2020 Hyundai Sonata

On or about November 13, 2024 our Hyundai Sonata 2020 gas tank almost exploded. We drove our vehicle to a dealership so that it could be checked because we kept hearing something that sounded like a loud pop / thumb underneath our vehicle. We had already been receiving notifications of a powertrain issue with the vehicle for years (without the dealership resolving the issue). So we were taking the vehicle in for numerous reasons when, the minute we drove our vehicle into the service bay (of a new and unrelated dealership) we were told that Hyundai's Corporate branch has ordered our vehicle grounded and told us we COULD NOT LEAVE with our vehicle or drive our vehicle off the dealership's lot. We were advised that our vehicle had almost exploded and that we were lucky to have brought the vehicle in. We were told that our vehicle should have never left the lot the day we purchased it brand new. We were told that our vehicle's backseats had detached and separated away from the frame of the vehicle. Our vehicle has been at the dealership since the day of the incident (e.g., on or about November 13, 2024). Our vehicle is still under factory warranty and powertrain warranty and Hyundai was not given us an end in sight or advised the public of the issue with their vehicles. WE were told that the vehicles needs repairs such as: 1. The vehicle needs the fuel tank assy and all of the parts for the tank, check valve, and campaign sticker: Please see TSB: 24-01-02OH

While driving at about 45mph a warning flashed on my dash. I couldn't read it before it disappeared, but it was something about front collision., contact dealer. the car immediately lost all power. Everything was still running, but I had no acceleration. I had to back down a busy road into a vacant lot. I had just come off of the highway when this happened, if I had still been driving on the Highway, I would have been hit by a car from behind, since there was no warning at all. The car was towed to a Hyundai dealership. After a diagnosis, it was said to be the Throttle body. I had to wait for the repair because the part was on back order. I was told that there was another car there waiting on the same part. I am afraid to drive the car now, even though the repair was made. I feel this is a safety hazard, and that someone could be injured or killed because of this issue with the car.

When accelerating hard (pedal to the floor) from approximately 55 mph, the transmission may not downshift correctly and loses power causing a safety issue. When attempting to continue accelerate at full throttle, the RPMs hang while simultaneously losing vehicle speed. Other symptoms noticed were slight vehicle jerkiness from RPMs bouncing up and down a couple of hundred RPMs. When letting off of the accelerator to a "normal" depression level, the vehicle upshifts into an appropriate gear and will gain speed (though sluggish). In the same drive (meaning the ignition was not turned off then back on) , if attempting to push accelerator to the floor, the same results happen as stated before. Also in the same drive (after exiting the highway), from a stop at a red light I tested the issue again with the same results. No warning lights, messages, or other symptoms were present to indicate a malfunction. My safety was at risk because I merged onto the highway and noticed another vehicle approaching me at an unsafe pace. Due to the issue, the car had to hit their brakes hard to avoid a crash. This is also a safety risk because if it happens from a stop, the car may fail to accelerate appropriately when turning in front of traffic. The problem has not be reproduced, confirmed or inspected by anyone besides myself. A video of the issue as it occurred was recorded. This issue is not consistent and has happened twice in approximately 3 months. My Hyundai dealership's service department suggested the car may have went into "limp mode." Given the inconsistent nature of the issue, I did not schedule an appointment to have it looked at because I would have been charged if nothing was found.

Driving, car started making a weird sound followed by a warning light on dashboard with dinging sound to correlate... car became difficult to gas, vehicle motion was lagging where I just knew I had to pull over Bc this car was going to literally stop began to slowly (Bc that’s all car would allow) to proceed forward and I was forced to come to a haunt as I pulled onto side of highway. I then could no longer move it. Turned car off for minute then returned to try to start again, car would not accelerate at all nor turn on fully.. I was forced to wait hour to get a tow... took to shop, no problem such was found , car started & ran again ... this is 3 days later the car again continued the same exact pattern & I was unable to drive any further and forced to once again to get tow. This has to be something of bearings with engine, this car mode is not on list but IT certainly is an issue that I believe is related & should be rectified by Hyundai.

MESSAGE ON INSTRUMENT PANEL STATED'COLLISION AVOIDANCE SYSTEM WAS DISABLED AND RADAR WAS BLOCKED.THE ELECTRIC POWER STEERING ALSO BEGAN TO FUNCTION ERRATICALLY AND A STEERING WHEEL SYMBOL APPEARED AND KEPT CHANGING COLOR FROM GREEN TO WHITE.THIS HAPPENED AFTER DRIVING APPROXIMATELY 400 MILES FROM THE DEALER IN NJ TO CHARLOTTE NC.MILEAGE IS 975.