2025 Hyundai Santa Fe

I am submitting a second and more urgent safety complaint regarding the Driver Monitoring and Driver Assistance systems in my vehicle. I previously reported this same core defect: the system falsely fails to recognize my face, sounds repeated warnings, and disables driving assistance while the vehicle is moving. Despite that prior complaint, the defect remains, and the seriousness of the danger has clearly not been recognized or addressed. This defect has now placed my life in immediate danger. While I was driving, the system falsely determined that it could not properly see my face. It sounded repeated warnings and then abruptly disabled driving assistance. That sudden withdrawal of assistance created a near-crash situation. I was attentive and was not experiencing a medical emergency. The danger was created by the system’s false detection and defective response. A safety system should reduce danger. This system detected a supposed problem and made the situation more dangerous by removing the assistance that was helping keep the vehicle under control. Had this occurred beside a concrete barrier, near stopped traffic, in a construction zone, on a curve, or next to a large truck, the result could have been a fatal collision. I could have been killed because of this system defect. When a driver cannot be verified, the vehicle should maintain lane control, reduce speed, activate hazard warnings, and perform a controlled safe stop. It should never abruptly withdraw assistance and create a more dangerous condition. I request that NHTSA investigate why a previously reported life-threatening defect remains unresolved and require Hyundai to correct this system logic before someone is seriously injured or killed.

I own a 2025 Hyundai Santa Fe that was purchased on 08/15/2025. The first malfunction occurred on 08/25/2025, only days after purchase, and the vehicle has experienced repeated safety-related issues since then. The vehicle has repeatedly displayed false Forward Collision Warning alerts, Blind Spot Warning failures, Park/Neutral errors, and intermittent disabling of safety features. The most serious incident occurred when the vehicle unexpectedly entered “Limit 20 MPH” mode while I was pulling into active traffic with my toddler in the vehicle, limiting acceleration and creating a safety risk. I have also experienced false collision alerts while parked and after the vehicle was shut off. The vehicle has been taken to the dealership multiple times for diagnosis and repair attempts. Some issues were duplicated by dealership personnel, while other visits were documented as “could not duplicate.” A front ultrasonic sensor was replaced, but the vehicle continued experiencing safety-related concerns afterward. During the repair process, I was informed and observed that dealership personnel appeared limited in what repair actions could be taken after consulting Hyundai through their diagnostic system. I was also informed that Hyundai influenced what could be included on service reports and that dealership personnel were instructed to “print the book” rather than fully document observed concerns. I believe this may have affected repair efforts and documentation of ongoing issues. The vehicle has been out of service for extended periods and the issues continue despite repeated repair attempts. Due to the ongoing malfunctions and inconsistent operation of the safety systems, I no longer feel safe driving the vehicle because I am concerned it may not function properly during a real emergency situation. Attached are photos of various dashboard errors and warning messages that occurred during these incidents to document the alerts and malfunctions experienced.

On April 27, 2026, my 2025 Hyundai Santa Fe experienced an intermittent electrical/system malfunction affecting multiple vehicle systems at the same time. Multiple orange warning lights/messages appeared on the dash, including driver-assistance warnings and the master warning triangle. At the same time, the front turn signal stopped working, causing rapid flashing; the power locks stopped working; the windows would not roll up or down; and the rear liftgate would not open using the key fob or exterior liftgate button. The vehicle/component is available for inspection upon request. This created a safety and access issue. The malfunction affected exterior signaling, locks, windows, and rear cargo access. My dog was in a crate in the rear cargo area, and I could not open the liftgate normally to access him. The failure of locks/windows/liftgate could create a serious emergency risk if a person, pet, or cargo needed to be accessed quickly, and the turn signal failure affected my ability to safely signal to other drivers. The issue lasted approximately 30–40 minutes and did not immediately clear after turning the vehicle off and back on. It later returned to normal on its own. This has happened more than once. The vehicle was taken to a Hyundai dealership for inspection. The dealer has been working with Hyundai Techline, but as of now they have not been able to reproduce the issue or find active diagnostic codes. I provided video evidence of the dash warnings from the incident. The dealer advised that scans currently show systems operating as designed because the issue is intermittent and not occurring during inspection. There were no prior symptoms before the failure. The warning lamps and messages appeared at the time the malfunction occurred. Seek reimbursement for rental car fees and diagnostic fee.

The vehicle has two display panels, molded into a single frame. There is an infotainment panel on the right that handles music, maps, and phone interaction. There is an instrument panel on the left. The infotainment panel has not issues. The instrument panel blanks out for 3 - 5 seconds every few minutes, and then reappears. Occasionally the words "No SIgnal" in big red letters will appear. Occasionally the gear selection letter will remain on the otherwise blank screen. The screen also shudders / tears occasionally before blanking. It does this whether the vehicle is moving or parked. I purchased the vehicle used, Jan 2 2026. I noticed the problem a couple of days later. It has continued. It is not getting any worse or any better.

Since I bought the car the forward attention warning goes off constantly. I’ve taken it to the dealership multiple times. They took off my eztag, stated it was blocking my camera. This is not the issue. Now there are 56 cars ahead of mine. This will be the 3rd time for the exact same complaint. It affects everything in the car. My cruise control doesn’t work because of this issue. If you turn the toggle back on it has more warning. Just the beeping constantly is going to cause an accident. I’ve asked Hyundai to buy it back they refuse. This is a known issue.

Dear NHTSA Team, My car was in a minor accident Last. After that, the repair shop replaced my bumper and front camera. Don Franklin Somerset Hyundai performed a calibration on my new radar. They calibrated it six times, but there are still many issues with the HDA driving system. 1. False Dual-Side Warning When a vehicle is present only on the right side, the vehicle camera system incorrectly detects vehicles on both the left and right sides. In reality, there is no vehicle on the left side. In this scenario, both the radar warning and the camera detection are incorrect. 2. Wrong-Side Warning In some cases, when a vehicle approaches from the left rear, no warning is issued on the left side, while a warning is incorrectly displayed on the right side. In this scenario, both the radar warning and the camera detection are incorrect. 3. False Warning During Smart Driving While driving on the highway using the smart driving function, when the vehicle is required to turn left or right, the system may generate a false dual-side warning. As a result, the vehicle aborts the intended left or right turn and continues driving in the center of the lane. In this scenario, both the radar warning and the camera detection are incorrect. 4. while driving manually (without HDA engaged) or parking, the vehicle shows left-side or right-side collision warnings without clear cause. I reported these issues to Hyundai USA approximately three weeks ago. I was instructed to bring the vehicle to the dealership for inspection. However, during my recent visit, the dealership representative only reviewed the videos I provided and concluded that no issues were present, without conducting a physical inspection or test drive of the vehicle. Given the ongoing safety concerns and lack of proper diagnosis or resolution, I am submitting this complaint for your review and assistance. Thank you for your attention to this matter. Thanks, Best Regards, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5

Forward Facing Driver Assist cabin camera will shut off the cruise while you are driving if it cannot detect your eyes. This is NOT a safety feature but rather an extremely dangerous safety hazard!!! While you are traveling at 70+ mph and put on sunglasses and all of a sudden the car starts alarming and decelerates without warning causing the driver to become EXTREMELY distracted trying to figure out what is going on is a recipe for a major incident. There is no way to shut the camera off so you are then forced to either drive with no cruise at all so you can wear sunglasses and for long trips creates added and unnecessary driver fatigue OR you forego wearing sunglasses and squinting causing unnecessary eye strain/fatigue so you can use the cruise. Please explain to me how this is a safety feature? Also the warning that 'you might need to take a break' is also NOT a safety feature and also creates driver distraction rather than safety and should just totally be removed from the vehicle software completely. We have literally driven the car over the center line on the rumble strips without a signal and then back into our lane again the warning does NOT go off, we've jerked the wheel to avoid an object in the road warning does NOT go off, BUT if you happen to drive to close to the center line but don't go over it then the warning DOES go off.....if we just left the house turned out of the driveway, the damn thing goes off. There is no making sense of when or why it goes off, it's completely random. And again, no option to turn it off. Had the dealership given COMPLETE details of these 2 specific "SAFETY" features - I use that term EXTEREMLY loosely - sharing they could NOT be turned off I never, EVER would have bought this vehicle. I am not alone in my complaints, I have seen hundreds of similar complaints on forums for Hyundai vehicles that have this feature. PLEASE PLEASE issue a directive to Hyundai that they need to push a fix allowing shut off of these 2 features

This car was in a BBB binding Arbitration and Hyundai was told to fix: speed control malfunction, speed linit not posting to hub arbitrary fan engagement. The Dealership ALM West had the car 2 weeks and the car sat on their lot. They said we are unable to duplicate the problem. Now in addition I showed them the cracked windshield and they were not responsible. I had an insurance complaint I took it to Safelite and replaced the windshield yesterday and I got it back with a new windshield and it also had a Crack in the replacement windshield. I think Hyundai knows there's a problem with the glass which is also part of the safety system of the car.

I am reporting a safety hazard with the Driver Monitoring/Driver Assistance system in my 2025 Hyundai Santa Fe SEL (VIN: [XXX] ). The system frequently misinterprets my normal driving behavior as inattentiveness and triggers constant, loud beeping while I am driving. In many cases, it also disables assistance functions mid‑drive, which is dangerous and unexpected. The false alerts appear to be caused by the system misreading my eyes due to their natural shape and size. This issue does not occur with my wife, who has larger eyes, which indicates the system is biased toward certain physiologies and does not reliably detect all drivers. I have tested this repeatedly: if I strain my eyes unnaturally wide, the alerts stop, but this is extremely uncomfortable and only sustainable for a few seconds. The system is effectively pressuring the driver to adopt unsafe, unnatural behavior to avoid constant alarms. Environmental conditions such as sun glare, rain, and darkness make the false alerts even more frequent. The sudden loud beeping is startling and forces me to divert attention from the road. The unexpected loss of assistance features during driving further increases the risk of an accident. This system is not functioning as an assistive feature. Instead, it creates distraction, encourages unsafe compensatory behavior, and fails to accommodate normal variations in driver physiology. I request that NHTSA investigate whether Hyundai’s driver monitoring system meets safety and reliability standards and require corrective action if necessary. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)