2023 Hyundai Santa Fe

I own a 2023 Hyundai Santa Fe Calligraphy AWD equipped with the 2.5L turbo engine and 8-speed wet dual-clutch transmission. At approximately 39,900 miles, the check-engine light illuminated. Hyundai Bluelink diagnostics reported powertrain/TCU diagnostic trouble code P1C2D03, identified as a high-pressure electric oil pump motor position sensor fault. I am concerned because this same diagnostic trouble code and high-pressure electric oil pump/transmission issue was associated with Hyundai Safety Recall 236 (NHTSA Recall 22V746) involving certain earlier Santa Fe model years. Hyundai's recall documentation described the possibility of the transmission high-pressure electric oil pump malfunctioning and causing loss of motive power while driving. My vehicle is a 2023 model and therefore was not included in that earlier recall, but Hyundai has subsequently issued technical service information covering 2021–2023 Santa Fe vehicles equipped with the 2.5T engine and 8-speed wet DCT, including vehicles displaying DTC P1C2D03. The current Hyundai service procedure indicates that affected vehicles may require transmission replacement. I have stopped driving the vehicle because of my concern about a possible loss of propulsion and have scheduled an appointment with a Hyundai dealership for diagnosis. At this time, I have not experienced a loss of motive power or an accident. I am reporting the issue because a 2023 vehicle outside the original recall population is displaying the same fault code associated with the previously recalled transmission condition. I believe NHTSA should evaluate whether the affected population should include additional model years.

Subject: Formal Dispute: Warranty Breach and Failure to Repair – 2023 Hyundai Santa Fe Timeline & Facts:11/2/25 (~52,000 miles): I officially reported an intermittent loss of power and severe engine revving (up to 7,000 RPM). This created a severe safety hazard when merging and accelerating from an idle stop.3/28/26 (Under 60k miles): After months of diagnostic delays, Hyundai confirmed the Dual-Clutch Transmission (DCT) needed replacement under the 60,000-mile warranty. A Hyundai Case Manager tracked the issue.Service Delay: Hyundai delayed repairs due to a lack of loaner vehicles, which were grounded for recall updates. Commuting pushed my mileage to 60,218. The Case Manager assured me coverage was locked in because the defect was documented before 60,000 miles.4/8/26: Due to corporate protocol, they ordered a valve body installation instead of a new transmission.8/11/26: The valve body failed. Hyundai delaership resubmitted the transmission replacement request. Corporate denied 100% coverage because the odometer was now over 60,000 miles (60,218). They are offering only 80%, leaving me with a $1,000 plus out-of-pocket expense.Legal & Contractual Position:Hyundai is contractually and legally obligated to cover 100% of this replacement. Under federal and state consumer protection laws, any defect reported prior to warranty expiration must be fully repaired by the manufacturer, even if the final repair occurs after the mileage threshold. The current mileage is a direct result of Hyundai’s internal diagnostic and loaner delays.Demanded Resolution:I demand that Hyundai cover 100% of the transmission replacement costs immediately. I am hoping this escalation to the NHTSA will help in bringing this matter to a positive end result, otherwise I have no choice but to pursue formal legal remedies.

This complaint concerns a serious, unresolved powertrain/propulsion safety defect in my 2023 Hyundai Santa Fe. While traveling approximately 70 mph, the vehicle suddenly lost propulsion and would not accelerate normally while surrounded by highway traffic.MOST IMPORTANTLY, THERE WAS NO WARNING OR ADVANCE INDICATION. No warning lights, messages, or symptoms appeared before the loss of propulsion. I had no opportunity to anticipate the failure or prepare to safely exit traffic. This placed me and other motorists at immediate risk of a serious or potentially fatal collision.A Hyundai dealership inspected the vehicle and documented DTC P284001, Shift Fork D Position Fault. Despite this documented fault, the underlying safety issue remains unresolved. Hyundai has not identified a permanent correction or established that the vehicle is safe to operate.There has not been another incident because I will not risk another sudden loss of propulsion by driving the vehicle. The absence of another failure does NOT mean the problem is resolved. The vehicle remains available for inspection.I have repeatedly sought assistance from Hyundai and the dealership without a meaningful resolution. Newer information regarding a possible computer reset/relearn procedure has also been presented, but the dealership refuses to perform it.I reviewed NHTSA complaints for 2023 Santa Fe vehicles and found multiple reports describing similar safety symptoms, including sudden loss of propulsion, inability to accelerate, abnormal transmission shifting, and loss of speed. This raises serious concern that this may not be an isolated failure.A vehicle that can unexpectedly lose propulsion at highway speed WITHOUT ANY WARNING creates an extreme crash risk. I respectfully request that NHTSA review the similar complaints, investigate whether a broader transmission/powertrain safety defect exists, and determine whether corrective action is necessary before this results in serious injury or death.

COMPONENT/SYSTEM: The powertrain launch control system — the Transmission Control Unit (TCU) and 8-speed wet dual-clutch transmission paired with the 2.5T engine — fails to deliver engine power in response to full accelerator input from a stop. The engine does not rev and the vehicle does not move for approximately 1–2 seconds despite the accelerator pedal being fully depressed, then power engages abruptly and violently. The vehicle is available for inspection upon request. SAFETY RISK: The failure occurs when launching from a stop into intersections and cross-traffic. In the most recent incident, I was turning left across the roadway from a stop with an oncoming vehicle approaching. I applied full accelerator and the vehicle did not respond at all for approximately 2 seconds — no engine response, no movement — leaving me stationary in the oncoming vehicle’s path. Power then engaged violently and without warning, causing the vehicle to lurch across the road. I was nearly struck. Similar events have occurred multiple times throughout my ownership; this was the closest to a collision. DEALER CONFIRMATION: Not yet inspected by a dealer. A dealer service appointment is being scheduled. OTHER INSPECTIONS: The vehicle has not been inspected by the manufacturer, police, or insurance representatives. WARNING LAMPS/PRIOR SYMPTOMS: No warning lamps or messages have appeared before, during, or after any of the events. The failure is intermittent and occurs without warning. The condition has been present since I purchased the vehicle in October 2022 and has occurred regularly throughout ownership — numerous occurrences over more than three years. No warning lamps have ever accompanied it. ADDITIONAL: Condition persists with Idle Stop & Go disabled, ruling out engine-restart delay. Same 8-speed wet DCT was subject to Recall 236 (NHTSA 22V-746) on 2021–2022 models for similar throttle non-response; 2023 excluded despite identical hardware.

Vehicle stalled while driving — unsafe loss of power. While driving at normal speed, the vehicle suddenly shut off without warning and the electrical system malfunctioned. I had to pull over and restart car. This created a dangerous situation and could have caused a collision. Prior to this incidenct, the vehicle had intermittent electrical issues during startup (flickering electronics). This is the first time the car has experienced during driving, and is now at the Hyundai dealership. The car has been reported as unsafe to drive. This appears similar to other Hyundai stalling/power loss issues and may indicate a developing safety defect. Requesting investigation.

While running errands around town, I noticed my 2023 Sante Fe 2.5T was sluggish shifting out of first gear into second. The RPMS revved to about 3K before the transmission shifted into 2nd. I didn't notice any problem shifting into 3rd and above. I drove to a gas station for fuel and shut off my car. When I started it and began to drive, I received an immediate warning to take the car to a dealer and the check engine light came on. The car had the same problem getting out of 1st gear at each of the traffic signals I got caught at on my way to the dealership about 2 miles away. The following day, the service department contacted me and determined I needed a new transmission due to the failure of the Dual Clutch electric high pressure oil pump in the transmission. They submitted a parts request and Hyundai approved a refurbished DCT warranty replacement. The transmission only has 50200 miles on it I am second owner but the car was a CPO so I have full warranty coverage. I was given a loaner under Hyundai' warranty provisions. My main concern is that although this vehicle is a 2023 Sante Fe, it was put in service around August of 2022 and would therefore have the same transmission as the 2021 and 2022s covered under Hyundai recall 236, but this has yet to be acknowledged as far as I know. Please investigate my situation and consider further requirements of Hyundai! Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On March 4, 2026, at approximately 7:30 AM EST, while driving my 2023 Hyundai Santa Fe Limited on [XXX] , the vehicle experienced a sudden loss of propulsion while traveling at approximately 70 mph (posted speed limit). The vehicle would not accelerate or maintain speed and would not move forward when placed in drive, indicating a failure within the powertrain/transmission system. The vehicle is currently located at a Hyundai dealership and is available for inspection upon request. This incident created a significant safety risk, as I was traveling at highway speed in active traffic when the vehicle unexpectedly lost the ability to move under its own power. This placed me at risk of being rear-ended and made it difficult to safely maneuver out of traffic. The vehicle was inspected by a Hyundai dealership. Diagnostic trouble code P284001 (Shift Fork “D” Position) was identified, and I was informed the failure is transmission-related. The condition was reproduced by placing the vehicle in drive, at which point the vehicle would not move. The vehicle has been inspected by the dealership. The manufacturer has been notified but has not physically inspected the vehicle. No police or insurance inspection was involved. There were no warning lights, messages, or prior symptoms before the failure. The issue occurred suddenly without any indication of a problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On 6/7/2023 with the original owner, the vehicle displayed code P1c2D03, according to carfax history the transmission was replaced 7/12/2023. I purchased the vehicle in May, 2025. In December, 2025, while driving to work I experienced intermittent loss of ability to accelerate, followed by the vehicle again displaying code P1C2D03 in the Bluelink app. The dealership performed a software update and told me to come get my car. On Monday, February 16, 2026, I started the vehicle and the dash displayed "Transmission error. Check transmission fluid immediately!", I again had it towed to the dealership where it has remained for the past three weeks. Now I have been called again to pick up the vehicle as the dealership cannot duplicate the error. At this time I am unsure if the service center actually checked the transmission fluid as the warning indicated should be done.