2023 Hyundai Santa Fe

Collision warning sensor alarm randomly comes on my dash and my car slams on the breaks. Very dangerous, I’m scared to drive down the highway going 60mph. 80,109 miles 2023 Hyundai Santa Fe. I have not brought it in to a Hyundai dealership because they want a diagnosis fee and everything else. Hyundai should fix it. This alarm has happened several times than it will go away and come on like 3 times in a row, usually daily when I use the car

While driving on the interstate, while using cruise control, my vehicle braked and decelerated, uncontrollably. The collision alert alarm went off. I forced the vehicle to accelerate and it stopped the braking and the collision alarm ceased. I took the car to the dealer and they spend the day checking it over. They said they couldn’t get the same reaction I reported, but reset the cruise control. On my way back home on, again on the interstate, and with the cruise control activated, it again had the same failures. I called the dealer and told them. They asked if I had recently mounted any new equipment on the windshield. I said I had Velcro attached and EZPASS toll reader. They asked me to remove it, because might be interfering with the cruise sensor. After I removed it, and while continuing on the interstate, with cruise activated, it again repeated the same failures. The dealer arranged to have my vehicle towed to their shop.

It is not just this vehicle; it is ALL vehicles with adaptive cruise control and automatic emergency braking. When sensors get snow or debris on them, they shut the vehicles down without warning. I have had 3 times this winter when the roads were fine, cruise control set, and because another vehicle was kicking up road salt, the vehicle instantly shut off the cruise control without any warning to the driver, all 3 times I had traffic behind me at 55mph or on the highway at 70mph. The emergency braking is another issue, as it will bring the vehicle to almost a stop, and does not take into account if there are other vehicles behind it or not! How more people have not been killed because of these 2 systems is beyond me! BOTH of these systems and the vehicle they are on NEED to be recalled and either sensors removed or workarounds implemented, that at least give the driver some advanced notice before the cruise control is turned off or before a vehicle decides to hard-brake itself!

On a clear road a sencor comes on detect comes on says detection collision. The breaks come on when you are traveling on interstate or two lane roads. When you are traveling 75 mph and breaks come on all of a sudden on the highway. We are lucky we never got hit in the back of the car going that fast. We will stop 75 to 35 mph in 10 seconds.

Component/System: Automatic Emergency Braking / Forward Collision-Avoidance (AEB/FCA) system and/or Electronic Parking Brake (EPB). The vehicle is available for inspection upon request. What happened: While driving my 2023 Hyundai Santa Fe (VIN: XXX) at highway speeds, the vehicle suddenly and aggressively applied the emergency braking system on two separate occasions within the same day (approximately 45–60 minutes apart). In both instances, the red emergency braking warning lights illuminated on the dashboard, and a warning sound activated. There were no vehicles, obstacles, or hazards in front of me either time. The braking was forceful and abrupt, causing rapid deceleration at highway speed. Both events occurred under normal, clear driving conditions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) Safety risk: My safety and the safety of other drivers were put at significant risk. Sudden unintended braking at highway speeds can easily lead to a rear-end collision since the deceleration was not caused by driver input and gave no warning. Reproduction / dealer confirmation: The dealer has not been able to reproduce the issue, and no diagnostic trouble codes have been found so far. The vehicle is currently at the dealership for inspection. Inspection: The vehicle has been inspected by the Hyundai dealership, but the cause has not been identified. No manufacturer field engineer, police, or insurance inspection has taken place yet. Warning lamps / prior symptoms: During the failures, the red emergency braking indicator and audible warning activated immediately when the brakes engaged. There were no warning lights or symptoms prior to either event. Assessment: Cause UNKNOWN. The problem appears to be an intermittent malfunction of the Automatic Emergency Braking system, forward collision sensors, or related braking components. No diagnostic codes were stored. This is a serious safety issue that occurred twice within one hour and could easily result in a collision.

The vehicle's software was updated on Oct 21, 2025. The software has serious flaw. When driving on slight incline on the passing lane the vehicle will apply the brakes without warning. This has happened 3 times. At times, when vehicles were following me they also had to apply the brakes unexpectedly. Had they not applied their brakes, they would have rear ended me at highway speeds. I also recall that there were no vehicles either in front or to the right ahead of me when it occurred. Also there was a guardrail on the left side of the highway at the time. This did not occur with the previous installed software. Every time this happened, the vehicle was in cruise control and driver assist was ON to keep vehicle in the lane.

I was travelling at 50mph a car pulled in front of me and stopped unexpetedly. I braked hard. My car began to slow, but the brake pedal went to the floor and did not slow, AFter a few seconds, the brake pedal came up from the floor and braking was resumed. I held the pedal to the floor the whole time trying to stop. It was as though the braking system failed and recovered. There was no pulsing felt on the brake pedal typical of ABS working. After my car resumed braking thte collision avoidance system took over and the car stopped just inches from the stopped car in front of me. I had just taken the car in for dealer service at 24,200 and everything was supposedly checked out as required by maintenance. I have contacted Hyundai but have not gotten a response yet.

On two occasions, once at 70mph and once at 45mph vehicle suddenly lost power and displayed warning to check collision system, there were no vehicles close enough to warrant this. I had to limp the car to the side of the road as safely as possible and shut car off, wait a few minutes and restart vehicle to clear error and allow proper power/ acceleration again.