Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
1 reports
36,000 miles · Jun 20, 2007
Service Brakes, Hydraulic
PREMATURE AND EXCESSIVE BRAKE WEAR ON ROTORS AND PADS ON A 2005 4200 INTERNATIONAL TRUCK. IT HAD CRITICAL INNER BRAKE PAD AND ROTOR WEAR ON THE FRONT AND REAR. FRONT LEFT ROTOR AND PAD WEAR WAS DUE TO FAILURE OF CALIPER, CAUSING THE TRUCK TO SNAP INTO ONCOMING TRAFFIC WHEN UNDER BRAKING. RIGHT FRONT WEAR TO BOTH ROTOR AND PAD …
Read full complaint
PREMATURE AND EXCESSIVE BRAKE WEAR ON ROTORS AND PADS ON A 2005 4200 INTERNATIONAL TRUCK. IT HAD CRITICAL INNER BRAKE PAD AND ROTOR WEAR ON THE FRONT AND REAR. FRONT LEFT ROTOR AND PAD WEAR WAS DUE TO FAILURE OF CALIPER, CAUSING THE TRUCK TO SNAP INTO ONCOMING TRAFFIC WHEN UNDER BRAKING. RIGHT FRONT WEAR TO BOTH ROTOR AND PAD DUE TO SLIDE PINS ON CALIPER NOT RETURNING PADS TO NORMAL POSITION. TRUCK HAD COMPLETE REAR ROTORS AND PAD DESTROYED DUE TO NONE SLIDING SLIDE PINS. PASSENGER REAR ROTOR INNER BRAKING SURFACE WAS GROUND DOWN TO 1/8 INCH WHILE THE OUTER SURFACE APPEARED TO BE WITHIN NORMAL SPECIFICATIONS. TRUCK ONLY HAS 36,693 MILES. *AK
NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2003 THROUGH 2010 INTERNATIONAL TRUCKS AND IC COMMERCIAL BUSES MANUFACTURED FROM DECEMBER 4, 2001 THROUGH DECEMBER 14, 2009 EQUIPPED WITH INTERNATIONAL VT365 ENGINES HAVING ENGINE CALIBRATION PAN2PVR0, PAN2PVR1, OR PAN2PWR. THE ENGINE NORMALLY RESPONDS TO A FAILED OPEN ACCELERATOR POSITION SENSOR CIRCUIT FAULT BY RETURNING THE ENGINE TO LOW IDLE SPEED OF 800 RPM AND DISABLING THE DRIVER'S ABILITY TO INCREASE THE ENGINE SPEED. HOWEVER IF THE OPEN CIRCUIT CORRECTS ITSELF WITHIN 30 SECONDS OF INITIATION, ENGINE SPEED COULD SUDDENLY INCREASE TO A HIGH IDLE SPEED OF 1200 RPM.
Consequence & remedy
Consequence: THIS INCREASE TO HIGH IDLE SPEED MAY OCCUR WITHOUT WARNING CAUSING A SUDDEN AND UNEXPECTED SHIFT IN VEHICLE POSITION POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 1, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.
CERTAIN MY 2005 THROUGH 2006 INTERNATIONAL HEAVY TRUCKS AND IC CORP CE SCHOOL BUSES MANUFACTURED BETWEEN JUNE 4, 2004, AND MARCH 31, 2005. THE ANCHOR BOLT THAT IS THE PIVOT POINT FOR THE DRIVELINE PARKING BRAKE SHOES MAY FATIGUE AND BREAK AS A RESULT OF AN INCORRECT SURFACE TREATMENT.
Consequence & remedy
Consequence: IF THE BOLT BREAKS, THE PARK BRAKE MAY NOT ENGAGE. THIS COULD CAUSE THE VEHICLE TO ROLL AWAY WITHOUT WARNING AND COULD RESULT IN A VEHICLE CRASH, POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Remedy: INTERNATIONAL RECALL NO. 00518. INTERNATIONAL WILL NOTIFY OWNER AND REPLACE THE AFFECTED ANCHOR BOLTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 14, 2005. CUSTOMERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.
ON CERTAIN TRUCKS BUILT WITH IROS REAR AIR SUSPENSION SYSTEMS, FOUR REAR SUSPENSION FASTENERS MAY NOT BE TIGHTENED SUFFICIENTLY. THIS HARDWARE CONNECTS THE MAIN SUPPORT MEMBERS OF THE REAR SUSPENSION TO THE HANGER BRACKETS.
Consequence & remedy
Consequence: THIS CONNECTION COULD FAIL IF THE NUTS WORKED THEIR WAY LOOSE OR OFF, OR THE BOLTS BROKE FROM FATIGUE. A FAILURE OF THESE FASTENERS COULD RESULT IN SEPARATION OF THE MAIN SUPPORT FROM THE HANGER BRACKET POSSIBLY RESULTING IN A SUDDEN LOSS OF CONTROL OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE ALL FOUR BOLTS AND TIGHTEN THE BOLTS PROPERLY. THE RECALL BEGAN ON NOVEMBER 5, 2004. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 International 4200 Problems, Complaints & Recalls | Skip That Year
Illustration