2021 Hyundai Sonata Hybrid

The vehicle experiences sudden, complete electrical power loss while driving at speed on highways and city streets or on the parking. All digital displays turn off, the engine shuts down, and power-assisted steering and braking are instantly lost without prior warning, presenting an extreme collision risk. The issue first occurred in August 2025 at approximately 48,000 miles and was taken to an authorized Hyundai dealer in Michigan for warranty repair. The dealer held the vehicle for over 30 days but failed to correct the defect. The identical power failure has continued and recently escalated to daily occurrences. A second Hyundai dealer (Pacifico Hyundai, Philadelphia, PA) diagnosed an intermittent open circuit in the engine wiring harness but Hyundai Motor America refuses to repair the vehicle under warranty, claiming 'outside influence' without providing evidence. Driving a hybrid vehicle that randomly cuts all power in live traffic is a life-threatening safety hazard. Hyundai Motor America has failed to rectify this critical safety defect.

Overheated engine alarm came on while I was on the freeway on a rainy day. Vehicle was towed to Hyundai dealership in which service technician found that the part preventing water from leaking into the muffler was broken. Hyundai dealership has ordered replacement part but it is on backorder. The broken part that needed replacement has been on backorder for close to a month and there is not an ETA of when the part will be received. Prior to the overheated engine alarm going off, cold air was blowing out of the vents even when the heat option was selected.

Coolant system leaks in to the engine or exhaust system, which is evident in white smoke exhaust and coolant level dropping. In my situation, I required an entire container of coolant to perform a daily commute, and the reservoir was empty by the time I made it to the dealership. Car is rendered undrivable due lack of coolant and engine overheating. My car was in the dealership repair facility for 6 weeks awaiting parts on back order due to nationwide shortage. A technical service bulletin has been issued for this manufacturer defect (23-EM-009H). Cost of repairs was roughly $2,300.

My 2021 Hyundai Sonata Hybrid seems to be leaking coolant into the exhaust system. Various reports online indicate that this is a consistent issue with 2020-2022 Hyundai Sonata Hybrid models. A lot of the reports indicate that owners have tried getting theirs cars repaired for the same issue I have a various dealerships all across the US, but either haven't had any luck or have had a temporary fix for the issue, which proceeded to occur again every couple of months. I personally have had my car inspected by my personal dealership and they have confirmed the issue and have mentioned that other owners have brought theirs in to be checked out, but haven't really had luck. I believe that Hyundai should take responsibility for this and issue a recall on the affected models. I bought the car in good faith hoping for reliability but haven't had it for even 6 months now and this problem is here. For safety or myself and others on the road, this models of the Sonatas need to be recalled and repaired IMMEDIATELY. For reference, here is a reference for the complaints people have made online regarding the vehicle: 1. [XXX] 2. [XXX] . (THE RESPONSES HERE ARE VERY DETAILED) [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

EHRS Coolant Leak- problem started in [XXX] when engine overheated. The weather in Michigan in inclement and being stranded in the intense cold can lead to loss of life. I had it towed to a Hyundai dealership that was unable to find the problem and in attempting to "find a leak" used the incorrect dye, necessitation transferal to another more competent dealership where the problem was diagnosed and was fixed with a replacement part. In December 2023 a TSB 23-EM-009h was issued by Hyundai describing this problem and issuing a part (Center Muffler). I was not informed and the problem recurred. currently this is the third episode and Hyundai after paying 95% of the previous cost, now only agrees to pay 85% and denies reimbursing me for the car rental. Warning lights appeared with all 3 occurrences. Hyundai should have issued a recall to obviate this. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On three separate occasions over the last two months, while driving, an alert comes on that says check hybrid system then the vehicle powers off. When this happens, you lose the ability to accelerate break steer, and I have been lucky each of those three times and that I was in a situation where there was not much traffic. I am not able to drive the vehicle at this time. I have reported the problem to Hyundai and they want me to drive the vehicle to the dealership for another check of it. They have looked at it once before and have not been able to diagnose a problem. It is unsafe to drive and they are not willing to assist in getting the vehicle to the dealership without me getting it over there.

Driving 70 mph, warning lights and alarms "Hybrid System Failure" "Vehicle shutting down" and then it does. No lights, no hazards, no power. Push button battery restart starts it again with no visible issues. Driving 30 mph, warning lights and alarms "Hybrid System Failure" "Vehicle shutting down" and then it does. No lights, no hazards, no power. Push button battery restart starts it again with no visible issues. Driving 58 mph warning lights and alarms "Hybrid System Failure" "Vehicle shutting down" and then it does. No lights, no hazards, no power. Push button battery restart starts it again with no visible issues. ^This is an ongoing issue. It's also been powerless several times while parked.

My car will power off randomly, or will seem as though there is no power. I have to revert back to the manual key to enter the vehicle and hit the 12vlt reset to power it back on. This happened at least 3 times. Once while operating the vehicle, and twice while the vehicle was left parked. This is not a low battery issue as, the car will only do this occasionally, and not every time I enter and turn on the vehicle. There is no error code to follow this mishap as all power goes out and the dealer maintenance has nothing to work with.