2021 Hyundai Sonata Hybrid

The BMS module within my cars hybrid system failed causing a parasitic drain on the hybrid battery. The dealership where the work was performed would have to be contacted for pictures. The hybrid battery system swole to a dangerously inflated level and did not produce any codes for an OBD reader to pickup. This has caused the dealership to turn my car away multiple times before finally performing the in depth inspecting required to verify battery swelling. This is a known problem throughout the internet I searched "2021 hyundai sonata hybrid battery dying every day" reddit has plenty of user with the same issues. I am not aware of who has inspected my battery besides the dealership. There was no warnings at all the only reason my battery was finally looked at is because of my persistence.

The contact owns a 2021 Hyundai Sonata Hybrid. The contact stated that the key fob was inoperable and after using the key to manually open the door. The contact stated that the vehicle failed to start while pressing the START/STOP button. The vehicle was towed to the local dealer, but the cause of the failure was not determined. The contact was advised that when the failure occurred, to start the vehicle, the battery reset button should be pressed before pressing the START/STOP button. The manufacturer was not contacted regarding the failure. The failure mileage was 24,000.

On three separate occasions over the last two months, while driving, an alert comes on that says check hybrid system then the vehicle powers off. When this happens, you lose the ability to accelerate break steer, and I have been lucky each of those three times and that I was in a situation where there was not much traffic. I am not able to drive the vehicle at this time. I have reported the problem to Hyundai and they want me to drive the vehicle to the dealership for another check of it. They have looked at it once before and have not been able to diagnose a problem. It is unsafe to drive and they are not willing to assist in getting the vehicle to the dealership without me getting it over there.

The vehicle, after parking, is nonresponsive to the key fob, nor will it start. This can happen at anytime and anywhere. Dealer said "It is possible the integrated 12v battery into the hybrid battery may be faulty. No codes or tests can confirm the issue. The dealer said the key fobs tested ok." My wife works late at night in a dark area, this has happened 2 times at her place of work and we are concerned for her safety as she has to wait outside for a tow truck to tow it to the dealer. The first 3 times it occured, this issue started around march of 2024, and repeated every 30-45 days. Now it has happened 2 more times in the last week. No warning lamps or indications of problems. The windshield has distortion within the glass and is not a clear view. It is as though you are looking through the heat of a jet engine trying to focus on what is on the other side. This is a major distraction while driving, reading the heads up display in the car, reading street signs and general navigation of pedestrian and other vehicle traffic. There is no aftermarket film or materials on the windshield. The door handle on the drivers side has a cover plate over the hole where a manual key could be inserted. As a construction worker I have very strong hands and I have a difficult time removing the cover plate. The last time I removed the plate I cut my hand on the interior part of the handle as the cover plate popped off. That is how hard the plate is to remove. My wife cannot remove the cover plate on her own. This system is in place for the manual use of the hidden key inside the key fob to be able to open the door in the event of a power failure of the vehicle. which has now happened randomly 5 times.

My battery has died twice, so dead that I can’t even unlock to car with the remote. The first time I had it jumped and took it to the dealership where they were unable to find anything wrong with it and they told me if it happened again to have it towed in so they could diagnose it while the battery was dead. So that happened again and I had it towed in to the dealership in early April. It’s now July and they still have my car and don’t have a diagnosis yet. They have had their field engineers out to run all sorts of tests, but nothing yet. Today they told me they have 3 Sonata hybrids there with the same issue as mine.

Randomly the car will get a message when driving starting “ Check Hybrid system. Turn engine Off” and the car isn’t able to accelerate when this happens. When you cut the engine off the car is unable to start again until it is jumped. I’ve confirmed the battery isn’t the issue however something with the vehicle is wrong. There are many accounts of people online dealing with the same issue.

My car will power off randomly, or will seem as though there is no power. I have to revert back to the manual key to enter the vehicle and hit the 12vlt reset to power it back on. This happened at least 3 times. Once while operating the vehicle, and twice while the vehicle was left parked. This is not a low battery issue as, the car will only do this occasionally, and not every time I enter and turn on the vehicle. There is no error code to follow this mishap as all power goes out and the dealer maintenance has nothing to work with.

The Battery dies randomly and requires the physical key to unlock the door. It is a hybrid, so it has a 12 volt battery button that jumpstarts the car. While driving the vehicle, the battery meter on the dashboard will show a near-full battery and then a near-empty battery within a few minutes. This vehicle was bought brand new from a Hyundai dealership and for the first 2 years, there wasn't an issue. The past few months, the battery issue started.