NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
30 reportsClear category filter143,000 miles · May 16, 2014
Electrical SystemLatches/locks/linkagesStructure
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT THE ELECTRONIC DOOR LOCKS INTERMITTENTLY LOCKED THE CONTACT OUT OF THE VEHICLE. THE FRONT DRIVER'S SIDE AND REAR DRIVER'S SIDE DOORS FAILED TO UNLOCK ELECTRONICALLY OR MANUALLY. THE CONTACT MENTIONED THAT THE KEY WAS USED IN ORDER TO UNLOCK THE FRONT PASSENGAR'S AN…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT STATED THAT THE ELECTRONIC DOOR LOCKS INTERMITTENTLY LOCKED THE CONTACT OUT OF THE VEHICLE. THE FRONT DRIVER'S SIDE AND REAR DRIVER'S SIDE DOORS FAILED TO UNLOCK ELECTRONICALLY OR MANUALLY. THE CONTACT MENTIONED THAT THE KEY WAS USED IN ORDER TO UNLOCK THE FRONT PASSENGAR'S AND REAR PASSENGAR'S SIDE DOORS MANUALLY. THE CONTACT ENTERED THE VEHICLE FROM THE FRONT PASSENGERS SIDE OCASSIONALLY. IN ADDITION, THE CONTACT HAD NOTICED THAT THE REAR END OF THE FRAME HAD RUSTED AND CORRODED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 143,000.
NHTSA ODI #10588981
168,000 miles · Jun 22, 2011
Electrical SystemFuel System, Gasoline
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT NOTICED FUEL WAS LEAKING FROM THE VEHICLE AND WHILE DRIVING THE FUMES ENTERED THE VEHICLE. THE FUEL GAUGE WAS INOPERABLE AND SHE WAS UNABLE TO DETERMINE HOW MUCH GASOLINE WAS IN THE VEHICLE. THE DEALER NOR MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS TAKEN TO A PRIVATE ME…
Read full complaint
TL* THE CONTACT OWNS A 1998 ISUZU RODEO. THE CONTACT NOTICED FUEL WAS LEAKING FROM THE VEHICLE AND WHILE DRIVING THE FUMES ENTERED THE VEHICLE. THE FUEL GAUGE WAS INOPERABLE AND SHE WAS UNABLE TO DETERMINE HOW MUCH GASOLINE WAS IN THE VEHICLE. THE DEALER NOR MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO INSPECTED THE VEHICLE AND CONFIRMED THAT THERE WAS A HOLE IN THE TOP OF THE FUEL TANK AND THE FUEL GAUGE WAS FAULTY. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 168,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10408480
140,000 miles · Dec 17, 2010
Electrical System
STARTING THE VEHICLE BECAME DIFFICULT BECAUSE OF ANTI THEFT. TURNING THE KEY TO START THE CAR WOULD NOT ELICIT ANY REACTION AT ALL. THE CAR IS DESIGNED SO THAT WHEN THE CAR IGNITION IS TURNED THIS GROUNDS THE ANTI-THEFT AND THE ELECTRICAL SIGNAL THEN CAN PASS TO THE STARTER. TO FIX THE PROBLEM WE GROUNDED THE ANTI-THEFT PERMAN…
Read full complaint
STARTING THE VEHICLE BECAME DIFFICULT BECAUSE OF ANTI THEFT. TURNING THE KEY TO START THE CAR WOULD NOT ELICIT ANY REACTION AT ALL. THE CAR IS DESIGNED SO THAT WHEN THE CAR IGNITION IS TURNED THIS GROUNDS THE ANTI-THEFT AND THE ELECTRICAL SIGNAL THEN CAN PASS TO THE STARTER. TO FIX THE PROBLEM WE GROUNDED THE ANTI-THEFT PERMANENTLY TO THE BODY FROM THE ENGINE MOUNTED FUSE BOX. *TR
NHTSA ODI #10371022
258 miles · May 5, 2008
Electrical System
TL*THE CONTACT OWNS A 1998 ISUZU RODEO. WHEN ATTEMPTING TO USE THE HORN THE SOUND, THE VOLUME WAS VERY LOW AND OTHER VEHICLES WERE UNABLE TO HEAR IT. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT MILEAGE WAS 100,000 AND THE FAILURE MILEAGE WAS AT 258.
NHTSA ODI #10226722
100,000 miles · Feb 2, 2008
Electrical SystemFuel System, Gasoline
FUEL GAUGE BEGAN READING ERRONEOUS. REPLACED FUEL SENDING UNIT LOCATED INSIDE FUEL TANK BUT STILL ONLY READS 1/8 OF A TANK WHEN FULL. I BELIEVE THE VEHICLE MUST BE REPROGRAMMED BY THE DEALER FOR THIS PARTICULAR MODEL YEAR. I HAVE TO GO BY THE MILES DRIVEN TO ESTIMATE NEXT FUEL STOP. *TR
NHTSA ODI #10216770
139,950 miles · Sep 8, 2006
Electrical System
DT*: THE CONTACT STATED, THE KEY WOULD NOT COME OUT OF THE IGNITION AFTER THE IGNITION WAS TURNED OFF AND HAD BEEN LODGED THERE FOR 5 DAYS. THE CONTACT NOTIFIED THE SERVICE DEALER WHO DETERMINED THE PROBLEM WAS WITH THE CABLE COMING FROM THE TRANSMISSION TO THE IGNITION. THE MANUFACTURER WAS NOTIFIED.
NHTSA ODI #10167675
98,651 miles · Dec 29, 2005
Electrical SystemEngine And Engine CoolingFire
DT: THE CONTACT STATED H VEHICLE BURNED TO THE GROUND AFTER IT STALLED. THE FIRE ORIGINATED FROM UNDER THE HOOD. THE CONTACT HAD NO PROBLEMS WITH THE VEHICLE PRIOR TO THE INCIDENT. HE TOOK THE VEHICLE TO DEALER FOR AN OIL CHANGE LESS THAN TWELVE HOURS PRIOR TO THE FIRE. A POLICE REPORT WAS TAKEN. THE FIRE DEPARTMENT DID RESP…
Read full complaint
DT: THE CONTACT STATED H VEHICLE BURNED TO THE GROUND AFTER IT STALLED. THE FIRE ORIGINATED FROM UNDER THE HOOD. THE CONTACT HAD NO PROBLEMS WITH THE VEHICLE PRIOR TO THE INCIDENT. HE TOOK THE VEHICLE TO DEALER FOR AN OIL CHANGE LESS THAN TWELVE HOURS PRIOR TO THE FIRE. A POLICE REPORT WAS TAKEN. THE FIRE DEPARTMENT DID RESPOND. THE POLICE REPORT INDICATED THE FIRE WAS OF AN ELECTRICAL NATURE. *AK UPDATED 02/24/06. *JB
NHTSA ODI #10146349
80,000 miles · Mar 30, 2004
Electrical SystemLatches/locks/linkages
INTERMITTENTLY CONSUMER WAS UNABLE TO REMOVE THE KEY OUT OF THE IGNITION SWITCH. ALSO, DOORS UNLOCKED FROM THE INSIDE. THE POWER LOCKS DID NOT WORK THE WAY THEY WERE DESIGNED TO WORK.*AK
NHTSA ODI #10065279
55,000 miles · Oct 23, 2003
Electrical SystemFire
WHILE DRIVING ABOUT 60 MPH ON THE HIGHWAY, SMOKE WAS COMING FROM UNDERNEATH THE VEHICLE. *AK
NHTSA ODI #10044609
88,000 miles · Aug 13, 2003
Electrical System
VEHICLE REGISTRATION WAS INCORRECT WHICH CAUSED THE RECALL NOTICE 98 V 170 000 TO GO TO AN INCORRECT ADDRESS. THE DEFECT OCCURRED, AND MANUFACTURER WAS REFUSING TO HONOR THE RECALL BASED ON THE CAMPAIGN ENDING.*AK
NHTSA ODI #10033838
Official recalls
4Sep 22, 2010
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Mar 2, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Jul 24, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence & remedy
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Nov 13, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequence & remedy
Consequence: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: ISUZU IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE98054 · Broken Accelerator Pedal
Opened Oct 9, 1998 · Closed Feb 18, 1999
Status: closed (inferred from source dates) · Power Train
COMPLAINTS ALLE THAT THE HONDA PASSPORT (THE HONDA PASSPORT AND ISUZU RODEO ARE SIMILAR VEHICLES, BOTH MANUFACTURED BY ISUZU) ACCELERATOR PEDAL SEPARATES FROM THE PEDAL LINKAGE.
PE98051 · Braking System/abs
Opened Sep 23, 1998 · Closed Mar 31, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration