2017 Hyundai Santa Fe

Problems with oil consumption/oil burning. Engine noise - mechanic said the timing chain socket is coming apart. Hyundai has had multiple issues with vehicles that have GDI LAMBDA II engine. In 2019, they recalled several makes with Lambda engine however my vehicle wasn’t one of them. Mechanic said it would cost $6200 to repair. Just to diagnose the issue was $440.

The engine on my car was consuming oil at a rapid rate. The dealer service department gave me the run around for many month. Stating they could never duplicate the issue. when clearly the whitish blue smoke pouring out of tailpipe and horrible combustion fumes inside cabin of car. At some point bluish smoke turned to black smoke and that when the $800 combustion test was suggested. Which they say will tell me if the engine is bad. how do they not know the signs of a bad engine. my car sat in service department for 2 months for them to say it's not covered under warranty. I tried everything to hold the manufacture responsible and they was unwilling to budge and help. The car has the extended warranty and my car was under the mileage and years. My car been sitting in my driveway since May 2024 needing a engine replacement. The fumes in cabin of vehicle was unbearable which cause me to have to drive with window down. Vehicle never show any warning lights when engine oil was low or empty. another incident was with the radio not turning off even after the battery went died. The radio continue to work and connect to phone when battery was died. After charging battery radio would again kill battery and not shut off. The only way it would shut off is to disconnect radio. How dealer explained the issue was that of a modem. That the car probably need to be reset when radio was disconnected it worked. But after that it happen 3 more times. these cars need to be recalled and all customer should get there money back. To own a 2005 Santa Fe with over 216,000 miles with no oil burning / leaking or smoke out tailpipe say a lot on the manufacturing of this vehicle. I have no mechanical issues with this car and that was the reason i wanted to upgrade to 2017. Now I wish I had never brought the 2017. Beware before buying this brand because they are no good.

Over the past year, the engine light continues to come on. The first time this happened, there was no oil in the reservoir even though it had recently had an oil change. They did another oil change and sent us on our way. The next time.[XXX], the check engine light came there was a loud clanking sound and low oil again. This was the code the dealership said it was: Code P0021 [XXX] . He suggested a tune-up at this time. He says the engine light should stay off. We just need to continue to check the oil. [XXX]. Check engine light came on again as my son was driving. He lost pressure is the gas pedal. When he pushed it, the vehicle would not accelerate. We has it towed to the same dealership On 10/2/24, they were finally able to tell us what Hyundai felt was wrong: Timing components will need to be replaced- the timing tensioner or chain has failed $4363.20. We pushed back because our personal mechanic said the following: We were told by our mechanic and some of the research that we did that the breaking of the timing chain is connected to the loss of oil pressure that has been happening because of the default in the engine which is part of the recall for that vehicle. What can they tell us about that? Those timing chains are supposed to last a long time and not go out at 130,000 miles or whatever the odometer reading is now. Can this be considered in the recall information for replacing the engine? It does not seem that they're really working with us or helping us on this. Our contact person went back to his shop foreman who went back to Hyundai to ask about this. He then said his shop foreman said it doesn't seem to be directly related to that warranty extension TXX8 - but we will submit all information to Hyundai prior approval and see what they say. It then took him until October 14 to say the following: Hyundai is asking my master technician to remove the valve valve cover and inspect timing parts closer. We took it to another INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S

[XXX] this engine was replaced under the Hundai Theta Engine Settlement at 91,654 miles. I am the original owner. This problem first started when oil light was on and my regular mechanic sent me to Hyundai because engine required excessive amts of oil. Oil usage test conducted, engine replaced under the NATIONAL RECALL. I have maintained car with regular service before and since that time. 10-14/2024 Good Year Center did my routine oil change at 190,027 on this replacement engine. At time of service, this second engine had 91,463 miles since being replaced in 2022. I did service in readiness for upcoming Thanksgiving vaca. 11/29/29. on [XXX] [XXX] at Greenville, Ala...check engine light began flashing... car was vibrating, shaking, making noise...oil light also went on, I began losing power . I pulled off hwy at [XXX} exit..still making noise, slowing down.. got to bottom of ramp was able to coast into parking lot of station/rest. 189 miles from home. Checked oil...none on dipstick, still vibrating and making noise. man from station came to help and told me to shut it off. he checked oil, looked under car. nothing running out, filter on tight. He worked at restaurant was also a mechanic... Got his meter and read the codes...saying that spark plugs 3 &4 were bad. Spark plugs changed 1/18/24 at Good year service center. He put in 4 qts of oil. tried to start car, oil light and check engine light still flashing. When he removed 3 and 4 plug tips were burnt and singed black. replaced plugs, started car... both check in light (now steady on) and oil light still on. still idling very rough and vibrating with noise. checked spark plugs again.. when he removed plug, it was coated in oil. Car towed 189 miles. dealer said burnt valve, not related to oil all over engine. Engine cost at 7000-9000. Not warranty issue per dealer. reported to corporate, still no response INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.

My complaint is the dealership that said had completed the recall on my brake systems according to both your and state records was not completed. They gave me a service notice stating the work was done. Since then the braked have continued to act up and the vehicle as a strange acceleration problem. The dealership is Don Wood Hyundai in Athens Ohio.

The engine seized due to an issue with the oil plug and another part, leading to a lack of oil in the system. The vehicle is currently with Hyundai and available for inspection upon request. How Safety Was Put at Risk: While driving on the highway, I suddenly lost acceleration (below 40mphs). I was forced to pull over to the left side of the highway where it was shallow, where I risked being hit by passing vehicles until there was a safe break in traffic, allowing me to maneuver to an exit. This created a hazardous situation for both myself and other drivers. Reproduction or Confirmation of the Problem: The issue has been confirmed by an independent automotive technician, who diagnosed the problem as a blown engine caused by a lack of oil. The vehicle is now with Hyundai for further inspection. Inspection by Others: The vehicle has been inspected by an independent service center and is currently being inspected by Hyundai. No other parties, such as the police or insurance representatives, have been involved. Warning Lamps or Messages Prior to Failure: The only warning sign prior to the incident was the check engine light blinking at the time of the failure. There were no other warning lamps, messages, or symptoms before the engine seized. The vehicle was within the oil range limit of 7,500 miles at the time of the incident. Additional Notes: The incident occurred suddenly, without prior warning or indication of an issue. Based on the diagnosis and known issues with the oil plug, I believe this failure was caused by a defect.

I have Hyudai Santafe 2017 Sport, bought it from dealership in 2020 with 46,000 Miles and in around past 4/5 years added 30,000 miles. Which is not much, in the past one year i have noticed that engine oil is burning faster than usual. On every oil change after driving between 1200 and 1500 miles the oil engine sign blinks and upon checking needed 2 Quarts of oil. I spoke the dealership and they are not very helpfull. Also they did the oil combustion test which i was charged. Later i was advised to do. ("Good morning, Just got off the phone with you sir warranty won't cover it due to the vehicle being out of manufacture warranty and mileage. My technician recommended starting with combustion chamber cleaning which would be around 1200 before taxes and shop supplies. Combustion chamber cleaning is the process of removing carbon buildup from the combustion chamber and intake valves of a fuel-injection engine. to see if that fixes the problem that you are having with the car burning oil. If that step doesn't work we we would submit a warranty pa again, to see if they would cover a new engine." Please advise what should be my next step, as per my mechanic the only solultion right now i have is keep adding oil carefully.

I was driving my 2017 Hyundai Santa Fe and suddenly I heard the knock sound from the engine and when I pulled over, I saw the oil came down from the engine. I towed my vehicle to Hyundai dealership and they diagnosed the issue is vertical square and potential rod bearing failure. My vehicle has only 91k miles. I want to find out if there is any recall on this issue that happened to my car. Please let me know.