Engine. Review the 643 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 161 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

14 crash reports23 fire reports11 injury reports

Engine complaints

643 reports

Clear category filter

Mileage unknown · Aug 21, 2024

Engine

Engine failed due to metal shavings and oil consumption issue. CHeck engine light came on and I immediatley took for service. IT has been examined by car dealer who got approval for 90% of engine replacement. Feel it should be 100% and fall under 11006230 and be covered 100%

NHTSA ODI #11609933

Mileage unknown · Aug 18, 2024

Engine

car started doing a weird noise. car checked at dealership, mentioned that it was probably the engine but that there was no engine light on. Car released back to us since no warning light was on. Engine died about a week later while driving (luckily, we were in a parking lot and our kids were not in the car). vehicle has been at…

Read full complaint

NHTSA ODI #11609218

Mileage unknown · Aug 17, 2024

EngineUnknown Or Other

Read full complaint

Current mileage is 80,000. For the last 30,000 miles the engine oil burns or leaks within a month of it being changed. When I return to the shop to get yet another oil change. They investigate for leaks and find nothing. They end up topping it off vs charging me. As I barely put a hundred miles on the vehicle since the last change. Even when I barely drive between oil changes, I end up checking the stick frequently to ensure it’s not leaking or burning oil until the next change. Yet it always does. It also randomly acts like it doesn’t want to start. Doesn’t matter if it’s cold, hot or normal kind of day. Take it to dealer or auto repair shop for a diagnostic check and nothing is found. They check the starter, circuits, battery, and alternator. Nothing. This happens multiple times a yr. I’ve never owned a vehicle that does this before. Even my old 200+ mile vehicle never did this. This Hyundai is only 7 yrs old and under 85,000 miles. It’s baffling.

NHTSA ODI #11609097

Mileage unknown · Aug 12, 2024

Engine

Read full complaint

My 2017 Hyundai Santa Fe has roughly 120,000 miles on it and an engine light came on. I brought the vehicle into an automotive shop where they stated the vehicle was very low on oil, they checked the code and then reset it. After they drove the vehicle, it began "knocking" and the code came back on. They stated in the paperwork, "[t]his code is caused by the ecm getting a response from the solenoids that the camshaft is off; engine is not timed properly. This can be caused by a stretched timing chain or if the chain jumps a tooth." The oil has been changed less than 2,500 miles prior, no light ever came on to indicate that it was low, there was no indication that it was burning excessive amounts of oil, and I park in the same spot each day with no sign of oil leakage. There were no warning signs that the oil was low or that there were issues with the engine. This engine easily could have overheated and seized with absolutely no warning that it was coming. I was set to drive with my family across the country right before this happened and we easily could have been driving on the highway if/when the engine seized. The automotive repair shop quoted $9,149.01 to fix the issues and I owe a little more than $10,000 on it. I don't want to risk repairing it since the faulty engine will likely have this issue again in the near future and I am at a loss for how to proceed, especially with many having the same issue.

NHTSA ODI #11608088

Mileage unknown · Aug 9, 2024

Engine

Read full complaint

On 7/24/24 I was driving off the expressway near my home when as I was switching lanes the vehicle made a loud clunk noise (it was like the sound of a lock turning but louder) and stopped accelerating, eventually coming to a full stop in the middle of the lane. Since I was blocking the lane, and it was during rush hour, I called the police to have them escort me out of the lane and into the middle divide. I had my vehicle towed to my home where my personal mechanic showed up to do an inspection. He tried turning on the car, but it only made a single-clicking noise. Next, he checked the oil and discovered that the dipstick was completely dry. He advised that the engine was seized due to no oil and suggested that I reach out to the location I had my last oil change at. An independent inspector completed a diagnostic on the vehicle and concluded the following: The top of this engine was dry and there were no oil stains on the underside of the hood or pooled in the engine compartment to suggest this engine leaked or displaced oil from the fill hole area. The oil fill cap was in the valve cover, tight and properly orientated. The oil pan drain plug was tight in the pan and not leaking. No torque seal or paint had been used on the drain plug or the oil pan. There was no impact damage to the oil pan. The inspector verified the oil filter housing and cover were dry with no signs of an active leak. The inspector verified the engine had been leaking oil to an active drip from the rear main engine oil seal, valve cover gaskets and from the oil pan gasket. There was also an excessive amount of soot and wetness in the tailpipes consistent with excessive oil consumption and the inspector observed a film of oil was present on the rear of the vehicle at both sides further indicating excessive oil consumption. The inspector attempted to start the engine and verified there was only a single clunk noise audible in the engine it could not be rotated indicating it was internally seized.

NHTSA ODI #11607545

Mileage unknown · Aug 8, 2024

Engine

Read full complaint

My 2017 Hyundai Santa Fe Sport has less than 100,000 miles and has been regularly serviced. On [XXX], the vehicle stopped suddenly and dangerously on the highway. No warning light engaged. Fortunately, I was able to roll to the breakdown lane without causing an accident. The vehicle had traveled 2,828 miles since its last oil change on March 30, 2024. My mechanic, Todd's Auto Repair in Beverly, Massachusetts, looked for leaks and performed an oil change. The vehicle traveled 894 miles before requiring another 5 quarts of oil on June 11, 2024. The vehicle traveled another 969 miles since last service and required 3 quarts of oil on July 25, 2024. The mechanic is therefore confident that the engine is burning through the oil at an alarming rate, with no warning lamps, messages or other symptoms present to protect the driver. I have an appointment for the vehicle to be inspected by a Hyundai dealer on August 12, 2024. The service center scheduler was resolute that there is nothing the Hyundai corporation will do for oil over-consumption. Hyundai customer Facebook groups indicate that this is a very common problem, putting drivers in peril. We welcome an inspection should you request one. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11607309

Mileage unknown · Aug 6, 2024

Engine

Read full complaint

My stepson was driving the car and it stopped running while at a red light in a left turn lane on a busy intersection. When he went to try to start it, it wouldn't turn over. Fortunately 2 officers showed up on scene to protect my stepson and his friends from an accident by blocking the lane behind the car. I arrived at the site of the incident and tried to start the car. When it wouldn't turn over I checked the oil and there was none on the dipstick. We just had numerous seals replaced on the engine within the last 8000 miles. We had it towed to a trusted shop that we frequent. They said that the motor was seized and there was no evidence of leaks. I called the local Hyundai dealer and I was told there was no coverage for the engine. Looking online I found many complaints from other people that have had the same issue with the same 3.3 liter engine. The engine was resealed due to leakage, however I had never needed to top off the oil since I bought the car. I have the oil changed every 3,000 miles or so. The shop that resealed the engine never took the heads off and stated that they did not see any evidence of major engine issues when they had the oil pan off. According to my stepson, there was never any warning and no lights on the dash.

NHTSA ODI #11606911

Mileage unknown · Aug 5, 2024

Engine

head gasket blown without prior warning and rapid engine oil consumption. Car will power down in the middle of Hight speed traffic potentially causing an accident. Car less than 7year old.

NHTSA ODI #11606591

Mileage unknown · Jul 25, 2024

Engine

Read full complaint

2017 Santa Fe 2.4 L bought at 70,000 miles. We stalled on the highway which was terrifying. We could have been hit or caused an accident. Check engine light went on at this time and there was a knocking sound. Took to Firestone mechanic right away, they said they found metal shavings within the engine and that we would need a total engine replacement which would be up to $10,000. We did a google search and there are thousands of other Hyundai Santa Fe 2017 owners with the same issue. This happened at random the car was running perfectly. This is a safety issue and needs to be recalled. We are devastated having only bought this car 6 months ago and it’s only at 80,000 mile's!!! We can’t afford another car but it is a basic need where we live.

NHTSA ODI #11604406

Mileage unknown · Jul 22, 2024

Engine

Read full complaint

This vehicle has been well serviced. On 06.24.2024, with 55,857 odometer reading, it was being taken to the dealer because it was making engine noise but it seized on the way. I had just gotten on the interstate and up to 65mph when I lost all power and had to coast to the shoulder of the road and call a tow truck to get it the rest of the way. Stayed at the dealer for a couple of weeks before we received a call to tell us it wasn't covered under warranty because of time...understandable but not acceptable. So we reached out to Hyundai ourselves and got a representative to look into why it wouldn't be covered if there were obvious (what we have come to find out) issues.There are already TSBS indicating timing chain issues but in order to determine what the cause of failure was would require taking it apart which they weren't willing to do. It appears this will be the next class action lawsuit as there are too many having similar problems and Hyundai isn't willing to stand up.

NHTSA ODI #11603896

Official recalls

22V056000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Feb 3, 2022

Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.

17V578000 · Engine And Engine Cooling:engine

Sep 20, 2017

Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe vehicles equipped with 3.3L engines. The crankshaft assemblies may have been produced with surface irregularities in the crankshaft pin, causing engine bearing wear.

Consequence & remedy

Consequence: The engine bearing wear may cause the vehicle to stall, increasing the risk of a crash.

Remedy: Hyundai will notify all owners, and dealers will inspect and replace the engine, as necessary, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 168.

17V358000 · Latches/locks/linkages:hood:latch

Jun 5, 2017

Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.

Consequence & remedy

Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.

Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.

17V142000 · Tires:pressure Monitoring And Regulating Systems

Mar 6, 2017

Hyundai Motor America (Hyundai) is recalling certain 2017 Santa Fe Sport vehicles. The affected vehicles have a tire pressure monitoring system (TPMS) that may not have been set in the correct mode during vehicle assembly, and therefore will not provide an appropriate warning in the event of an underinflated tire. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."

Consequence & remedy

Consequence: An underinflated inflated tire can increase the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the TPMS sensors, free of charge. The recall began March 31, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for the recall is 159.

16V842000 · Electrical System:wiring; Trailer Hitches

Nov 21, 2016

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

Additional source detail variants (2)

Trailer Hitches

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

Electrical System:wiring

Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

16V145000 · Seat Belts:front:warning Light/devices

Mar 10, 2016

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.

Remedy: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP24001 · 3.3L Engine Loss Of Motive Power (lomp)

Opened Feb 8, 2024 · Closed May 16, 2024

Status: closed (inferred from source dates) · Engine

The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegations of a loss of motive power, often resulting in an engine seizure. The stall is preceded by a knocking sound, decreased performance and no warning lights. An analysis of the subject vehicle population was undertaken using complaints submitted to ODI along with manufacturer data. It was determined that the frequency of events is low for the subject population, while those that specifically report a loss of motive power event have a high mileage at the time of incident. The 2017 Santa Fe is equipped with a service interval reminder for the consumer that must be set by the consumer themselves or at a dealership. A Technical Service Bulletin (19-EM-002H) instructs the dealership to set the maintenance reminder at the completion of routine maintenance service or anytime a repair is performed that requires new engine oil. This maintenance reminder will help reinforce the need for proper oil maintenance intervals. Additionally, the Santa Fe vehicles with 3.3L V-shaped Lambda-II engines will be added to Hyundai’s existing Technical Service Bulletin (23-EM-007H) related to combustion chamber cleaning. These actions will help limit negative consumer incidents related to loss of motive power. Lastly, Hyundai has extended the limited engine warranty for MY 2013-2019 Santa Fe vehicles equipped with 3.3L V-shaped Lambda-II engines included in the Petition. The updated coverage is 15 years, or 150,000 miles and details are contained in Technical Service Bulletin 24-EM-003H. In view of the service interval reminder, combustion chamber cleaning, and extended warranty actions being taken by Hyundai, ODI is denying this Defect Petition. The agency reserves the right to take additional action if warranted by future circumstances. To review the report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.