEM. I AM HEARBY MAKING IT KNOWN THAT I WILL NO LONGER BE RESPONISBLE FOR ANY CONSEQUENCES AFTER THIS AUTOMOBILE LEAVES BUHLER ISUZU WITH OR WITH OUT THE SAID REPAIRS. THE COURT DATE FOR THIS ACCIDENT IS ON SEPT 22 05.
NHTSA ODI #10133494
95,000 miles · Dec 8, 2004
Service Brakes, Hydraulic
A RECALL WAS ISSUED FOR THE BRAKES, HOWEVER THE PROBLEM NEVER WAS REPAIRED. *AK
NHTSA ODI #10103352
152,159 miles · Nov 16, 2004
Service Brakes, HydraulicCrash
WHILE DRIVING 50 MPH A DEER JUMPED OUT INTO THE STREET CONSUMER ATTEMPTED TO STOP AND BRAKES FAILED. VEHICLE COLLIDED WITH THE DEER, DRAGGING IT ABOUT 1500 FEET. NO REPORT OF AIRBAG DEPLOYMENT. NO INJURIES REPORTED. *AK
NHTSA ODI #10101072
66,310 miles · Nov 6, 2004
Service Brakes, Hydraulic
WHEN THE BRAKES ARE APPLIED IT HAS A RELATIVELY LONG STOPPING DISTANCE COMPARED TO OTHER VEHICLES. FORTUNATELY ISUZU LAUNCHED A RECALL CAMPAIGN TO ADDRESS THE PROBLEM AND THE ABS MODULE WAS REPLACED BUT THE PROBLEM IS PERSISTS. I WROTE TO THE MANUFACTURER INFORMING THEM OF THE PROBLEM BUT I HAVE HEARD FROM THEM SINCE THEN. *JB…
Read full complaint
WHEN THE BRAKES ARE APPLIED IT HAS A RELATIVELY LONG STOPPING DISTANCE COMPARED TO OTHER VEHICLES. FORTUNATELY ISUZU LAUNCHED A RECALL CAMPAIGN TO ADDRESS THE PROBLEM AND THE ABS MODULE WAS REPLACED BUT THE PROBLEM IS PERSISTS. I WROTE TO THE MANUFACTURER INFORMING THEM OF THE PROBLEM BUT I HAVE HEARD FROM THEM SINCE THEN. *JB
NHTSA ODI #10098364
80,000 miles · Sep 22, 2004
Engine And Engine CoolingEquipmentFuel System, OtherCrashInjury
FAILURE OF ABS BRAKE SYSTEM, EVEN THOUGH DEALER FIXED THE PROBLEM VIA RECALL; FUEL LEAK AT HOSE AND FUEL PUMP CONNECTION; FAILURE OF FUEL SENDING UNIT AND FUEL GAUGE.*AK
NHTSA ODI #10093046
Mileage unknown · Sep 13, 2004
Service Brakes, Hydraulic
CONSUMER RECEIVED NHTSA RECALL: 02I002000 CONCERNING ABS BRAKES. AFTER HAVING THE COMPUTER REPLACED FOR THE ABS, AND WHILE DRIVING 25 MPH ABS LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. VEHICLE WAS TAKEN BACK TO THE DEALER FOR INSPECTION. THE CAUSE HAD NOT BEEN DETERMINED. *AK
NHTSA ODI #10091998
74,000 miles · Sep 2, 2004
Service Brakes, Hydraulic
AFTER ABS RECALL 02I002000 REPAIRS WERE PERFORMED THE BRAKE PEDAL WENT TO THE FLOOR WHEN DEPRESSED, RESULTING IN EXTENDED STOPPING DISTANCE. DEALERSHIP INDICATED THAT THE RECALL PART FAILED. *AK
NHTSA ODI #10090315
Mileage unknown · Jul 23, 2004
Service Brakes, Hydraulic
PROBLEMS WITH ABS SYSTEM ON 1998 ISUZU RODEO.*MR THE ABS LIGHT ILLUMINATED AND STAYED ON. THE CONSUMER RECEIVED A RECALL NOTICE FOR THE ABS (02I-002) AND TOOK THE VEHICLE TO THE DEALER TO BE REPAIRED. WHEN THE CONSUMER PICKED THE VEHICLE UP SHE NOTICED THAT THE ABS LIGHT WAS STILL ON. THE DEALER FAILED TO GIVE THE CONSUMER …
Read full complaint
PROBLEMS WITH ABS SYSTEM ON 1998 ISUZU RODEO.*MR THE ABS LIGHT ILLUMINATED AND STAYED ON. THE CONSUMER RECEIVED A RECALL NOTICE FOR THE ABS (02I-002) AND TOOK THE VEHICLE TO THE DEALER TO BE REPAIRED. WHEN THE CONSUMER PICKED THE VEHICLE UP SHE NOTICED THAT THE ABS LIGHT WAS STILL ON. THE DEALER FAILED TO GIVE THE CONSUMER AN INVOICE INDICATING WHAT WAS REPAIRED/REPLACED. THE CONSUMER CONTACTED THE DEALER WHO INFORMED HER THAT THERE WAS PROBABLY SOME OTHER PROBLEM WITH THE SYSTEM AND TO BRING THE VEHICLE IN FOR SERVICE. THE CONSUMER FEELS THE PROBLEM SHOULD HAVE BEEN REPAIRED THE FIRST TIME. *NM *JB
NHTSA ODI #10083789
Official recalls
4Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Jul 24, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Nov 13, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequence & remedy
Consequence: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: ISUZU IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE98054 · Broken Accelerator Pedal
Opened Oct 9, 1998 · Closed Feb 18, 1999
Status: closed (inferred from source dates) · Power Train
COMPLAINTS ALLE THAT THE HONDA PASSPORT (THE HONDA PASSPORT AND ISUZU RODEO ARE SIMILAR VEHICLES, BOTH MANUFACTURED BY ISUZU) ACCELERATOR PEDAL SEPARATES FROM THE PEDAL LINKAGE.
PE98051 · Braking System/abs
Opened Sep 23, 1998 · Closed Mar 31, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration