NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
962 reports1,000 miles · Nov 16, 2019
Unknown Or Other
OIL IS VANISHING FROM THE VEHICLE. FOR EVERY 1000 MILES THERE IS A PINT OF OIL MISSING FROM THE VEHICLE. THIS HAS BEEN REPORTED TO THE HYUNDAI MUTIPLE TIMES. HYUNDAI CAN NOT FIND ANY ISSUE WITH THE VEHICLE. THIS IS CONCERING BECUASE THE VEHICLE CAN BREAK DOWN ON A LONG ROAD TRIP WITHOUT CONSANT OIL CHECKS AND REFILLING DURING TH…
Read full complaint
OIL IS VANISHING FROM THE VEHICLE. FOR EVERY 1000 MILES THERE IS A PINT OF OIL MISSING FROM THE VEHICLE. THIS HAS BEEN REPORTED TO THE HYUNDAI MUTIPLE TIMES. HYUNDAI CAN NOT FIND ANY ISSUE WITH THE VEHICLE. THIS IS CONCERING BECUASE THE VEHICLE CAN BREAK DOWN ON A LONG ROAD TRIP WITHOUT CONSANT OIL CHECKS AND REFILLING DURING THE TRIP. HYUNDAI HAS YET TO REPLACE THE MOTOR OR RESOLVE THE ISSUE. NO OIL LEAK LOCATED IT APPEARS THE OIL IS JUST GOING MISSING WHILE THE VEHICLE IS IN MOTION.
NHTSA ODI #11280469
Mileage unknown · Nov 6, 2019
Unknown Or Other
THERE IS A LEAK ON THE DRIVERS SIDE OF THE VEHICLE COMING FROM UNKNOWN DEFECT. EVERY TIME IT RAINS, WATER DRIPS FROM UNDER THE DASH TO THE FLOOR CLOSE TO THE FRAME OF THE CAR.
NHTSA ODI #11278491
30,000 miles · Oct 28, 2019
Engine
TL* THE CONTACT OWNS A 2017 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN AND REPAIRED PER AN UNKNOWN RECALL REGARDING THE ENGINE. WHILE ATTEMPTING TO ACCELERATE TO APPROXIMATELY 60 MPH, THE RPMS DRASTICALLY REDUCED AND FAILED TO INCREASE. THE CONTACT TOOK THE VEHICLE TO ROUTE 2 HYUNDAI (LOCATED AT 743 N…
Read full complaint
TL* THE CONTACT OWNS A 2017 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN AND REPAIRED PER AN UNKNOWN RECALL REGARDING THE ENGINE. WHILE ATTEMPTING TO ACCELERATE TO APPROXIMATELY 60 MPH, THE RPMS DRASTICALLY REDUCED AND FAILED TO INCREASE. THE CONTACT TOOK THE VEHICLE TO ROUTE 2 HYUNDAI (LOCATED AT 743 NORTH MAIN STREET, LEOMINSTER, MA 01453, 978-534-999) WHERE THE RECALL REPAIR WAS ATTEMPTED SEVERAL TIMES; HOWEVER, THE FAILURE PERSISTED. THE CONTACT WAS UNABLE TO PROVIDE THE REPAIR SPECIFICS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
NHTSA ODI #11271484
79,618 miles · Oct 15, 2019
EnginePower Train
ON MARCH , 19 2019 AROUND 5:00AM I WAS ON MY WAY TO WORK LIKE NORMAL. AS I WAS GETTING ON THE FREEWAY AT ABOUT 45 MILES PER HOUR MY CAR SHUT OFF WHILE DRIVING. I HAD NO POWER STEERING BUT I COASTED TO A STOP IN THE RIGHT LANE OF FREEWAY TURNED MY CAR BACK ON AND DROVE ABOUT 500 FEET AND THE SAME THING HAPPEN BUT THIS TIME IT WO…
Read full complaint
ON MARCH , 19 2019 AROUND 5:00AM I WAS ON MY WAY TO WORK LIKE NORMAL. AS I WAS GETTING ON THE FREEWAY AT ABOUT 45 MILES PER HOUR MY CAR SHUT OFF WHILE DRIVING. I HAD NO POWER STEERING BUT I COASTED TO A STOP IN THE RIGHT LANE OF FREEWAY TURNED MY CAR BACK ON AND DROVE ABOUT 500 FEET AND THE SAME THING HAPPEN BUT THIS TIME IT WOULD NOT TURN BACK ON. I HAD AAA TOW MY CAR TO THEIR SHOP. 3/20/2019 AAA TOW MY CAR TO CARDINALEWAY HYUNDAI 2525 WARDLOW ROAD CORONA, CA 92882 SERVICE: (951) 271-3333 5/13/2019 - [X] I ACCEPT HYUNDAI MOTOR AMERICA'S GOODWILL OFFER OF COVERING THE OF PARTS AND YOU COVERING THE LABOR $1,100.00 JORDAN NATIONAL CONSUMER AFFAIRS ‪ (714) 965-3976‬ HYUNDAI MOTOR AMERICA 9/16/2019 - NEW ENGINE IS INSTALLED | CAR IS READY | I I PAY THE THE 1,100.00 AND PICK UP MY CAR. 9/17/2019 - BROUGHT THE CAR BACK TO DEALER. A LEAK WAS FIXED 2 SPARK PLUGS CHANGED 9/18/2019 - I WENT TO PICK UP MY CAR ON 9/18/2019 WHEN I TURNED MY CAR ON THE CHECK ENGINE LIGHT WAS
NHTSA ODI #11268459
62,000 miles · Oct 12, 2019
Electronic Stability Control (esc)EngineVehicle Speed Control
WHILE TURNING RIGHT OUT OF A PARKING LOT ONTO A TWO LANE ROAD, THE VEHICLE SUDDENLY STOPPED ACCELERATING FOR 3-5 SECONDS AS A TRUCK WAS BEARING DOWN ON US. THE POSITION OF THE GAS PEDAL MADE NO DIFFERENCE. THE ENGINE WAS RUNNING AT AN IDLE WITH ZERO RESPONSE FROM PEDAL INPUT. WHEN IT DID FINALLY ACCELERATE, IT LURCHED FORWARD AS…
Read full complaint
WHILE TURNING RIGHT OUT OF A PARKING LOT ONTO A TWO LANE ROAD, THE VEHICLE SUDDENLY STOPPED ACCELERATING FOR 3-5 SECONDS AS A TRUCK WAS BEARING DOWN ON US. THE POSITION OF THE GAS PEDAL MADE NO DIFFERENCE. THE ENGINE WAS RUNNING AT AN IDLE WITH ZERO RESPONSE FROM PEDAL INPUT. WHEN IT DID FINALLY ACCELERATE, IT LURCHED FORWARD AS THE PEDAL WAS PRESSED TO THE FLOOR. WE ARE ALSO EXPERIENCING WHAT COULD BE DESCRIBED AS A SHUDDER WHEN DECELERATING TO A STOP. IT TYPICALLY SEEMS TO OCCUR BETWEEN 20-12 MPH. IT FEELS AS IF THE ENGINE IS STUMBLING OR IT IS HAVING TROUBLE DOWNSHIFTING SMOOTHLY.
NHTSA ODI #11268117
Mileage unknown · Oct 10, 2019
Electrical SystemUnknown Or Other
OVER ONE MONTH AGO, MY GPS VIEWER SHOWED A WRONG TIME. I RESET THE CLOCK AND EXITED THE FEATURE. THE CLOCK QUIT APPEARING ON THE SCREEN. AT FIRST I DIDN'T NOTICE IT. THEN WHEN I DID, I WASN'T ABLE TO ENTER THE PROGRAM TO SET THE CLOCK: IT WAS ALL DARK ON THE CHOICES. I READ BOTH MY MANUALS AND NOTHING IN THEM TALKED ABOUT THIS P…
Read full complaint
OVER ONE MONTH AGO, MY GPS VIEWER SHOWED A WRONG TIME. I RESET THE CLOCK AND EXITED THE FEATURE. THE CLOCK QUIT APPEARING ON THE SCREEN. AT FIRST I DIDN'T NOTICE IT. THEN WHEN I DID, I WASN'T ABLE TO ENTER THE PROGRAM TO SET THE CLOCK: IT WAS ALL DARK ON THE CHOICES. I READ BOTH MY MANUALS AND NOTHING IN THEM TALKED ABOUT THIS PROBLEM. I HAD SEVERAL FRIENDS READ THE MANUAL AND THEY COULDN'T FIND ANY INFORMATION TO FIX THIS EITHER. I WENT TO THE DEALER AND HAVE IT FIXED AND THEY SAID THERE IS NO FIX FOR THIS. THE SECOND TIME I CAME TO THE DEALER, THE TECHNICIAN ORDERED THE WHOLE HEAD UNIT AND THEY SAID I HAVE TO WAIT FOR THE ORDER. IT'S ABOUT 4-5 WEEKS NOW AND I STILL HAVEN'T HEARD ANYTHING. I CALLED LAST WEEK AND THEY SAID THERE IS NO ETA FOR IT. I DO NOT KNOW WHAT TO DO ANYMORE.
NHTSA ODI #11267569
38,000 miles · Oct 5, 2019
Unknown Or Other
OVER ONE MONTH AGO, MY GPS VIEWER SHOWED A WRONG TIME. I RESET THE CLOCK AND EXITED THE FEATURE. THE CLOCK QUIT APPEARING ON THE SCREEN. AT FIRST I DIDN'T NOTICE IT. THEN WHEN I DID, I WASN'T ABLE TO ENTER THE PROGRAM TO SET THE CLOCK: IT WAS ALL DARK ON THE CHOICES. I READ BOTH MY MANUALS AND NOTHING IN THEM TALKED ABOUT …
Read full complaint
OVER ONE MONTH AGO, MY GPS VIEWER SHOWED A WRONG TIME. I RESET THE CLOCK AND EXITED THE FEATURE. THE CLOCK QUIT APPEARING ON THE SCREEN. AT FIRST I DIDN'T NOTICE IT. THEN WHEN I DID, I WASN'T ABLE TO ENTER THE PROGRAM TO SET THE CLOCK: IT WAS ALL DARK ON THE CHOICES. I READ BOTH MY MANUALS AND NOTHING IN THEM TALKED ABOUT THIS PROBLEM. I HAD SEVERAL FRIENDS READ THE MANUAL AND THEY COULDN'T FIND ANY INFORMATION TO FIX THIS EITHER. WHEN I WENT FOR AN OIL CHANGE, I FOUND OUT THAT THIS ISSUE WAS AFFECTING LOTS OF VEHICLES AND THEY SAID THERE WAS A COUPLE OF THINGS THEY COULD DO TO ATTEMPT TO FIX IT. SOMETIMES IT WORKED AND SOMETIMES IT DIDN'T. MINE DIDN'T. NO ONE CONTACTED ME TO ALERT ME TO THE PROBLEM (SAID MAYBE A CELL TOWER ISSUE WHEN I WAS AT THE DEALERS). I HAVE TO ACCESS MY FITBIT TO GET THE TIME WHICH REQUIRES SQUEEZING THE SIDES OF IT AND SOMETIMES SCROLLING IT. NOT SUPPOSE TO USE YOUR CELL PHONE FOR SAFETY, BUT MESSING WITH MY FITBIT UNDER MY JACKET IS JUST AS BAD. WHY WEREN'T WE NOTIFIED. GOOGLE SHOWS PEOPLE HAVE BEEN COMPLAINING ABOUT THIS PROBLEM FOR SOME TIME NOW. I'M A SENIOR CITIZEN AND MAY NOT BE USING CORRECT TERMS FOR THE GPS STUFF. IT IS A SAFETY ISSUE WHEN YOUR EYES AREN'T ON THE ROAD AS THEY SHOULD BE AND MESSING WITH YOUR FITBIT. YES I CAN INVEST IN A WATCH AGAIN, BUT WHY SHOULD I HAVE TO DO THIS? DOESN'T MATTER IF I AM DRIVING OR STATIONARY, IT DOESN'T WORK!!!!!
NHTSA ODI #11266501
40,000 miles · Sep 24, 2019
Electrical SystemUnknown Or OtherFire
TL* THE CONTACT OWNED A 2017 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE UNDER THE HOOD WHILE PARKED AND UNOCCUPIED. THE FIRE DEPARTMENT WAS PRESENT, EXTINGUISHED THE FIRE, AND STATED THAT THE FIRE INITIATED AROUND THE BATTERY AREA. A FIRE DEPARTMENT REPORT WAS FILED. THE CONTACT MENTIONED THAT A NEW BATTER…
Read full complaint
TL* THE CONTACT OWNED A 2017 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE UNDER THE HOOD WHILE PARKED AND UNOCCUPIED. THE FIRE DEPARTMENT WAS PRESENT, EXTINGUISHED THE FIRE, AND STATED THAT THE FIRE INITIATED AROUND THE BATTERY AREA. A FIRE DEPARTMENT REPORT WAS FILED. THE CONTACT MENTIONED THAT A NEW BATTERY WAS INSTALLED A WEEK PRIOR THE FAILURE. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS TOWED AND DEEMED DESTROYED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE DEALER WAS NOT CONTACTED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
NHTSA ODI #11257848
21,764 miles · Sep 17, 2019
EngineVehicle Speed Control
I WAS DRIVING FROM KELLOGG, MN TO WINONA, MN AND I STOPPED AT LARK TOYS. WHILE JOINING MN HIGHWAY 61, TURNING RIGHT I HAD TO ACCELERATE. I WAS IN SPORT MODE AND VEHICLE ACCELERATED AND ALMOST STOPPED. LUCKILY NO ACCIDENT OCCURRED, I HAD MY 17 MONTH KID AND MY WIFE IN THE CAR. CAR AFTER THAT GAVE CHECK ENGINE LIGHT WARNING AND IT…
Read full complaint
I WAS DRIVING FROM KELLOGG, MN TO WINONA, MN AND I STOPPED AT LARK TOYS. WHILE JOINING MN HIGHWAY 61, TURNING RIGHT I HAD TO ACCELERATE. I WAS IN SPORT MODE AND VEHICLE ACCELERATED AND ALMOST STOPPED. LUCKILY NO ACCIDENT OCCURRED, I HAD MY 17 MONTH KID AND MY WIFE IN THE CAR. CAR AFTER THAT GAVE CHECK ENGINE LIGHT WARNING AND IT WOULD NOT ACCELERATE. I CHANGED TO ECO MODE AND THEN IT SLOWLY STARTED TO ACCELERATE, BUT AT ABOUT 20 MILES AN HOUR IT JERKED AGAIN, BUT I PRESSED ACCELERATE HARD AND IT SUSTAINED SPEED. BUT IT WONT GO OVER 65 MILES AN HOUR. I SLOWLY MADE IT HOME. BUT I TRIED TO DRIVE AGAIN AND SAME ISSUE. CALLED HYUNDAI CUSTOMER SUPPORT AND THEY REFUSED TO ROCHESTER AS IT IS 46 MILES AND THEY ONLY SUPPORT 20 MILES OR LESS TOW. MY CAR IS STILL UNDER MANUFACTURE WARRANTY AND YET WORST SERVICE. I ALMOST GOT KILLED TODAY WITH MY 17 MONTH TODDLER
NHTSA ODI #11256056
53,000 miles · Sep 4, 2019
Unknown Or Other
WHILE IN MOTION THE VEHICLE EITHER BRAKES OR BACKFIRES. THE JERKING MOTION IS SO HARD THAT I THOUGHT I WAS HIT BY ANOTHER CAR. THE CAR CONTINUES TO DRIVE BUT ACCELERATION RATE SLOWS DRASTICALLY CAUSING NEAR MISSES AS WELL. THE TRACTION CONTROL AND DOWNHILL SHIFTING LIGHTS COME ON AND STAY ON UNTIL YOU TURN THE ENGINE OFF AND B…
Read full complaint
WHILE IN MOTION THE VEHICLE EITHER BRAKES OR BACKFIRES. THE JERKING MOTION IS SO HARD THAT I THOUGHT I WAS HIT BY ANOTHER CAR. THE CAR CONTINUES TO DRIVE BUT ACCELERATION RATE SLOWS DRASTICALLY CAUSING NEAR MISSES AS WELL. THE TRACTION CONTROL AND DOWNHILL SHIFTING LIGHTS COME ON AND STAY ON UNTIL YOU TURN THE ENGINE OFF AND BACK ON. SO FAR THIS HAS HAPPENED FOUR TIMES IN BOTH NORMAL AND ECONOMY DRIVE MODES WHILE TRAVELING ON THE INTERSTATE/HIGHWAY AT SPEEDS BETWEEN 50 AND 70 MPH.
NHTSA ODI #11253205
Official recalls
6Feb 3, 2022
Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.
Sep 20, 2017
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.
Consequence & remedy
Consequence: The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.
Remedy: Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.
Jun 5, 2017
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Consequence & remedy
Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Mar 6, 2017
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An underinflated inflated tire can increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.
Nov 21, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Additional source detail variants (2)
Trailer Hitches
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Electrical System:wiring
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Mar 10, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.
Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP24001 · 3.3L Engine Loss Of Motive Power (lomp)
Opened Feb 8, 2024 · Closed May 16, 2024
Status: closed (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegations of a loss of motive power, often resulting in an engine seizure. The stall is preceded by a knocking sound, decreased performance and no warning lights. An analysis of the subject vehicle population was undertaken using complaints submitted to ODI along with manufacturer data. It was determined that the frequency of events is low for the subject population, while those that specifically report a loss of motive power event have a high mileage at the time of incident. The 2017 Santa Fe is equipped with a service interval reminder for the consumer that must be set by the consumer themselves or at a dealership. A Technical Service Bulletin (19-EM-002H) instructs the dealership to set the maintenance reminder at the completion of routine maintenance service or anytime a repair is performed that requires new engine oil. This maintenance reminder will help reinforce the need for proper oil maintenance intervals. Additionally, the Santa Fe vehicles with 3.3L V-shaped Lambda-II engines will be added to Hyundai’s existing Technical Service Bulletin (23-EM-007H) related to combustion chamber cleaning. These actions will help limit negative consumer incidents related to loss of motive power. Lastly, Hyundai has extended the limited engine warranty for MY 2013-2019 Santa Fe vehicles equipped with 3.3L V-shaped Lambda-II engines included in the Petition. The updated coverage is 15 years, or 150,000 miles and details are contained in Technical Service Bulletin 24-EM-003H. In view of the service interval reminder, combustion chamber cleaning, and extended warranty actions being taken by Hyundai, ODI is denying this Defect Petition. The agency reserves the right to take additional action if warranted by future circumstances. To review the report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration