NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
962 reportsMileage unknown · Oct 27, 2024
Engine
My car has 81,000 miles on it, I have had regular oil changes and after reading many recalls on here I see I am definitely not alone. My check engine light stays on, after paying $100. for dealer to check the codes I was told nothing in particular showed a problem even though I have to put oil in my car between oil changes and t…
Read full complaint
My car has 81,000 miles on it, I have had regular oil changes and after reading many recalls on here I see I am definitely not alone. My check engine light stays on, after paying $100. for dealer to check the codes I was told nothing in particular showed a problem even though I have to put oil in my car between oil changes and there are no leaks on drive. Apparently the 100K mile warranty is not being honored from the other reports I have read on here. Why ??? The price of new cars is beyond reach and if dealer is claiming there is a warranty there be should be way to make them honor it!!!
NHTSA ODI #11622151
Mileage unknown · Oct 26, 2024
Engine
The engine seized. Driving at 55 mph on a 4 lane highway outside of city limits, the vehicle went into limp mode. Luckily, it was later in the evening with less traffic and I was fortunate enough to be able to turn into a left turn lane and coast into an office building parking lot. There was no shoulder available if I had been …
Read full complaint
The engine seized. Driving at 55 mph on a 4 lane highway outside of city limits, the vehicle went into limp mode. Luckily, it was later in the evening with less traffic and I was fortunate enough to be able to turn into a left turn lane and coast into an office building parking lot. There was no shoulder available if I had been in the right lane and somewhat of a rural area. There were no sensors that alerted me prior to this happening. But, when it did happen the dash board lit up like a Christmas tree! It was 6:30 pm, I coasted into a parking spot in the lot and turned the car off. It would not start and I contacted a tow service. I had it towed to an automotive shop near my home. They confirmed the next morning, that there was no oil on the dip stick and the engine seized. They alerted me to the fact that this has become a common problem with this Hyundai engine. I then had the vehicle towed the Hyundai dealership where we purchased the vehicle. We are the original owner. The vehicle is sitting at Rosen Hyundai in Algonquin, IL and should be available for inspection. Monica at the dealership called me after the inspection and confirmed that this is a common issue with this vehicle. She at first used the word recall...and when I asked if there was a recall, she said not a recall, but Hyundai has issued a BULLETIN about this problem. At first, she stated that my maintenance records were in order and being the original owner I qualified to file a claim with Hyundai for engine replacement. 3 days later, she called and stated that Hyundai needed more proof of maintenance than what they could pull off Carfax or my claim was going to be denied. She sent me a picture of the engine and stated that the valves show neglect. I replied of course they do....the engine seized! There was never ever any low oil warning light, check engine or or any warning lights what so ever prior to the event! Hyundai admitted that there is no low oil sensor warning.
NHTSA ODI #11622077
97,000 miles · Oct 23, 2024
Engine And Engine Cooling
The contact owns a 2017 Hyundai Santa Fe. The contact stated while starting the vehicle, there was an abnormal ticking noise detected. There were no warning lights illuminated. The contact stated the noise was coming from cylinder #3 and the lifters. The vehicle was taken to the dealer, who was unable to duplicate the failure wh…
Read full complaint
The contact owns a 2017 Hyundai Santa Fe. The contact stated while starting the vehicle, there was an abnormal ticking noise detected. There were no warning lights illuminated. The contact stated the noise was coming from cylinder #3 and the lifters. The vehicle was taken to the dealer, who was unable to duplicate the failure while starting the vehicle. The vehicle was not diagnosed or repaired. The vehicle was taken to another local dealer Service Center at Gurley Leep Hyundai (5302 Grape Rd Suite #3, Mishawaka, IN 46545); which determined that the cam shaft and pump electronic body sensor, ABS, and harness needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 97,000.
NHTSA ODI #11621577
Mileage unknown · Oct 18, 2024
Electrical System
The liftgate randomly closes and I have to jump out of the way to avoid it hitting me. This obviously poses a huge risk to my young children when they are nearby. In addition to that, the liftgate will sometimes only open a quarter or half of the way, sometimes all the way then suddenly reverse and start closing, and sometimes …
Read full complaint
The liftgate randomly closes and I have to jump out of the way to avoid it hitting me. This obviously poses a huge risk to my young children when they are nearby. In addition to that, the liftgate will sometimes only open a quarter or half of the way, sometimes all the way then suddenly reverse and start closing, and sometimes does not open at all. I've gone on Hyundai forums online and found numerous other people with the exact same complaint. Seems to be effecting cars made from 2016 - 2020. I have multiple videos of this but can't upload them as you only accept pictures.
NHTSA ODI #11620590
Mileage unknown · Oct 15, 2024
EnginePower TrainUnknown Or Other
While driving a 1/2 second squeal came from engine compartment. Motor immediately stopped. No power steering or brakes. Vehicle is available for inspection. We were on an interstate We coasted to shoulder. There issue is frequent on Internet forums. A trusted mechanic old us the engine was totally seized. Could be turned manuall…
Read full complaint
While driving a 1/2 second squeal came from engine compartment. Motor immediately stopped. No power steering or brakes. Vehicle is available for inspection. We were on an interstate We coasted to shoulder. There issue is frequent on Internet forums. A trusted mechanic old us the engine was totally seized. Could be turned manually. No oil in crankcase. At this time only aforementioned mechanic has inspected the vehicle. No warning sounds or performance changes prior to incident. No warning lights or notice warnings were seen prior coincident.
NHTSA ODI #11620000
Mileage unknown · Oct 15, 2024
Engine
Since this vehicle reached about 75,000 miles, it has been burning oil like crazy. We have to add a quart every 7-10 days. It drives fine, there’s no oil leaks, no smoke from the tailpipe. We took the car to Hyundai and they did their oil consumption tests. They came to the conclusion that this was within the normal range and wo…
Read full complaint
Since this vehicle reached about 75,000 miles, it has been burning oil like crazy. We have to add a quart every 7-10 days. It drives fine, there’s no oil leaks, no smoke from the tailpipe. We took the car to Hyundai and they did their oil consumption tests. They came to the conclusion that this was within the normal range and would do nothing for us. This needs to be fixed, Hyundai!
NHTSA ODI #11619964
Mileage unknown · Oct 15, 2024
Engine
The engine consumed all of the oil and now has to be replaced
NHTSA ODI #11619790
121,000 miles · Oct 11, 2024
Electrical SystemService Brakes, Hydraulic
The contact owns a 2017 Hyundai Santa Fe. The contact stated that while his wife was driving at undisclosed speeds, the vehicle lost automotive power and the vehicle failed to stop while depressing the brake pedal. The vehicle was allowed to decelerate and come to a stop. No warning light was illuminated. The vehicle was towed t…
Read full complaint
The contact owns a 2017 Hyundai Santa Fe. The contact stated that while his wife was driving at undisclosed speeds, the vehicle lost automotive power and the vehicle failed to stop while depressing the brake pedal. The vehicle was allowed to decelerate and come to a stop. No warning light was illuminated. The vehicle was towed to a local dealer where it was diagnosed and determined that the alternator needed to be replaced. The vehicle was repaired. In addition, the contact stated that the engine was previously replaced and the contact was concerned that the warning lights on the instrument panel might not properly display because the check engine warning light had not illuminated during the previous failure. The manufacturer was made aware of the failure. The failure mileage was approximately 121,000.
NHTSA ODI #11619332
Mileage unknown · Oct 9, 2024
Engine
Like many others, car consumed a quart of oil each 500-1,000 miles driven. Car received synthetic oil changes every other month along with additional quarts of oil in between oil changes. All service records maintained with receipts of additional oil quarts purchased. Car NEVER displayed any warning lights for low oil pressure o…
Read full complaint
Like many others, car consumed a quart of oil each 500-1,000 miles driven. Car received synthetic oil changes every other month along with additional quarts of oil in between oil changes. All service records maintained with receipts of additional oil quarts purchased. Car NEVER displayed any warning lights for low oil pressure or check engine lights. While driving on the highway at 65 MPH, engine seized. Was able to pull over safely and had car towed to the dealership. Service manager at dealer claims it will be over $20k to fix but Hyundai is only willing to cover 70% because it’s no longer covered under warranty and isn’t backed by their extended warranty offer. What a way to admit fault but gaslighting the consumer into believing it’s the consumer’s fault for a faulty product. Hyundai does not allow outside mechanics to look at vehicle or make repairs if you want them to take responsibility. So stuck with paying inflated dealer fees for repair and labor.
NHTSA ODI #11618953
142,500 miles · Oct 8, 2024
Engine
The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving at an undisclosed speed, the engine was making an abnormal sound and the RPM increased. In addition, the contact stated that every 2,000 miles engine oil needed to be added to the vehicle. The vehicle was taken to an independent mechanic where it was diag…
Read full complaint
The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving at an undisclosed speed, the engine was making an abnormal sound and the RPM increased. In addition, the contact stated that every 2,000 miles engine oil needed to be added to the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed with a cracked valve cover and excessive oil consumption. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the repair was not covered under warranty due to the codes received per the diagnostic test. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 142,500.
NHTSA ODI #11618780
Official recalls
6Feb 3, 2022
Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.
Sep 20, 2017
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.
Consequence & remedy
Consequence: The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.
Remedy: Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.
Jun 5, 2017
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Consequence & remedy
Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Mar 6, 2017
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An underinflated inflated tire can increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.
Nov 21, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Additional source detail variants (2)
Trailer Hitches
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Electrical System:wiring
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Mar 10, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.
Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP24001 · 3.3L Engine Loss Of Motive Power (lomp)
Opened Feb 8, 2024 · Closed May 16, 2024
Status: closed (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegations of a loss of motive power, often resulting in an engine seizure. The stall is preceded by a knocking sound, decreased performance and no warning lights. An analysis of the subject vehicle population was undertaken using complaints submitted to ODI along with manufacturer data. It was determined that the frequency of events is low for the subject population, while those that specifically report a loss of motive power event have a high mileage at the time of incident. The 2017 Santa Fe is equipped with a service interval reminder for the consumer that must be set by the consumer themselves or at a dealership. A Technical Service Bulletin (19-EM-002H) instructs the dealership to set the maintenance reminder at the completion of routine maintenance service or anytime a repair is performed that requires new engine oil. This maintenance reminder will help reinforce the need for proper oil maintenance intervals. Additionally, the Santa Fe vehicles with 3.3L V-shaped Lambda-II engines will be added to Hyundai’s existing Technical Service Bulletin (23-EM-007H) related to combustion chamber cleaning. These actions will help limit negative consumer incidents related to loss of motive power. Lastly, Hyundai has extended the limited engine warranty for MY 2013-2019 Santa Fe vehicles equipped with 3.3L V-shaped Lambda-II engines included in the Petition. The updated coverage is 15 years, or 150,000 miles and details are contained in Technical Service Bulletin 24-EM-003H. In view of the service interval reminder, combustion chamber cleaning, and extended warranty actions being taken by Hyundai, ODI is denying this Defect Petition. The agency reserves the right to take additional action if warranted by future circumstances. To review the report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration