Engine. Review the 643 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 161 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

14 crash reports23 fire reports11 injury reports

Structure complaints

7 reports

Clear category filter

Mileage unknown · Nov 17, 2025

Structure

The contact owns a 2017 Hyundai Santa Fe. The contact stated that the tailgate and the hood unintendedly lowered after being raised and struck the contact. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ODI #11699911

Mileage unknown · Jan 23, 2025

Structure

The back passenger door will not open from outside or inside (driver side) which is safety issue that needs to be recalled immediately.

NHTSA ODI #11638130

Mileage unknown · Apr 17, 2023

Structure

Read full complaint

While just entering the freeway my hood flew open at approximately 65-70 mph, hit and broke the windshield, causing me to run off the road. The vehicle exhibited no prior indications that the hood could fly up. The vehicle was taken to a Hyundai dealership and we were told that we needed to contact Hyundai Customer Care that the dealership could not do anything until a Claims Manger contacted them. Upon contacting Customer Care a claim number was assigned and the Hyundai claims manger eventually called saying that this defect is not covered under the recall 163 (TSB# 17-01-050 for Secondary Latch Cable) because the manufacture date is 7/30/2016 and the recall dates are 7/12/2012 through 6/27/2016. This is only 33 days after the recall period ended and sounds like the Hyundai factory had an escape of a bad vehicle. I took pictures of the secondary latch cable, it shows corrosion, and uploaded to the Hyundai website at the advice of the Customer Care Representative. After a lengthy period time the Hyundai Clams Manager reported, on a recorded line as he stressed, that his management did not see this as a warranty or goodwill repair and suggested that I make an insurance claim for the repair and for a rental car. My wife, mother in law and children were not physically injured but emotionally rattled. We've had no choice but to drive the vehicle, with the hood secured alternate DIY means, as we awaited disposition by Hyundai. We now have no choice but to arrange both repair and loaner vehicle by ourselves. Again, the vehicle manufacture and recall date range are only 33 days apart - this smells of an escape from the Hyundai manufacturing plant. Also, isn't the purpose of the secondary latch to prevent the hood from flying up if the primary latch fails or is partially / false latched? Please contact me if you need any additional information i.e. Claim number, Claims Manager name, etc.

NHTSA ODI #11517504

80,000 miles · Mar 20, 2023

StructureInjury

Read full complaint

The contact owns a 2017 Hyundai Santa Fe. The contact stated while she was parked in her driveway, she was at the back of the vehicle and had lifted the lift gate to place items in the back when the lift gate inadvertently came down on the contact's neck. The contact was trapped by the liftgate and struggled to pull her head out. The contact had hurt her neck in the process of freeing herself and had set up an appointment with a doctor. The contact stated no warning lights or chimes were heard or noticed. The contact had not taken the vehicle to a dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 80,000.

NHTSA ODI #11512865

Mileage unknown · Sep 2, 2022

Structure

The back hatch does not stay up when you open it falls down with no warning

NHTSA ODI #11482596

37,000 miles · Dec 30, 2018

Structure

SUNROOF EXPLODED DRIVING AT SPEED LIMIT ON FREEWAY,DRY,CLEAR,NO SNOW,NO VEHICLES NEAR,ESP IN FRONT OF VEHICLE.LOUD BANG,THOUGHT TIRE BLEW OUT,PULLED OVER,SAW ROOF GLASS BROKEN.WIND SCREEN WAS FORWARD,SO NO GLASS PARTICLES RAINED DOWN,BUT THIS IS SAFETY HAZARD AS L OFTEN DRIVE MY CHILDREN & GRANDCHILDREN IN THIS VEHICLE.

NHTSA ODI #11164077

8,000 miles · May 14, 2017

EngineFuel/propulsion SystemStructure

Read full complaint

THE "CHECK ENGINE LIGHT" INDICATOR TURNED ON, AND THERE WAS A RECOGNIZABLE FAILURE IN ENGINE WHEN SRTARTING. TOOK IT BACK TO DEALERAND TOOK NEARLYA MONTH TO FIND THE INCONVINIENCE AND TWO WEEKS TO FIX IT. THEY CALL ME BACK TO ANNUONCE ME IT WAS READY AND BY THE TIME I WAS RECIVING I NOTICED THE AIR CONDITIONAR NOT FUNCTIONING AT ALL. ONCE AGAIN ONE MORE WEEK TO FIND THE MISSFUNCTIONING AND REPARING, NOW THE VEIHICLE IS CONSUMMING TO MUCH GASOLINE (ALMOST HALF TANK IN 87 KILOMETER) THE INJECTORS PROBLEM PLEVAILS. I GET THE SANTA FE IN MXICO, CIUDAD JUAREZ CHIHUAHUA AT HYNDAI PENTA IS THE NAME OF THE AGENCY, AS A BRAND NEW VEHICLE WHIT 0 KILOMETERS AND I PAY IT IN CASH I HOPE YOU CAN HELP ME BECAUSE THEY DONT WANT TO RESPOND. THANK YOU.

NHTSA ODI #10985617

Official recalls

22V056000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Feb 3, 2022

Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.

17V578000 · Engine And Engine Cooling:engine

Sep 20, 2017

Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.

Consequence & remedy

Consequence: The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.

Remedy: Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.

17V358000 · Latches/locks/linkages:hood:latch

Jun 5, 2017

Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.

Consequence & remedy

Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.

Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.

17V142000 · Tires:pressure Monitoring And Regulating Systems

Mar 6, 2017

Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."

Consequence & remedy

Consequence: An underinflated inflated tire can increase the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.

16V842000 · Electrical System:wiring; Trailer Hitches

Nov 21, 2016

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

Additional source detail variants (2)

Trailer Hitches

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

Electrical System:wiring

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

16V145000 · Seat Belts:front:warning Light/devices

Mar 10, 2016

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.

Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP24001 · 3.3L Engine Loss Of Motive Power (lomp)

Opened Feb 8, 2024 · Closed May 16, 2024

Status: closed (inferred from source dates) · Engine

The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegations of a loss of motive power, often resulting in an engine seizure. The stall is preceded by a knocking sound, decreased performance and no warning lights. An analysis of the subject vehicle population was undertaken using complaints submitted to ODI along with manufacturer data. It was determined that the frequency of events is low for the subject population, while those that specifically report a loss of motive power event have a high mileage at the time of incident. The 2017 Santa Fe is equipped with a service interval reminder for the consumer that must be set by the consumer themselves or at a dealership. A Technical Service Bulletin (19-EM-002H) instructs the dealership to set the maintenance reminder at the completion of routine maintenance service or anytime a repair is performed that requires new engine oil. This maintenance reminder will help reinforce the need for proper oil maintenance intervals. Additionally, the Santa Fe vehicles with 3.3L V-shaped Lambda-II engines will be added to Hyundai’s existing Technical Service Bulletin (23-EM-007H) related to combustion chamber cleaning. These actions will help limit negative consumer incidents related to loss of motive power. Lastly, Hyundai has extended the limited engine warranty for MY 2013-2019 Santa Fe vehicles equipped with 3.3L V-shaped Lambda-II engines included in the Petition. The updated coverage is 15 years, or 150,000 miles and details are contained in Technical Service Bulletin 24-EM-003H. In view of the service interval reminder, combustion chamber cleaning, and extended warranty actions being taken by Hyundai, ODI is denying this Defect Petition. The agency reserves the right to take additional action if warranted by future circumstances. To review the report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.