2021 Hyundai Sonata

I was notified of a recall on my from vehicle by Hyundai via email some time in March of 2026. The message said mentioned my vehicle may have a defective/worn purge control check valve that would cause the fuel tank to deform. Potentially leading to a release of fuel over time, which then could ignite. NHTSA Recall #25V796000 My car showed now signs of problems, but I brought it into a Hyundai dealership on March 13th where they confirmed my vehicle had the issue. They said the situation required I not drive my vehicle and gave me a rental in the meantime. I assumed it would be a simple swap of the fuel tank and everything would be fine. I was offered a buyback from my Hyundai claims manager over the situation, but I figured since its a simple fix, I'd keep my car and have it fixed. Two weeks went by with no update from the dealership, so I walked in for answers. Turns out, the subframe of my car has been damaged by the expanding fuel tank and they are still waiting for updates from Hyundai on how to proceed as they themselves don't know how to fix my vehicle. My Hyundai claims manager did not mention this when we talked over the phone and he offered a buyback. None of their recall notices mention structural damage anywhere or even as a possibility. I asked the dealership again on April 1, 2026, and they are still waiting on guidance on how to proceed. Neither does my Hyundai claims manager handling this situation on their end.

The internal core of the Exhaust Heat Recovery System (EHRS), part of the center muffler/front pipe assembly (#28600-L5210), suffered a catastrophic failure. This allowed approximately 9 gallons of engine coolant to leak directly into the hot exhaust stream. Safety Risk: This failure creates a severe visibility hazard. During acceleration from stop lights and stop signs, the vehicle emits massive, thick clouds of white glycol smoke. The smoke is so dense that it completely obscures the driver's view of trailing vehicles and prevents following drivers from seeing the roadway or my vehicle's brake lights, creating a high risk of rear-end collisions. Additionally, the rapid loss of coolant caused the engine to overheat and lose power while in motion, nearly causing a stall in active traffic. Confirmation: The failure was confirmed by the service department at Washington Hyundai (Invoice #174281). This is the second failure of this specific component (previously failed in Jan 2025). The manufacturer issued TSB 23-EM-009H for this defect, acknowledging it affects 2020-2023 Sonata Hybrids, but no safety recall has been issued. Symptoms: The issue was preceded by a "sweet" burning smell and a sudden "Engine Overheating" warning on the dashboard. The failed component has been replaced by the dealer, but the manufacturer refused to replace the coolant-poisoned Oxygen (O2) sensors, leaving the vehicle in a technically compromised state. The failed unit is likely held by the dealer for warranty parts return.

The contact owns a 2021 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); and the vehicle was taken to the dealer for the recall repair; however, the dealer informed the contact that the vehicle was unrepairable, and there was no further information provided. The manufacturer was made aware of the issue, and a case was filed. The manufacturer informed the contact that the field engineers had reviewed the vehicle and advised that a buyback was the best option. Additionally, the manufacturer offered an 8 percent discount on the purchase of a new vehicle. The contact declined the offer because the vehicle had not experienced a failure, and the vehicle would be paid off after two additional payments.

Hyundai technical service bulletin 23-EM-009H (EHRS COOLANT LEAK) - AKA a faulty heat exchange that causes the coolant to leak into the exhaust and burn away. Resulting in a very hard to diagnose coolant disappearance. This should be a recall. They have literally already acknowledged a manufacturer defect with the service bulletin. The problem is that in most cases, it occurs out of the 60k or 100k warranty. The dealer seems to have discretion as to which of the mileage limits apply. One dealer in NC told me 60k and my local in SC told me 100k. My problem started at ~90k, but was just topped off on fluid and repaired as "normal evaporation". Now 12k later at 102k, they acknowledged the TSB but claimed I was out of warranty. With me being out of warranty, they claimed that Hyundai would not send them tsb parts and that I would need to replace the whole system with the normal skus around $3k.

The contact owns a 2021 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle was driven to the shoulder of the road. The contact stated that the fuel level indicated empty, and the low fuel warning light was illuminated. The passenger seated in the rear seat noticed that the rear seat was out of place and that the seat was very hot. The vehicle was refueled prior to the failure. The contact and the other occupants in the vehicle exited the vehicle. The vehicle was towed to the residence. The dealer was made aware of the failure. The contact was informed that the failure was like the failure listed in NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline). The contact was unaware of the open recall because a recall notification was not received. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

The contact owns a 2021 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

On i believe 1/14/26, my check engine light came on. Scheduled appt.for 1/16/26 for diagnostic. Several things were wrong. I decided to come back due to not having the money at the time. Over the wked, I remembered a recall notice i received around November that I asked about in November during my oil change & was told the parts aren't in & they'd give me a call. Upon viewing the recall it seemed some things I was told on 1/16/26 could be a result of the recall. I called my service person Linda on 1/20/26, she spoke to her supervisor & they informed me some of the issues seem to stem from the recall. Linda gave me the manufacturer recall contact information. I contacted them on 1/20/26. She explained there was indeed a recall, there wasn't a remedy yet, it was safe to drive & if something changes, to call back. On 1/28/26 around 5:30am I left home for work & my car all of a sudden experienced a loss of power. It wouldn't go past 30mph. I returned back home & called out of work. I called the manufacturer recall & informed them. She made an appt. to take my car in the follow day, 1/29/26. I decided to drop it off that same day, 1/28/26. I had someone follow me being i could only go 30mph on a flat road & 10mph on a slight hill. I found out my service person Linda was no longer employeed there. I spoke with another employee. He said they would have to do another diagnostic. I left my car. I called the dealership on 1/29/26 for an update, they had not looked at my car. I called the manufacturer recall, they assigned a case manger to my case. Jay from the NCA, called me on 1/30/26 I believe. We've communicated several times without me receiving a adequate update. He's saying the issue seems to be steamed from the recall, there is now remedy yet, & they are still investigating. I've been without a car since 1/28/26, still making payments, missing work, haven't been offered a loaner & have no idea when or if I will get my car back.

The EHRS coolant system failed and had a leak causing the coolant to be excessively burned off as thick white smoke. This caused me to not be able to see anything behind me and forced others to stop or slow down dramatically to avoid colliding with me. I had my engine overheat and force me to pull over on the side of an unsafe road because the exhaust system burned off my entire tank of coolant in less than a mile. I have taken this to a Hyundai dealership and they confirmed it was the EHRS system failure and told me it was a fairly known issue with the 2020-2023 Sonata Hybrids. I was told that even if I get it replaced the possibility of having it happen again are pretty high. This seems extremely unsafe to myself and others.

Vehicle suddenly lost heat in 30 degree weather. No warnings, check engine light, or temperature gauge indicators came on. Lucky made it to a parts store and found out I was extremely low on coolant. Bought coolant and put it in. Made it back to the house and was immediately low again. No visible leaking. Oil was completely fine (1 gallon of coolant would have have left some kind indicator). Realized it was more than likely the ehrs. If this happened during the summer, my engine could have blown due to a poor design causing a major accident.