IllustrationPaint on hood of car is peeling off, down to bare metal
2020 Hyundai Sonata
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2020 Hyundai Sonata do not stand out strongly from the model-year median of 161.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sonata years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
360–25K
725–50K
250–75K
675–100K
3100–150K
0150K+
54 reports with mileage · 124 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports1 fire reports4 injury reports
What owners actually said
178 reportsWhile driving my cars a light starting blinking and my engine light came on and the car lost power This has happened on at least 3 occasions and I had to pull over upon starting the car after a few hours all returned to normal I reported this to dealer and they could not find a problem
I took my vehicle into the dealership when it was under 12,000 miles for another issue and mentioned a problem with the headlight on the right fogging up with moisture. I was immediately told that this had to be seen with their eyes because light cost more than $1,000. It has continued for over 1 1/2 years. Early this month, I t…
Read full complaint
I took my vehicle into the dealership when it was under 12,000 miles for another issue and mentioned a problem with the headlight on the right fogging up with moisture. I was immediately told that this had to be seen with their eyes because light cost more than $1,000. It has continued for over 1 1/2 years. Early this month, I took a picture at night and in the morning. The service manager wanted to add another hoop; can you get a picture of the water in it? The water is droplets on the light, decreasing visibility on the road. Pictures are attached. There is one picture that shows the left headlight with no issue.
2020 HYUNDAI SONATA. CONSUMER WRITES IN REGARD TO GRINDING NOISE WHILE DRIVING. THE CONSUMER STATED UPON INSPECTION BY TOYOTA, IT WAS DISCOVERED THAT THE UNDERSHIELD HAD COME LOOSE AND DRAGGING.
2020 Sonata......Steering wheel has started to make a raspy, rubbing noise when turned. When researching this problem on U tube, it is apparently a fairly common problem with Hyundai vehicles. The fix requires that a bearing in the steering be replaced. If not replaced I would imagine that the bearing would eventually seize …
Read full complaint
2020 Sonata......Steering wheel has started to make a raspy, rubbing noise when turned. When researching this problem on U tube, it is apparently a fairly common problem with Hyundai vehicles. The fix requires that a bearing in the steering be replaced. If not replaced I would imagine that the bearing would eventually seize up and the car could not be steered. I checked with local dealership and they were not aware of the problem and couldn't tell me if it would be covered by my warranty. I only have 9500 miles on the vehicle.
The Panoramic sunroof has a line fracture crack which exploded for unknown reasons. A rock or any foreign object DID NOT hit the sunroof to cause it to shatter. Residue from the glass shattering got into my eyes. Freeman Hyundai stated that an object hit the sunroof it would not be covered under their warranty. A object did not…
Read full complaint
The Panoramic sunroof has a line fracture crack which exploded for unknown reasons. A rock or any foreign object DID NOT hit the sunroof to cause it to shatter. Residue from the glass shattering got into my eyes. Freeman Hyundai stated that an object hit the sunroof it would not be covered under their warranty. A object did not hit the sunroof and it looks like Hyundai has a history of sunroof shattering unexpectedly. There were no warning signs prior to the sunroof shattering.
The AC Fan in my car quit working. Took it to a repair shop where I was told that the AC Blower Motor went bad. The blower motor was drawing too much amps and caused the blower motor fuse to melt into the wiring harness for the blower motor along with melting several other fuses nearby including the fuse box. The cost to repa…
Read full complaint
The AC Fan in my car quit working. Took it to a repair shop where I was told that the AC Blower Motor went bad. The blower motor was drawing too much amps and caused the blower motor fuse to melt into the wiring harness for the blower motor along with melting several other fuses nearby including the fuse box. The cost to repair this correctly fixing and addressing all parts damaged was $5000. Because my vehicle is out of warranty due to mileage I contacted Hyundai who stated that I had to go and pay another diagnostic fee at a Hyundai Dealership to have them look at it. They continued to tell me that the vehicle was out of warranty but would not assist in providing information to get the issue resolved at no cost to me.
Steering parts being replaced many times, and the engine oil is low after I just got an oil change a week ago. Excessive engine oil usage with no idea where it is going.
The contact owns a 2020 Hyundai Sonata. The contact stated that while her husband was driving 75 MPH, the brake warning light appeared on the instrument panel as the vehicle began to hesitate upon depression of the accelerator pedal. The contact stated that the vehicle decelerated to 20 MPH as her husband pulled to the side of t…
Read full complaint
The contact owns a 2020 Hyundai Sonata. The contact stated that while her husband was driving 75 MPH, the brake warning light appeared on the instrument panel as the vehicle began to hesitate upon depression of the accelerator pedal. The contact stated that the vehicle decelerated to 20 MPH as her husband pulled to the side of the highway and turned off the vehicle. The contact called the dealer and was given suggestions on how to correct the failure; however, none of the options worked. After some time, her husband restarted the vehicle and the vehicle resumed normal operation. The next day, the contact stated that the brake light returned upon start of the vehicle. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 19,000.
When accelerating hard (pedal to the floor) from approximately 55 mph, the transmission may not downshift correctly and loses power causing a safety issue. When attempting to continue accelerate at full throttle, the RPMs hang while simultaneously losing vehicle speed. Other symptoms noticed were slight vehicle jerkiness from RP…
Read full complaint
When accelerating hard (pedal to the floor) from approximately 55 mph, the transmission may not downshift correctly and loses power causing a safety issue. When attempting to continue accelerate at full throttle, the RPMs hang while simultaneously losing vehicle speed. Other symptoms noticed were slight vehicle jerkiness from RPMs bouncing up and down a couple of hundred RPMs. When letting off of the accelerator to a "normal" depression level, the vehicle upshifts into an appropriate gear and will gain speed (though sluggish). In the same drive (meaning the ignition was not turned off then back on) , if attempting to push accelerator to the floor, the same results happen as stated before. Also in the same drive (after exiting the highway), from a stop at a red light I tested the issue again with the same results. No warning lights, messages, or other symptoms were present to indicate a malfunction. My safety was at risk because I merged onto the highway and noticed another vehicle approaching me at an unsafe pace. Due to the issue, the car had to hit their brakes hard to avoid a crash. This is also a safety risk because if it happens from a stop, the car may fail to accelerate appropriately when turning in front of traffic. The problem has not be reproduced, confirmed or inspected by anyone besides myself. A video of the issue as it occurred was recorded. This issue is not consistent and has happened twice in approximately 3 months. My Hyundai dealership's service department suggested the car may have went into "limp mode." Given the inconsistent nature of the issue, I did not schedule an appointment to have it looked at because I would have been charged if nothing was found.
Official recalls
425V796000 · Fuel System, Gasoline
Nov 17, 2025
Hyundai Motor America (Hyundai) is recalling certain 2020-2023 Sonata vehicles. A damaged check valve can allow air to enter the fuel tank, causing it to expand and contact hot exhaust components, melting the tank.
Consequence & remedy
Consequence: A melted fuel tank can leak, increasing the risk of a fire.
Remedy: Dealers will inspect and replace the check valve. The fuel tank assembly will be inspected for damage and replaced if necessary. Additionally, dealers will inspect and update the engine control unit software. All repairs will be performed as necessary, free of charge. Owner notification letters were mailed beginning March 13, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 286. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on November 19, 2025.
22V196000 · Latches/locks/linkages:trunk Lid:latch
Mar 28, 2022
Hyundai Motor America (Hyundai) is recalling certain 2020 Sonata and Sonata Hybrid, and 2019 Genesis G70 vehicles. The trunk latch may become damaged, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."
Consequence & remedy
Consequence: A person inside the trunk compartment may become trapped, increasing their risk of injury.
Remedy: Dealers will inspect the trunk latch and replace the trunk latch base, as necessary, free of charge. Owner notification letters were mailed May 26, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 221/010G.
20V213000 · Electrical System:software
Apr 9, 2020
Hyundai Motor America (Hyundai) is recalling certain 2020 Nexo and Sonata vehicles. The Remote Smart Parking Assist (RSPA) software may fail to prevent vehicle movement upon detection of an RSPA system malfunction.
Consequence & remedy
Consequence: Unintended vehicle movement increases the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will reprogram the RSPA software, free of charge. The recall began June 3, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 191.
20V122000 · Equipment:other:labels
Feb 28, 2020
Hyundai Motor America (Hyundai) is recalling certain 2020 Sonata vehicles produced between October 22, 2019 and February 13, 2020. The tire pressure label inside the driver's door and the owner's manual state an incorrect tire size. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: The incorrect tire information may mislead the vehicle owner to install the wrong tire size, potentially affecting vehicle handling, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will install new label stickers over the tire pressure label and in the owner's manual, free of charge. The recall began April 22, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 190.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.