IllustrationTL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT STATED THAT WHILE OPENING THE HATCH DOOR, THE REAR GLASS WINDOW SEPARATED FROM THE FRAME. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF FAILURE. THE FAILURE MILEAGE WAS 118,000.
2005 Hyundai Tucson
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Hyundai Tucson do not stand out strongly from the model-year median of 180.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tucson years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
380–25K
2025–50K
2550–75K
1575–100K
24100–150K
17150K+
139 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports3 fire reports11 injury reports
Visibility complaints
9 reportsAS I WAS DRIVING DOWN THE HIGHWAY, I NOTICED THAT ONE OF THE WINDOWS IN MY 2005 HYUNDAI TUCSON SOUNDED LIKE IT HAD BEEN ROLLED DOWN. ALMOST IMMEDIATELY, MY DAUGHTER YELLED, "OUR WINDOW IS COMING OFF!" I HAD JUST ENOUGH TIME TO LOOK IN MY REARVIEW MIRROR TO SEE THE RIGHT REAR QUARTER PANEL WINDOW BEING HELD ON BY JUST A SMALL STR…
Read full complaint
AS I WAS DRIVING DOWN THE HIGHWAY, I NOTICED THAT ONE OF THE WINDOWS IN MY 2005 HYUNDAI TUCSON SOUNDED LIKE IT HAD BEEN ROLLED DOWN. ALMOST IMMEDIATELY, MY DAUGHTER YELLED, "OUR WINDOW IS COMING OFF!" I HAD JUST ENOUGH TIME TO LOOK IN MY REARVIEW MIRROR TO SEE THE RIGHT REAR QUARTER PANEL WINDOW BEING HELD ON BY JUST A SMALL STRIP OF SOME SORT OF ADHESIVE. IN LESS THAN A SECOND, THE WINDOW FLEW OFF, BEGAN PINWHEELING THROUGH THE AIR AND NARROWLY MISSED THE VEHICLE JUST BEHIND ME. EVEN THE REPAIRMAN AT THE HYUNDAI DEALERSHIP THAT REPLACED THE WINDOW FOR ME WAS SPEECHLESS WHEN I TOLD HIM WHAT HAPPENED. I CONTACTED HYUNDAI, AND ALL THEY WOULD TELL ME IS THAT MY CAR IS OUT OF WARRANTY. WHILE IT WOULD HAVE BEEN NICE FOR THEM TO OFFER TO PAY FOR THE REPAIR, I WAS MUCH MORE CONCERNED WITH THEIR LACK OF CONCERN FOR ANYTHING OTHER THAN THE FACT THAT THE VEHICLE WAS OUT OF WARRANTY. THEY DID NOT ASK FOR ANY DETAILS OR OFFER ANY CONCERN FOR THE POSSIBLE DAMAGE AND/OR LOSS OF LIFE THAT COULD EASILY HAVE OCCURRED HAD THAT WINDOW HIT THE CAR BEHIND ME. *TR
THE REAR WINDOW HINGES RUST OUT. ONE HINGE RUSTED OUT AND NOW THE OTHER. IF BOTH HAD GONE THE WINDOW WOULD HAVE FALLEN OUT, IF ON THE HIGHWAY COULD HAVE BEEN QUITE SERIOUS. *TR
MY 2005 HUNDAI TUSCON SEEMS TO BE OF VERY POOR QUALITY. I RARELY USE THE BACKHATCH WINDOW, MAYBE 5 TIMES IN THE PAST 10MONTHS. THE PASSENGER SIDE HINGE BROKE AND IS TOTALLY CORRODED (SP?) BY JUST OPENING IT AN INCH BY MISTAKE AND CLOSING IT, IT SNAPPED RIGHT OFF. HYUNDAI DEALER SAYS "WELL IT IS 6YRS OLD". I ALSO HAVE HAD AN …
Read full complaint
MY 2005 HUNDAI TUSCON SEEMS TO BE OF VERY POOR QUALITY. I RARELY USE THE BACKHATCH WINDOW, MAYBE 5 TIMES IN THE PAST 10MONTHS. THE PASSENGER SIDE HINGE BROKE AND IS TOTALLY CORRODED (SP?) BY JUST OPENING IT AN INCH BY MISTAKE AND CLOSING IT, IT SNAPPED RIGHT OFF. HYUNDAI DEALER SAYS "WELL IT IS 6YRS OLD". I ALSO HAVE HAD AN ISSUE SINCE I PURCHASED THE VEHICLE WHERE THE POWER LOCKS GO ON AND OFF ON THEIR OWN AND THERE IS SOMETHING RANDOMLY DRAINING THE BATTERY IF IT IS NOT DRIVEN EVERY 24-48HRS. IT APPEARS BOTH OF THESE ISSUES HAVE BEEN APPARENT FOR MANY 2005 TUSCON OWNERS, AND HYUNDAI IS FAILING TO ACKNOWLEDGE THESE FACTORY ISSUES WHICH SHOULD HAVE BEEN RECALLED IN MY OPINION. *TR
2005 HYUNDAI TUCSON, PURCHASED USED. BOTH SUN VISORS ARE CRACKED WHERE THEY ATTACH TO THE VEHICLE. THE DRIVERS SIDE VISOR CANNOT BE USED AS IT SWINGS FREELY AND OBSTRUCTS VISION. THE PASSENGER SIDE IS CRACKED IN EXACTLY THE SAME WAY. THE SONATA VISORS WERE RECALLED, THE TUCSON APPEARS TO BE THE SAME DESIGN BUT HAS NOT BEEN R…
Read full complaint
2005 HYUNDAI TUCSON, PURCHASED USED. BOTH SUN VISORS ARE CRACKED WHERE THEY ATTACH TO THE VEHICLE. THE DRIVERS SIDE VISOR CANNOT BE USED AS IT SWINGS FREELY AND OBSTRUCTS VISION. THE PASSENGER SIDE IS CRACKED IN EXACTLY THE SAME WAY. THE SONATA VISORS WERE RECALLED, THE TUCSON APPEARS TO BE THE SAME DESIGN BUT HAS NOT BEEN RECALLED AND ARE VERY EXPENSIVE TO REPLACE. LOOKING FOR USED PARTS AT JUNK YARDS WE FOUND ALL OF THE VISORS WERE CRACKED IN THE SAME MANNER. APPEARS TO BE A DANGEROUS, FAULTY DESIGN. *TR
I BOUGHT MY HYUNDAI TUSCON BRAND NEW BACK IN 2005. LAST WEEK I NOTICED A RATTLING SOUND COMING FROM THE REAR WINDSHIELD AND WHEN I WENT TO CHECK IT THE BACK WINDSHIELD ALMOST HAS FALLEN OUT. THE LATCH THAT HOLDS THE WINDSHIELD IN PLACE HAS CORRODED COMPLETELY. I CAN HONESTLY SAY THAT OVER THE 5 YEARS I HAVE OWNED THE VEHICLE I H…
Read full complaint
I BOUGHT MY HYUNDAI TUSCON BRAND NEW BACK IN 2005. LAST WEEK I NOTICED A RATTLING SOUND COMING FROM THE REAR WINDSHIELD AND WHEN I WENT TO CHECK IT THE BACK WINDSHIELD ALMOST HAS FALLEN OUT. THE LATCH THAT HOLDS THE WINDSHIELD IN PLACE HAS CORRODED COMPLETELY. I CAN HONESTLY SAY THAT OVER THE 5 YEARS I HAVE OWNED THE VEHICLE I HARDLY OPEN THE BACK WINDOW. I USUALLY OPEN THE ENTIRE TAILGATE WHEN PLACING ITEMS FOR STORAGE. I HAVE CONTACTED THE DEALER AND HYUNDAI ABOUT THE ISSUE LOOKING TO GET THE LATCH REPLACED AND HAVEN'T HEARD ANYTHING BACK FROM THEM. I HAVE TRIED ON SEVERAL ATTEMPTS SINCE I NOTICE THE PROBLEM. THIS IS DANGEROUS AND COULD CAUSE THE WINDSHIELD TO COME FALLING OUT. *TR
PROBLEMAS CON EL POWER TRAIN. HISTORY = EN EL PRIMER AO SE DAO CD PLAYER LO CAMBIARON PERO EMPECE A TENER DIFICULTADES CON EL HORN POR UN MAL ENTENDIDO CAMBIARON EL CLOCK, HASTA LA FECHA NUNCA ME ARREGLARON EL HORN EL CUAL DEJA Y EMPIEZA A FUNCIONAR EN CUALQUIER MOMENTO. EL VEHICULO EN VECES PRENDIA LA LUZ DEL "CHECK" PERO POR U…
Read full complaint
PROBLEMAS CON EL POWER TRAIN. HISTORY = EN EL PRIMER AO SE DAO CD PLAYER LO CAMBIARON PERO EMPECE A TENER DIFICULTADES CON EL HORN POR UN MAL ENTENDIDO CAMBIARON EL CLOCK, HASTA LA FECHA NUNCA ME ARREGLARON EL HORN EL CUAL DEJA Y EMPIEZA A FUNCIONAR EN CUALQUIER MOMENTO. EL VEHICULO EN VECES PRENDIA LA LUZ DEL "CHECK" PERO POR UNAS HORAS O UN DIA EL DEALER NUNCA ENCONTRO NADA EN VECES TAMBIEN SE DABA COMO JALONES COMO QUE SE QUERIA PARAR, SE LLEGO A PARA 3 VECES, LOS DEL DEALER NUNCA ENCONTRARON NADA SIEMPRE LA LLEVE AHI PARA MANTENIMIENTO Y CAMBIO DE ACEITE, ELLOS COBRAN DEMASIADO POR LOS SERVICIOS, YA CAMBIE HEADLIGHTS 2 VECES Y OTRAS LUCESITAS DEL FRENTE, SE CAMBIO SERPENTINE BELT,BATERIA , LLANTAS, PARABRISAS, FRENOS; EN LOS ULTIMOS 9 MESES CAMBIE A OTRO LUGAR PARA CAMBIO Y CHEQUEO DE FLUIDOS. EL 12/17/09 7AM, PRENDIO A LA 3RD VEZ QUE TRATE FUI Y VINE AL TRABAJO Y CASA SIN PROBLEMAS, POR LA TARDE SALI A LOS 15 MINUTOS SE EMPEZO A JALONEAR Y CADA VES QUE BAJABA LA VELOCIDAD SE QUERIA APAGAR EL MOTOR LO CUAL SUCEDIO AL HACER ALGUN STOP, PERO LA PRENDIA DE NUEVO SIN NINGUN PROBLEMA AL REGRESO A CASA VOLVIO A PARARSE VARIAS VECES, ADEMAS SE PRENDIO LA LUZ DE "CHECK" Y A LOS 5 MINUTOS SE PRENDIO OTRA QUE POR EL SEOR QUE LEVANTO EL VEHICULO SE QUE INDICABA PROBLEMAS EN EL "POWER TRAIN" Y MENCIONO TAMBIEN EL 4X4. TOTAL QUE AL PRENDER ESA LUZ YA NO QUISO LEVANTAR LA MARCHA NOMAS COMO A 1 MILLA POR HORA Y ESO JALONENDOSE MUCHO, BUENO POR UNA U OTRA RAZON YO HABLE HASTA EL 12/29/09 PARA QUE LA LEVANTARAN Y HASTA HOY SE ME COMUNICO QUE TENIA UN SENSOR DAADO ALGO ASI COMO "THROTLE POSITION CENSOR" POR LO CUAL ME QUIEREN COBRAR 455.00 + TAXES. YO NO TENIA IDEA DE ESTE SITIO, Y CREO QUE TENIA DERECHO DE QUE SE ME COMUNICARA EN EL DEALER ACERCA DE TODOS LOS RECALLS PARA ESTE TIPO DE VEHICULO, ESTOY INSATISFECHA CON EL VEHICULO Y POR LOS ALTOS COSTOS DE MANTENIMIENTO QUE HE TENIDO QUE PAGAR DE ALGO QUE YA SABIAN QUE EXISTIA. NECESITO AYUDA URGENE, PLEASE. *TR RECEIVED COMPLAINT WRITTEN IN ENGLISH.
THE BACK HATCH WINDOW OF MY 2005 TUSCON BROKE, SENDING THE RIGHT 1/2 OF THE WINDOW FLYING DOWN ABOUT 2 FEET. THE BACK DOOR/HATCH LATCH IS ALSO BROKEN, YOU CAN'T SHUT IT WITHOUT PULLING HE LATCH BACK OUT MANUALLY FIRST AFTER OPENING IT. HAS BEEN OVER A MONTH AND 1/2 ;PARTS STILL NOT ALL IN. ALSO,THE GAS CAP LATCH IS RESTED A…
Read full complaint
THE BACK HATCH WINDOW OF MY 2005 TUSCON BROKE, SENDING THE RIGHT 1/2 OF THE WINDOW FLYING DOWN ABOUT 2 FEET. THE BACK DOOR/HATCH LATCH IS ALSO BROKEN, YOU CAN'T SHUT IT WITHOUT PULLING HE LATCH BACK OUT MANUALLY FIRST AFTER OPENING IT. HAS BEEN OVER A MONTH AND 1/2 ;PARTS STILL NOT ALL IN. ALSO,THE GAS CAP LATCH IS RESTED AND I FEAR NEXT TO BREAK. *TR
WAS DRIVING TO WORK IN THE RAIN/SNOW FROM WASH, DC; NOTICE UNUSUAL LOUD WINDSHIELD WIPERS; SUDDENLY NOTICE THAT LEFT WINDSHIELD WIPER WAS WIPING OFF OF THE WINDOW AS IF WERE GOING TO FLY OFF..IT DISTRACTED ME TO POINT OF ALMOST HAVING A COLLISION; CALLED ALEXANDRIA HYUANDAI FROM MY JOB IN FREDERICK, MD AND WAS REFERRED TO IDEAL…
Read full complaint
WAS DRIVING TO WORK IN THE RAIN/SNOW FROM WASH, DC; NOTICE UNUSUAL LOUD WINDSHIELD WIPERS; SUDDENLY NOTICE THAT LEFT WINDSHIELD WIPER WAS WIPING OFF OF THE WINDOW AS IF WERE GOING TO FLY OFF..IT DISTRACTED ME TO POINT OF ALMOST HAVING A COLLISION; CALLED ALEXANDRIA HYUANDAI FROM MY JOB IN FREDERICK, MD AND WAS REFERRED TO IDEAL HYUANDAI WHERE THE SRV REP DIAGNOSED THE VRH AS HAVING A DEFECTIVE W/S TRANSMISSION...SAID IT WOULD TAKE SIX WKS, THEN TWO WKS O GET THE PART FOR THIS NEW SUV...I REALLY DON'T FEEL SAFE, AND WANT TO RETURN IT!*AK
Official recalls
809V280000 · Exterior Lighting
Jul 21, 2009
HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A DEFECTIVE STOP LAMP SWITCH MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION WOULD NOT BE ABLE TO BE SHIFT OUT OF THE "PARK" POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: ANY OF THESE MALFUNCTIONS COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 2, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO CUSTOMER SERVICE AT 1-787-999-4310.
09V122000 · Exterior Lighting:brake Lights:switch
Apr 15, 2009
HYUNDAI IS RECALLING 532,633 MY 2006-2007 ACCENT, ENTOURAGE, SONATA, MY 2007 AZERA, ELANTRA AND SANTA FE, MY 2005-2007 TUCSON AND MY 2007-2008 VERACRUZ VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
07V197000 · Air Bags:frontal:driver Side:inflator Module
May 8, 2007
ON CERTAIN VEHICLES, STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED THAT A SMALL STATURE ADULT DRIVER NOT WEARING A SEAT BELT AND INVOLVED IN A FRONTAL OR NEAR FRONTAL CRASH, THE DEPLOYMENT OF THE DRIVER AIR BAG MAY NOT OCCUR.
Consequence & remedy
Consequence: THIS CAN CAUSE INCREASED RISK OF INJURY TO THE DRIVER UNDER CERTAIN CRASH CONDITIONS.
Remedy: DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE WITH ONE THAT IS DESIGNED TO PROVIDE AN INCREASED MARGIN OF COMPLIANCE FOR LOW RISK DEPLOYMENT FOR SMALL STATURE ADULTS WHO ARE NOT PROPERLY WEARING THE SEAT BELTS. THE RECALL BEGAN ON SEPTEMBER 6, 2007, AND WILL BE PERFORMED IN TWO MAILINGS. OWNERS MAY CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
06V445000 · Air Bags:frontal:driver Side:inflator Module
Nov 22, 2006
ON CERTAIN SPORT UTILITY VEHICLES, DURING STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED IF A SMALL STATURED ADULT DRIVER, NOT WEARING A SEAT BELT, IS INVOLVED IN A FRONTAL OR NEAR FRONTAL CRASH, DEPLOYMENT OF THE DRIVER AIR BAG MAY RESULT IN AN INSUFFICIENT MARGIN OF COMPLIANCE AS MEASURED BY THE TEST DUMMY USED IN THE NHTSA TEST.
Consequence & remedy
Consequence: THIS CAN CAUSE INCREASED RISK OF INJURY TO THE DRIVER UNDER CERTAIN CRASH CONDITIONS.
Remedy: DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE. THE RECALL BEGAN ON JANUARY 29, 2007, AND WILL BE CONDUCTED THROUGH SIX MAILINGS. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
05V342000 · Parking Brake
Jul 27, 2005
ON CERTAIN PASSENGER VEHICLES, THE PARKING LEVER RATCHET PAWL WAS NOT PROPERLY MANUFACTURED AND MAY DAMAGE THE TEETH OF THE PARKING LEVER RATCHET. DAMAGED PARKING BRAKE LEVER RATCHET TEETH MAY PREVENT THE PARKING BRAKE FROM ENGAGING OR MAY ALLOW THE PARKING BRAKE TO RELEASE AFTER IT HAS BEEN ENGAGED.
Consequence & remedy
Consequence: THE INABILITY TO ENGAGE OR THE INADVERTENT RELEASE OF THE PARKING BRAKE LEVER, MAY ALLOW YOUR VEHICLE TO ROLL WHILE IT IS PARKED AND MAY RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE PARKING BRAKE LEVER ASSEMBLY. THE RECALL BEGAN ON SEPTEMBER 12, 2005. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.
05V315000 · Parking Brake
Jul 7, 2005
ON CERTAIN SPORT UTILITY VEHICLES, THE PARKING BRAKE LEVER RATCHET PAWL WAS NOT PROPERLY MANUFACTURED AND MY DAMAGE THE TEETH OF THE PARKING BRAKE LEVER RATCHET. DAMAGED PARKING BRAKE LEVER RATCHET TEETH MAY PREVENT THE PARKING BRAKE FROM ENGAGING OR MAY ALLOW THE PARKING BRAKE TO RELEASE AFTER IT HAS BEEN ENGAGED.
Consequence & remedy
Consequence: THE INABILITY TO ENGAGE, OR THE INADVERTENT RELEASE OF, THE PARKING BRAKE LEVER MAY ALLOW YOUR VEHICLE TO ROLL WHILE IT IS PARKED AND MAY RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE PARKING BRAKE LEVER ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
05V177000 · Electronic Stability Control:automatic (asc)
Apr 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ELECTRONIC STABILITY PROGRAM (ESP), THE YAW RATE SENSOR MAY BECOME TOO SENSITIVE AND MAY RECALIBRATE INACCURATELY. WHILE DRIVING THE ESP PROGRAM MAY CAUSE THE ENGINE TO REDUCE POWER AND MAY CAUSE A BRAKE AT ONE OF THE WHEELS TO BE INAPPROPRIATELY.
Consequence & remedy
Consequence: BRAKE APPLICATION CAUSED BY INADVERTENT ESP ACTIVATION MAY RESULT IN LOSS OF CONTROL AND A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ESP HYDRAULIC ELECTRONIC CONTROL UNIT. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2005. OWNERS MAY CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
05V119000 · Electronic Stability Control:automatic (asc)
Mar 25, 2005
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ELECTRONIC STABILITY PROGRAM (ESP), THE YAW RATE SENSOR MAY BECOME TOO SENSITIVE AND MAY RECALIBRATE INACCURATELY. WHILE DRIVING THE ESP PROGRAM MAY CAUSE THE ENGINE TO REDUCE POWER AND MAY CAUSE A BRAKE AT ONE OF THE WHEELS TO BE INAPPROPRIATELY.
Consequence & remedy
Consequence: BRAKE APPLICATION CAUSED BY INADVERTENT ESP ACTIVATION MAY RESULT IN LOSS OF CONTROL AND A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ESP HYDRAULIC ELECTRONIC CONTROL UNIT FREE OF CHARGE. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE09003 · Stop Lamp Switch Failure
Opened Jan 14, 2009 · Closed Apr 24, 2009
Status: closed (inferred from source dates) · Electronic Stability Control; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Power Train:automatic Transmission:lever And Linkage:column Shift; Power Train:automatic Transmission:lever And Linkage:floor Shift; Power Train:manual Transmission:column Shift Assembly; Power Train:manual Transmission:floor Shift Assembly; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:pedals And Linkages; Vehicle Speed Control:cruise Control
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (10)
Electronic Stability Control
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights:switch
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:automatic Transmission:lever And Linkage:column Shift
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:automatic Transmission:lever And Linkage:floor Shift
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:manual Transmission:column Shift Assembly
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:manual Transmission:floor Shift Assembly
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Service Brakes, Hydraulic:pedals And Linkages
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Vehicle Speed Control:cruise Control
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.