2025 Hyundai Santa Fe

I am reporting a potential safety defect involving repeated windshield chipping and cracking on my 2025 Hyundai Santa Fe. The vehicle was purchased new. The first incident occurred on April 15, 2025, approximately three months after I purchased the vehicle. While driving approximately 60 mph on a highway in clear, dry conditions with no gravel or unusual road conditions, a small rock struck the upper-right portion of the windshield. The windshield cracked from the impact. The windshield was subsequently replaced on June 6, 2025. In June 2026, while again driving approximately 60 mph on a highway under clear and dry conditions, a small rock struck the center of the windshield and caused a chip. In July 2026, approximately one month later, another small pebble struck the upper-middle portion of the windshield and caused another chip. There were no crashes, sudden braking, turning maneuvers, or unusual driving conditions involved in these incidents. I am concerned because the windshield has repeatedly chipped or cracked from relatively small rocks or pebbles. I have owned and driven other vehicles for many years and have never experienced this level of repeated windshield damage from minor road debris. The windshield was supplied by Hyundai. I believe the repeated failures warrant investigation into the quality, durability, material, manufacturing, or specifications of the windshield glass used in this vehicle. The windshield is an important safety component, and a chip can potentially develop into a larger crack and impair the windshield's integrity while the vehicle is being driven. I have photographs of the most recent chip and an invoice documenting the windshield replacement performed on June 6, 2025. I am requesting that NHTSA review this complaint and determine whether similar complaints exist and whether a safety-related defect or trend may be present in the 2025 Hyundai Santa Fe.

I was sent a letter in the mail asking to bring in my vehicle for a safety recall involving the rearview camera. I scheduled an appointment with Key Hyundai of Milford, CT. After waiting for an hour, I was told that the dealership did not have the part needed to perform the repair and that they would call me when the part came in. It has been three weeks and I have not received a call or been contacted in any way. I got the sense that because this was not a paid service it was a very low priority for the service department. Because of that, I feel reluctant to trust the dealership with the repair.

In this car when you are driving and it is raining hard and you are on a big highway at night with cars coming towards you, the windshield does not clear and it streaks really bad so you cannot see. I have sent pictures to the dealership as well as Hyundai of what it looks like just when you clean off the windshield of snow that it streaks really bad then too and the streaks stay on there, so if you clean your window the day before and get up the next day the halo streaks are still on there. I can somewhat handle that part but when you are driving in rain and you cannot see it is very dangerous . This is a brand new car and this is the 4th time I have had it in the shop for this and they keep saying they cannot duplicate it, but they have not had it when it is raining at night. I do not even want to drive this car at night if I think it may rain because it is so bad. The manufacturer has not inspected it, only the dealership. I am driving a 2026 loaner right now because it is still in the shop but they want me to come pick it up this week saying they cannot duplicate it. If you look the 2026 has had a new windshield design and I know that it is probably because they know the 2025 design is dangerous. I cannot upload on here . Is there anyway I can get an email address to send the documents too? I can scan the receipts from the times it has been there but the conversations are all via email that I have. If I Could get an email I could send them over.

My name is [XXX] I live at [XXX] my phone number is [XXX] my social security is [XXX] . I own a 2025 Hyundai Santa Fe that is subject to Safety Recall 25V-808 involving the rearview camera system. On [XXX] at 12:30pm while operating my vehicle, the rearview camera malfunctioned (the image was [blank / inoperative]). Due to the loss of rear visibility, I was involved in a minor accident while backing up. At the time of the incident, I had not yet received the recall repair. The malfunction experienced is consistent with the defect described in the recall notice regarding the rearview camera harness. This incident caused [minor vehicle damage / property damage. I am reporting this to document a safety-related incident connected to an acknowledged manufacturing defect.I am requesting that this incident be reviewed as a recall-related accident and that Hyundai advise on reimbursement or compensation options. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Driving in light rain at 65 mph , drivers side wiper failed after using AUTO feature. Occurrd 12/23/20125. Wiper was fixed by dealership under warranty on 12/26/2025. 3 weeks later on 1/12/2026 very same situation occurred and exact same malfunction happened yet again. Drivers side wiper total non-operational again. Taken back to the dealership for repair and the Dealership said with 100% certainty issue was caused both times from ice and and snow buildup ans will not submit under warranty. Vehicle is garage kept ( heated) and had absolutely no ice or snow on the vehicle upon operation. Weather was 40+ degrees both days when malfunction occurred. Safety issue was serious due to my wife now unable to see through the window potentially causing an accident during adverse weather conditions.

Within a month of purchasing the vehicle [March of 2025] I was having a windshield replaced due to a crack. After I had that one installed, it needed to be replaced due to scratches on the windshield [safelite warrantied it under faulty glass]. Now within 2 weeks I have had 2 small impacts and 2 chip/cracks filled. I have never had issues with windshields in my driving career thus far like this. I understand windshields can pick up rocks and what not but searching online it doesn't seem to be an isolated incident at all. I think Hyundai may be using cheap glass or something. This is very frustrating because im constantly looking anytime I hear an impact on the windshield. Also, I do not want to be constantly calling safelite for chip repairs

While driving on a service road at approximately 45 mph, the corner side glass on my 2025 Hyundai Santa Fe shattered suddenly and without warning. There was no impact from a rock or object, and no other vehicles were present that could have caused debris. We had just entered the service road, and road conditions were normal. My [XXX] was seated in the front passenger seat at the time of the incident. The glass shattered inward, and the only thing preventing glass from entering the cabin was the window tint holding the shattered pieces together. This presented a serious safety hazard, as occupants could have been injured if the tint had not contained the glass. Once parked in my garage, I took pictures and tried to examine the damage but the window was still crackling and popping. My husband was able to inspected the window immediately after he returned home and confirmed there is no visible rock chip or point of external impact. The fracture pattern appears to originate from inside the glass or along the edge, consistent with a stress fracture or defect rather than road damage. This failure occurred under normal driving conditions with no accident, no debris strike, and no extreme temperature change. The sudden shattering while driving posed a significant risk to driver control and passenger safety, especially with multiple children in the vehicle. I am also aware of other owner complaints involving unexplained glass cracking or shattering on Hyundai Santa Fe vehicles, which raises concern that this may represent a broader defect rather than an isolated incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)