My vehicle had oil consumption problems that were fixed with a new replacement engine now my catalytic converter is going bad due to engine oil consumption problems and the dealer I deal with is refusing to help with this issue. There is only around 50k miles on the new engine. I would greatly appreciate your help with this Than…
Read full complaint
My vehicle had oil consumption problems that were fixed with a new replacement engine now my catalytic converter is going bad due to engine oil consumption problems and the dealer I deal with is refusing to help with this issue. There is only around 50k miles on the new engine. I would greatly appreciate your help with this Thank you!
NHTSA ODI #11735297
Mileage unknown · May 1, 2026
EngineUnknown Or Other
On 4/17/26 McDonalds Hyundai of [XXX] , dealership performed an ECU update for THETA II Emissions logic improvement (Hyundai campaign number 9C2). Ever since that time the vehicle has been lurching during acceleration. This happens particularly when the vehicle has been sitting for several hours. I reported this to the dealershi…
Read full complaint
On 4/17/26 McDonalds Hyundai of [XXX] , dealership performed an ECU update for THETA II Emissions logic improvement (Hyundai campaign number 9C2). Ever since that time the vehicle has been lurching during acceleration. This happens particularly when the vehicle has been sitting for several hours. I reported this to the dealership on 4/28/26 (Scott, service manager) and to Hyundai on 4/29/26 (Hyundai Case Management #: 42610495). I noted to Hyundai that this same/similar problem has been reported by other owners ( see [XXX] ) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11735182
Mileage unknown · Apr 27, 2026
EngineFire
While driving home on the highway from our sons hockey game at about 8:30 pm we were going about 60 mph when the car made a noise and began smoking and as we were trying to pull over on the side of the highway noticed by the reflection of a passing car that the engine on our vehicle was on fire under the vehicle. We had to evacu…
Read full complaint
While driving home on the highway from our sons hockey game at about 8:30 pm we were going about 60 mph when the car made a noise and began smoking and as we were trying to pull over on the side of the highway noticed by the reflection of a passing car that the engine on our vehicle was on fire under the vehicle. We had to evacuate the vehicle quickly and get our children out on the side of a busy highway with fire showing under the front end of the car.
NHTSA ODI #11734049
Mileage unknown · Apr 23, 2026
Engine
My wife's 2017 Hyundai Santa Fe Limited experienced a sudden crack in the engine and lost oil without any warning signs. There were no warning lights, no check engine light, and no unusual noise before the engice crack. A certified independent mechanic inspected the vehicle and confirmed the engine has no oil, whick it did a cou…
Read full complaint
My wife's 2017 Hyundai Santa Fe Limited experienced a sudden crack in the engine and lost oil without any warning signs. There were no warning lights, no check engine light, and no unusual noise before the engice crack. A certified independent mechanic inspected the vehicle and confirmed the engine has no oil, whick it did a couple days before when I checked the oil and topped it off, which is the same issue described in Hyundai’s known engine safety recalls. I was never notified of any safety campaigns or recalls. I am not the first owner, so the required recall inspections and updates were never completed on this vehicle before I bought it. The sudden engine crack and loss of oil created a serious safety risk, especially because there was no warning before it happened and it almost left our family stranded two hours from home. This failure matches the symptoms described in Hyundai’s Theta II engine defect investigations. While at the mechanic shop, we were quoted $10,000 to get a new remanufactured engine put into this car. I certainly (and I know most families) don't have $10k sitting around waiting to be used for car repairs. I am requesting that NHTSA investigate whether this vehicle should be included in the affected group, and whether this engine failure is part of the broader safety defect already identified in many Hyundai engines from the same model years. This vehicle is currently parked in our yard waiting to be repaired or sold. I would prefer it be repaired by Hyundai since one of the car plants is only 1 hour from our house. I was unaware of the current safety recall until I read it today.
NHTSA ODI #11733373
Mileage unknown · Apr 23, 2026
Engine
My engine just died wont start has 121099 and hyundai wont fix it
NHTSA ODI #11733368
Mileage unknown · Apr 20, 2026
Engine
Seem like there was a recall on the 3.3L engines on the Hyundai Santa Fe starting January 26, 2017, for engine related knocking noise. My Vin is [XXX] according to the Manufacturing plate it was made in Korea released on January 04, 2017. I realize it is a 22-day window on the recall but after an oil change the motor has starte…
Read full complaint
Seem like there was a recall on the 3.3L engines on the Hyundai Santa Fe starting January 26, 2017, for engine related knocking noise. My Vin is [XXX] according to the Manufacturing plate it was made in Korea released on January 04, 2017. I realize it is a 22-day window on the recall but after an oil change the motor has started knocking the oil is the right viscosity, full to capacity, and oil filter changed. I drove 200 miles after an oil change then the motor started knocking. Is there a certain stamp on the cam shafts to verify which of the 420 vehicles are affected by this recall? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11732327
Mileage unknown · Apr 16, 2026
Engine
My 2017 Hyundai Santa Fe Sport 2.0T (Theta II 2.0L GDI Turbo engine) has been diagnosed with burned exhaust valves requiring a complete engine replacement. This is the second catastrophic powertrain failure on this vehicle in under two years. In July 2024, I paid $2,754 to replace the turbocharger at an authorized Hyundai dealer…
Read full complaint
My 2017 Hyundai Santa Fe Sport 2.0T (Theta II 2.0L GDI Turbo engine) has been diagnosed with burned exhaust valves requiring a complete engine replacement. This is the second catastrophic powertrain failure on this vehicle in under two years. In July 2024, I paid $2,754 to replace the turbocharger at an authorized Hyundai dealership (Wright Hyundai, [XXX] ). The burned valves are consistent with carbon buildup on intake valves, a widely documented and known deficiency of the GDI fuel delivery system used in the Theta II engine family. Carbon deposits restrict airflow, cause valve seating issues, and lead to valve failure. This is an inherent design characteristic of the engine, not a maintenance-related failure. At no point during my ownership — including during the turbocharger repair — was I informed of this known issue or advised of any preventive measures such as fuel system cleaning treatments. I am additionally concerned that the dealership's diagnostic process was incomplete. The service center diagnosed the burned valves and immediately recommended an engine replacement without performing a bearing clearance test or completing the full diagnostic flowchart. The dealership has refused to perform further diagnostics unless I pay additional fees, and has refused to share documentation from a tech line case opened with Hyundai corporate. Because diagnostics were halted at the burned valve finding, a connecting rod bearing failure — the specific defect covered under the Theta II class action settlement (In re: Hyundai and Kia Engine Litigation, NoXXX) — has not been ruled out as a contributing cause. Hyundai's National Consumer Affairs office (Case #XXX) denied my goodwill request without addressing either the known GDI carbon buildup issue or the fact that this is the second catastrophic failure on this engine platform. This vehicle has approximately 86,000 miles. I purchased it as a second owner in August 2020 at 42,730 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 5
NHTSA ODI #11731552
Mileage unknown · Mar 29, 2026
Engine
The vehicle is burning oil even when oil changes are done routinely. Then all of a sudden I have total loss of power will not go over 35 miles an hour. And climbing hill would not go over 20. It just happened no warning lights on dash So now I have a car that is still owning 8 grand on. So now a lawn ornament. I have seen…
Read full complaint
The vehicle is burning oil even when oil changes are done routinely. Then all of a sudden I have total loss of power will not go over 35 miles an hour. And climbing hill would not go over 20. It just happened no warning lights on dash So now I have a car that is still owning 8 grand on. So now a lawn ornament. I have seen on different formats. That there is hundreds having the same issue. Hyundai is not fixing the issue for any of us
NHTSA ODI #11727792
Mileage unknown · Mar 29, 2026
Engine
ENGINE. IT HAPPENED WHILE I WAS DRIVING. NO IT WASNT REPRODUCED OR CONFIRMED BY A DEALER, BUT HAVE BEEN TOLD BY A COUPLE AND ALSO ME SEEING THAT THE ENGINE WASNT ABLE TO MANUALLY BE CRANKED AT ALL. NO INSPECTION WAS DONE BY MANUFACTURR, POLICE, OR INSURANCE, BECAUSE IT DIDNT CAUSE A ACCIDENT. JUST ENGINE LIGHT WHICH HAVE BEEN RE…
Read full complaint
ENGINE. IT HAPPENED WHILE I WAS DRIVING. NO IT WASNT REPRODUCED OR CONFIRMED BY A DEALER, BUT HAVE BEEN TOLD BY A COUPLE AND ALSO ME SEEING THAT THE ENGINE WASNT ABLE TO MANUALLY BE CRANKED AT ALL. NO INSPECTION WAS DONE BY MANUFACTURR, POLICE, OR INSURANCE, BECAUSE IT DIDNT CAUSE A ACCIDENT. JUST ENGINE LIGHT WHICH HAVE BEEN REPORTED TO THE DEALERSHIP AND WAS TOLED THEY COULDNT FIX IT, BUT THAT WAS JUST STAYING ON ALL THE TIME FOR QUITE SOME TIME. NO FINALLY I WOULD LIKE TO SEE IF THIS CAN BE INVESTIGATED ON TO BE A RECALL SINCE THE ORIGINAL MILES ARE ONLY ABOUT 68000 AND SHOULDNT HAVE THESE PROBLEM AT THIS LOW MILEAGE.
NHTSA ODI #11727762
Mileage unknown · Mar 28, 2026
EngineFuel/propulsion SystemPower Train
I purchase the 2017 Santa Fe Sport in October of 2023 with just short of 80K miles. It was in great condition and had no issues. I have maintained it according to Hyundai specification and regular on schedule oil changes with recommended 5w-20 full synthetic. At approximately 100K miles, I experienced an oil pressure light on…
Read full complaint
I purchase the 2017 Santa Fe Sport in October of 2023 with just short of 80K miles. It was in great condition and had no issues. I have maintained it according to Hyundai specification and regular on schedule oil changes with recommended 5w-20 full synthetic. At approximately 100K miles, I experienced an oil pressure light on the dash, when checked, the engine was approximately 2 quarts low. From this point on, the engine started consuming oil at an increasing rate all while I maintained regular maintenance. First, 1 quart a month, or about 1200 to 1500 miles, then to 1 quart every 2 weeks or 800 miles. I maintained weekly checks on the oil level and on the evening of 3/24/2026, I had added a quart, bringing the level to the midway point between the high and low dipstick markings. On the afternoon of 3/24/26 while driving on the highway in heavy, but at speed limit, traffic on the highway, I experienced a loss of power and a check engine light. I was able to exit the highway but the car started to run very rough and unable to idle. Luckily, there was no traffic approaching when I turned off the exit and made a left into parking lot to shut off the vehicle. I will be having it towed to a dealership in the next few days for their analysis.
Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.
Consequence & remedy
Consequence: The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.
Remedy: Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Consequence & remedy
Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An underinflated inflated tire can increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Additional source detail variants (2)
Trailer Hitches
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Electrical System:wiring
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.
Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP24001 · 3.3L Engine Loss Of Motive Power (lomp)
Opened Feb 8, 2024 · Closed May 16, 2024
Status: closed (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegations of a loss of motive power, often resulting in an engine seizure. The stall is preceded by a knocking sound, decreased performance and no warning lights. An analysis of the subject vehicle population was undertaken using complaints submitted to ODI along with manufacturer data. It was determined that the frequency of events is low for the subject population, while those that specifically report a loss of motive power event have a high mileage at the time of incident. The 2017 Santa Fe is equipped with a service interval reminder for the consumer that must be set by the consumer themselves or at a dealership. A Technical Service Bulletin (19-EM-002H) instructs the dealership to set the maintenance reminder at the completion of routine maintenance service or anytime a repair is performed that requires new engine oil. This maintenance reminder will help reinforce the need for proper oil maintenance intervals. Additionally, the Santa Fe vehicles with 3.3L V-shaped Lambda-II engines will be added to Hyundai’s existing Technical Service Bulletin (23-EM-007H) related to combustion chamber cleaning. These actions will help limit negative consumer incidents related to loss of motive power. Lastly, Hyundai has extended the limited engine warranty for MY 2013-2019 Santa Fe vehicles equipped with 3.3L V-shaped Lambda-II engines included in the Petition. The updated coverage is 15 years, or 150,000 miles and details are contained in Technical Service Bulletin 24-EM-003H. In view of the service interval reminder, combustion chamber cleaning, and extended warranty actions being taken by Hyundai, ODI is denying this Defect Petition. The agency reserves the right to take additional action if warranted by future circumstances. To review the report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2017 Hyundai Santa Fe Problems, Complaints & Recalls | Skip That Year
Illustration