Engine. Review the 273 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

14 crash reports41 fire reports10 injury reports

Wheels complaints

14 reports

Clear category filter

61,000 miles · Jan 5, 2021

EngineFuel/propulsion SystemWheels

THE MOTOR STATED TO ACT UP. IT WAS DRIVING REGULAR THEN ALL AT ONCE THE MOTOR STARTED TO MAKE A GRINING NOISE THEN THE CAR SLOWED DOWN TO 20 MPA. I GOT SCARED THEN CAME HOME IT WAS SMOKING TOO. I PUT MY FOOT TO THE FLOOR AND NOTHING HAPPENED STILL GOING 20 MPA

NHTSA ODI #11386724

69,000 miles · Jul 5, 2019

Wheels

RIGHT SECTOR WAS ON RECALL BUT NOT THE LEFT. MY LEFT HAS SINCE BROKEN AND ABS LIGHT IS ON PLUS 2 OTHER LIGHTS. CAR DEALERSHIP WANTS 500.00 PLUS TO FIX IT. IFF IT RAINS OR BAD WEATHER I WILLLNT HAVE ABS.

NHTSA ODI #11229534

72,000 miles · Nov 12, 2018

EngineFuel/propulsion SystemWheelsFire

Read full complaint

I OWN A 2013 SANTA FE AND I HAVE HAD SEVERAL ISSUES WITH IT, THE ENGINE BEING REPLACED DUE TO FAILING WHILE DRIVING ON THE HIGHWAY, IT WAS SERVICED WITH A FEW OTHER ITEMS DEALER FOUND TO BE NEEDED FOR SOME RECALLS. BUT NONE I CAN RECALL FOR SURE WAS REGARDING THE ENGINE ITSELF, WILL NEED TO CHECK SERVICE RECORDS. THEN LATER IT WAS THE FUEL PUMP(INJECTOR) NEED TO VERIFY SPECIFICS, BUT GAS FUMES AND SMOKE COMING FROM THE ENGINE AND THIS WAS REPLACED, THEN LATER AGAIN HAD TO TAKE IN AGAIN FOR REPAIR DUE TO SERVICE ERROR OF TUBING BEING BENT ECT WHEN INSTALLED, NOTICED THE HIGH AMOUNT OF GAS FUMES AND SMOKE FROM THE ENGINE AND INTO THE CABIN. THIS WAS A FEW MONTHS AGO, THEN NOV 9 2018 MY CAR CAUGHT FIRE AND WAS DESTROYED BY FLAMES. I HAD JUST SECONDS TO PULL THE CAR OVER AND PUT IN PARK, GRAB MY 6 YEAR OLD SON AND GET OUT BEFORE FLAMES COVERED THE ENTIRE ENGINE THEN THE ENTIRE CAR. I WAS IN MY NEIGHBORHOOD AND PULLED OVER ON THE SIDE OF THE STREET. I WOULD LIKE TO START AN INVESTIGATION REGARDING THIS MATTER, I FEAR I AND MY SON COULD HAVE DIED DUE TO THIS KNOWN AND NEGLECTED ISSUE THESE SANTA FE'S HAVE BEEN HAVING. I HAVE HAD THE CAR SERVICED AT THE DEALERSHIP SO I WILL BE ABLE TO SUPPLY THE SERVICE REPORTS AND THE CASE NUMBER FOR THE WILLIAMSON COUNTY SHERIFF REPORT OF THE FIRE AND OTHER DOCUMENTS NEEDED. MY CELL [XXX] PLEASE LEAVE A MESSAGE IF I MISS YOUR CALL AND EMAIL INSTRUCTIONS AND OR INFORMATION NEEDED TO MOVE FORWARD. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI #11150942

Mileage unknown · Jun 1, 2018

Power TrainWheels

Read full complaint

TIRES WORE PREMATURE AND IT WAS DETERMINED TO BE THE FRONT LEFT HUB BEARING AT 41696 MILES.WE HAD BEEN HEARING A THUMPING NOISE AND IT SLOWLY WORSENED OVER TIME. TOOK IT BACK FOR ANOTHER NOISE IN THE REAR END. HYUNDAI DETERMINED IT TO BE THE COUPLER AND AXLES THAT HAD FAILED. SERVICE PERSON SAID IT COULD HAVE LOCKED UP AND CAUSED FURTHER DAMAGE. ALSO THE UPPER AND LOWER AC LINES WENT BAD AND NEEDED TO BE REPLACED. SERVICE PERSON SAID WE HAVE BEEN GETTING THREE TO FIVE A WEEK.

NHTSA ODI #11099260

70,000 miles · Dec 3, 2016

Wheels

Read full complaint

CONTINENTAL CROSSTRACK LX SPORT 235-55-19 TIRE HAD A LOUD BUMPING NOISE COMING FROM THE RIGHT FRONT TIRE. ALSO HAD NOISE SOUNDING LIKE WHEEL BEARING NOISE AT ALL SPEEDS UP TO 70 MPH.REPLACED TIRE WITH ANOTHER BRAND.ALL NOISE WENT AWAY AFTER REPLACING TIRE. CLOSE INSPECTION OF TIRE INSIDE AND OUTSIDE REVIELED NO DEFECTS OTHER THAN A RAISED AREA WHERE BELT COMES TOGETHER. THESE TIRES NEED FUTHER INVESTIGATION BY EXPERTS TO DETERMINE SAFETY ASPECTS OF THESE TIRES.VEHICLE WAS IN MOTION ON ALL TYPES OF ROADS UP TO 70 MPH. EVEN AT 20 MPH THE TIRE WAS MAKING A BUMP,BUMP NOISE. TIRE WAS NOT OUT OF BALANCE. RECOMMEND ALL THESE TIRES BE RECALLED DUE TO SAFETY CONCERNS.

NHTSA ODI #10929702

24,000 miles · Nov 10, 2015

Air BagsStructureWheelsCrashInjury

GOING ON SIDE STREET AT 25MPH WHEN CAR SUDDENLY LOST CONTROL THEN HIT A CAR TIRE ON THE RIGHT OF THE VEHICLE BUT THEN ROLLED OVER ON ITS HEAD. SIDE AIR BAGS DEPLOYED BUT NOT DRIVER AIR BAG. THIS CAR HAS TO BE UNSTABLE TO HIT ANOTHER CAR ON THE SIDE (SEE PICS) AND OVERTURN. BESIDES, THERE ARE ALREADY RECALLS ON SOME SANTA FE SPOR…

Read full complaint

NHTSA ODI #10789544

11,045 miles · Nov 4, 2015

SteeringUnknown Or OtherWheelsCrash

Read full complaint

I WAS DRIVING WEST ON U.S. HWY 80 AT ABOUT 30 MPH, AFTER PULLING OUT OF A PARKING LOT ABOUT 1 BLOCK BEFORE I LOST CONTROL OF MY 2013 HYUNDAI SANTA FE, AT AN INTERSECTION. IT MADE A SHARP RIGHT TURN WITHOUT MY HELP AT ALL. AFTER HITTING ANOTHER VEHICLE AND THEN JUMPING A LARGE CURB, I CAME TO STOP ABOUT 18" FROM A SMALL TREE. I WAS COMPLETELY TRAUMATIZED. THE RIGHT FRONT WHEEL HAD A BLOW OUT FROM THE OUTSIDE SIDE WALL OF THE TIRE. THE MECHANIC SAID IT LOOKED SLASHED. THE BIG QUESTION IS, DID THE BLOW OUT OCCUR AT THE TIME MY VEHICLE MADE THE SHARP RIGHT TURN AT THE INTERSECTION, OR DID IT OCCUR WHEN IT HIT THE CURB? I DON'T KNOW, BUT I FEEL SOMETHING HAPPENED TO CAUSE THAT SHARP RIGHT TURN IN THE FIRST PLACE. I HAD THE MECHANIC CHECK OUT THE RIGHT FRONT WHEEL AREA (AXLE, ETC). THEY SAID THEY COULDN'T FIND ANYTHING WRONG WITH THE VEHICLES PARTS, THAT WASN'T CAUSED BY THE ACCIDENT. THIS MAKES ME MORE CONVINCED IT HAS TO BE THE TIRE. THIS IS THE SECOND TIRE THAT HAS BLOWN OUT ON THE OUTSIDE WALL OF THE TIRE SINCE I PURCHASED THIS VEHICLE IN 2013. THE OTHER BLOW OUT WAS FROM A NAIL GOING THROUGH THE OUTSIDE WALL. I ONLY HAVE 11,045 MILES ON THIS VEHICLE. TIRES ARE A KUMHO, CRUGEN, P235/55R19, 101H SL BSW OE (INFORMATION COPIED FROM A DISCOUNT TIRE RECEIPT WHEN THE FIRST BLOW OUT WAS REPLACED 5-22-15). I AM AFRAID TO GET BACK IN THIS VEHICLE BECAUSE I DON'T KNOW WHAT CAUSED COMPLETE LOSS OF CONTROL. I WILL TRADE IT IN ON A DIFFERENT VEHICLE. I'M AFRAID OF HYUNDAI'S AND KUMHO TIRES!

NHTSA ODI #10788476

35,236 miles · Feb 25, 2015

SteeringSuspensionWheels

Read full complaint

WHILE DRIVING MY AWD SANTA-FE THROUGH SNOW. SNOW BEGINS TO BUILD UP ON TIRES AND RIMS AS DUE ALL VEHICLES. WHILE HAVING PARKED MY SANTA-FE FOR 30-45 MINUTES OR CONTINUALLY DRIVING THROUGH SNOW AND RETURNING TO DRIVE SAID SANTA-FE YOU START TO FEEL VIBRATIONS AND THEN VEHICLE STARTS VIOLENTLY SHUTTERING THE FASTER U GO. THE SNOW THROWS OFF THE WHEEL BALANCE AND MAKES CAR SHUTTER VIOLENTLY. THE ONLY FIX FROM DEALER IS PARK CAR IN WARM GARAGE WHILE PARKING OR SCRAP INNER WHEELS BEFORE DRIVING. YOU WOULD THINK ANY CUV/SUV WITH AWD SHOULD NOT HAVE THIS PROBLEM, REALLY ANY VEHICLE SHOULD NOT HAVE THIS PROBLEM. I GUESS I BOUGHT THE AWD TO STAY ON CLEAN DRY ROADS. DEFEATS THE PURPOSE OF AN AWD. GUESS IT WILL TAKE SOMEONE CRASHING BEFORE LOOKED INTO. MY FIX, BUY CAN OF NEVER WET AND SPRAY RIMS AND TIRES SO NO SNOW OR ICE STICKS TO WHEELS OR RIMS OR CHANGE RIMS MORE MONEY$ BUT BOTH WORK. SIMPLE, COMPLAIN AND SOLUTION RESOLVED

NHTSA ODI #10690518

Mileage unknown · Dec 26, 2013

Wheels

Read full complaint

WE RECEIVED A RECALL LETTER FOR THE SANTA FE SPORTS NHTSA CAMPAIGN NUMBER 13V-355. WE CALLED OUR SERVICE OFFICE (UNIVERSAL HYUNDAI ORLANDO). THEY WERE NOT VERY HELPFUL. 1) THE PART IS ON BACK ORDER AND THEY HAVE NO IDEA WHEN IT WILL BE AVAILABLE 2) WHEN THE PART COMES IN IT WILL TAKE AT LEAST 4 HOURS TO REPLACE AND WE WILL HAVE TO LEAVE THE CAR WITH HEM. 3) WE LIVE ABOUT 15 MILES FROM THE NEAREST HYUNDAI OFFICE. 4) THEY REFUSED TO OFFER A LOANEE CAR. THEY SAID WE COULD RENT A CAR FROM ENTERPRISE. IF A CAR IS RECALLED WE WOULD EXPECT THE PART TO BE AVAILABLE AND ALSO WE WOULD NOT EXPECT TO BE OUT OF POCKET BECAUSE OF THE RECALL. *TR

NHTSA ODI #10557274

18,981 miles · Nov 12, 2013

Power TrainWheels

Read full complaint

I SCHEDULED AN APPOINTMENT WITH FITZGERALD LAKEFOREST HYUNDAI IN GAITHERSBURG, MD ON 10/7/2013 FOR THE CAMPAIGN 112 RECALL, ALONG WITH AN OIL CHANGE AND TIRE ROTATION. WHEN I PICKED THE CAR UP, I WAS INFORMED THAT THE PART FOR THE RECALL HAD TO BE SPECIAL ORDERED AND THEY WOULD CALL WHEN THE PART CAME IN. A COUPLE OF WEEKS LATER, I RECEIVED A CALL FROM [XXX] IN THE SERVICE DEPARTMENT THAT THE PARTS WERE IN FOR THE RECALL AND FOR SOME SWITCHES THEY REPLACED IN MY CONSOLE UNDER A WARRANTY REPAIR. I TOOK THE CAR IN AGAIN ON 10/17/2013. THE DEALER TALKED ME INTO A LOANER CAR (AS I WAS ALREADY LATE FOR WORK AGAIN FOR THE SECOND TIME IN 2 WEEKS DUE TO THESE APPOINTMENTS). THEY SAID THE LOANER CAR WOULD BE FASTER. THE GUY INSIDE SAID I WOULDN'T HAVE TO PUT GAS IN THE CAR, BUT THE GUY OUTSIDE THAT WENT OVER THE CAR SAID THAT I WAS RESPONSIBLE FOR FILLING THE CAR BACK UP. I ENDED UP SPENDING $8.00 IN GAS FOR THE LOANER. I RECEIVED A CALL AROUND NOON ON THE 17TH THAT MY CAR WAS READY. I RETURNED THE LOANER AND PICKED UP MY CAR. I WENT OUTSIDE AND READ MY PAPERWORK AND REALIZED THEY STILL DID NOT DO THE SAFETY RECALL. NO ONE EVER TOLD ME THAT THE WORK WASN'T DONE. I WENT BACK INSIDE AND ALL THEY COULD SAY IS "SORRY." THE PART IS ON A "NATIONWIDE BACK ORDER" AND THEY WILL CALL ME WHEN IT COMES IN. I EXPLAINED THAT I WOULD HAVE NEVER BROUGHT IT BACK IN IF THEY DIDN'T HAVE THE PART. I WAS ADVISED FOR THE SECOND TIME THAT THEY DID HAVE THE PART. I STILL HAVE NOT HEARD FROM THE DEALER. HYUNDAI AND LAKEFOREST FITZGERALD HYUNDAI BETTER HOPE THAT I AM NOT INVOLVED IN AN ACCIDENT DUE TO THIS NEGLIGENCE. I'VE NEVER HAD SUCH A PROBLEM TRYING TO GET RECALL WORK PERFORMED. I'VE NOW MISSED HOURS FROM WORK AND HAD EXTRA FUEL EXPENSES FOR SOMETHING COMPLETELY OUT OF MY CONTROL. I STILL HAVE NOT BEEN CONTACTED. I REALLY DON'T TRUST LAKEFOREST FITZGERALD HYUNDAI ANYMORE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10551950

Official recalls

23V651000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Sep 22, 2023

Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.

17V358000 · Latches/locks/linkages:hood:latch

Jun 5, 2017

Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.

Consequence & remedy

Consequence: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.

Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.

13V355000 · Power Train:axle Assembly:axle Shaft

Aug 12, 2013

Hyundai is recalling certain model year 2013 front wheel drive Santa Fe Sport vehicles manufactured July 13, 2012, through March 12, 2013; and equipped with 2.4 liter engines. Due to a manufacturing issue, the right front axle shaft may fracture.

Consequence & remedy

Consequence: A fractured front axle may result in a loss of power to the wheels. Additionally, if the vehicle is parked without the parking brake applied, it may roll away. Either condition increases the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the front axle shaft assembly, free of charge. The recall began on September 19, 2013. Owners may contact Hyundai Custom Care Center at 1-800-633-5151. Hyundai's recall number is 112.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

EA21003 · Engine Fires

Opened Dec 22, 2021 · Closed Feb 5, 2024

Status: closed (inferred from source dates) · Engine

On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V-568, 17V-226, 20V-746, and 21V-727; and Kia recalls 17V-224, 19V-120, 20V-750, and 21V-844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V-877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines. The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS. It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP21003 · Throttle Control System Vulnerabilities

Opened Nov 12, 2021 · Closed Jun 20, 2023

Status: closed (inferred from source dates) · Vehicle Speed Control:throttle

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.

PE19003 · Non-crash Vehicle Fires

Opened Mar 29, 2019 · Closed Dec 22, 2021

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:alternator/generator/regulator; Electrical System:starter Assembly; Electrical System:starter Assembly:relay; Electrical System:starter Assembly:solenoid; Electrical System:wiring; Electrical System:wiring: Rear Compartment/trunk; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Engine; Engine And Engine Cooling; Engine And Engine Cooling:cooling System; Engine And Engine Cooling:cooling System:fan; Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings; Engine And Engine Cooling:cooling System:radiator Assembly; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:diesel; Engine And Engine Cooling:engine:gasoline; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys; Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control ; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor; Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve); Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:back Up Lights:switch; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch; Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Unknown Or Other

During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Hyundai Sonata and Santa Fe vehicles equipped with Theta II and Lambda II engines (approximately 1.3 million vehicles). ODI also reviewed field data of other Hyundai vehicles equipped with Theta II, Gamma, Nu and Lambda engines (approximately 4.8 million). As a result of this PE, Hyundai has issued NHTSA Recalls 20V-746 and 21V-727 to address potential engine failures and fires in certain Hyundai vehicles equipped with various engine types. Additional information on these and other related recall actions is available in the downloadable version of this resume available at NHTSA.gov. In addition, ODI has upgraded this PE to an Engineering Analysis (EA) 21-003 which will focus on potential recall scope concerns and recall remedy concerns related to the engine failure rewlated recalls mentioned above and conducted previously. See the EA21-003 Opening Resume available at NHTSA.gov for more information. Also available in the downloadable version of this resume is a list of the reference numbers for the 302 ODI reports, or Vehicle Owner Questionnaires (VOQs), cited above which ODI received through mid-November 2021. Note that the Manufacturer reports cited above are customer complaints received through March 2019.

Additional source detail variants (432)

Electrical SYSTEM:12V/24V/48V Battery:cables

Electrical SYSTEM:12V/24V/48V Battery

Electrical System:alternator/generator/regulator

Electrical System

Electrical System:starter Assembly

Electrical System:starter Assembly:relay

Electrical System:starter Assembly:solenoid

Electrical System:wiring:front Underhood

Electrical System:wiring:fuses And Circuit Breakers

Electrical System:wiring

Electrical System:wiring:interior/under Dash

Electrical System:wiring: Rear Compartment/trunk

Engine And Engine Cooling:cooling System:fan

Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings

Engine And Engine Cooling:cooling System

Engine And Engine Cooling:cooling System:radiator Assembly

Engine And Engine Cooling:engine:diesel

Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys

Engine And Engine Cooling:engine:gasoline

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Engine And Engine Cooling:engine

Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Engine And Engine Cooling:exhaust System:emission Control

Engine And Engine Cooling:exhaust System

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Engine And Engine Cooling

Engine

Exterior Lighting:back Up Lights

Exterior Lighting:back Up Lights:switch

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Exterior Lighting:fog Lights

Exterior Lighting:fog Lights:switch

Exterior Lighting:hazard Flashing Warning Lights

Exterior Lighting:hazard Flashing Warning Lights:switch

Exterior Lighting:hazard Flashing Warning Lights:unit

Exterior Lighting:headlights:concealment Devices

Exterior Lighting:headlights:high/low Beam Dimmer Switch

Exterior Lighting:headlights

Exterior Lighting:headlights:switch

Exterior Lighting

Exterior Lighting:tail Lights

Exterior Lighting:tail Lights:switch

Exterior Lighting:turn Signal:flasher Unit

Exterior Lighting:turn Signal

Exterior Lighting:turn Signal:switch

Fuel System, Gasoline:delivery:fuel Pump

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Fuel System, Gasoline:delivery

Fuel System, Gasoline

Unknown Or Other

DP18003 · Non-crash Vehicle Fires

Opened Aug 21, 2018 · Closed May 10, 2019

Status: closed (inferred from source dates) · Electrical System; Electrical System: Instrument Cluster/panel; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:alternator/generator/regulator; Electrical System:ignition; Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; Electrical System:ignition:module; Electrical System:ignition:switch; Electrical System:propulsion System:traction Battery; Electrical System:starter Assembly; Electrical System:starter Assembly:relay; Electrical System:starter Assembly:solenoid; Electrical System:wiring; Electrical System:wiring: Rear Compartment/trunk; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Engine; Engine And Engine Cooling; Engine And Engine Cooling:cooling System; Engine And Engine Cooling:cooling System:fan; Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings; Engine And Engine Cooling:cooling System:radiator Assembly; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys; Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control ; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor; Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve); Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch; Unknown Or Other

In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehicles. In a letter dated July 24, 2018, CAS requested that MY 2010-2015 Kia Soul vehicles be added to the petition. CAS stated that there is a higher number of complaints to NHTSA regarding non-crash fires on these vehicles compared to other similar vehicles. The Office of Defects Investigation (ODI) had already opened Recall Queries (RQ17-003 and RQ17-004) on all Kia and Hyundai vehicles equipped with Theta II engines for engine failures that may cause stalling and fires.The queries cover most of the petition subject Optima, Sorento, Sonata, and Santa Fe vehicles but not any of the subject Soul vehicles.On August 21, 2018, ODI opened a Defect Petition (DP18-003) to evaluate whether to grant or deny the CAS petition. ODI sent Information Request letters to Kia and Hyundai (September and October 2018) requesting information on all engine and non-engine related fires in the petition vehicles.ODI performed extensive analysis on the information obtained from Kia and Hyundai. During the DP18-003 analysis, Kia and Hyundai each initiated three additional safety recalls related to engine compartment fires on certain petitioned and non-petitioned vehicles (nearly 740,000 total vehicles: Recalls 18V-907, 18V-934, 19V-101, 19V-063, 19V-120, and 19V-204). Based on ODI?s review of the applicable materials, including responses to Information Requests sent to multiple manufacturers, Vehicle Owner Questionnaires (VOQ), and Early Warning Data, NHTSA decided to grant the petition.The CAS petition was granted on March 29, 2019. Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) have been opened to assess the scope, frequency, and potential safety-related consequences of alleged defects relating to non-collision vehicle fires in the 2011-2014 Kia Optima and Sorento, 2011-2014 Hyundai Sonata and Santa Fe, and 2010-2015 Kia Soul.Attached is a list of the reference numbers for the 404 VOQs cited above.

Additional source detail variants (208)

Electrical SYSTEM:12V/24V/48V Battery:cables

Electrical SYSTEM:12V/24V/48V Battery

Electrical System:alternator/generator/regulator

Electrical System

Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module

Electrical System:ignition

Electrical System:ignition:module

Electrical System:ignition:switch

Electrical System: Instrument Cluster/panel

Electrical System:propulsion System:traction Battery

Electrical System:starter Assembly

Electrical System:starter Assembly:relay

Electrical System:starter Assembly:solenoid

Electrical System:wiring:front Underhood

Electrical System:wiring:fuses And Circuit Breakers

Electrical System:wiring

Electrical System:wiring:interior/under Dash

Electrical System:wiring: Rear Compartment/trunk

Engine And Engine Cooling:cooling System:fan

Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings

Engine And Engine Cooling:cooling System

Engine And Engine Cooling:cooling System:radiator Assembly

Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys

Engine And Engine Cooling:engine:gasoline

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Engine And Engine Cooling:engine

Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Engine And Engine Cooling:exhaust System:emission Control

Engine And Engine Cooling:exhaust System

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Engine And Engine Cooling

Engine

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Exterior Lighting:fog Lights

Exterior Lighting:fog Lights:switch

Exterior Lighting:hazard Flashing Warning Lights

Exterior Lighting:hazard Flashing Warning Lights:switch

Exterior Lighting:hazard Flashing Warning Lights:unit

Exterior Lighting:headlights:concealment Devices

Exterior Lighting:headlights:high/low Beam Dimmer Switch

Exterior Lighting:headlights

Exterior Lighting:headlights:switch

Exterior Lighting:tail Lights

Exterior Lighting:tail Lights:switch

Exterior Lighting:turn Signal:flasher Unit

Exterior Lighting:turn Signal

Exterior Lighting:turn Signal:switch

Unknown Or Other

RQ17004 · Scope And Timeliness

Opened May 18, 2017 · Closed Dec 22, 2021

Status: closed (inferred from source dates) · Engine

NHTSA opened Recall Query (RQ) 17-004 to investigate the timeliness and scope of Hyundai?s Theta II GDI engine recalls (Recall Nos. 15V-568 and 17V-226), and Hyundai?s compliance with reporting requirements. On November 23, 2020, the Agency entered into a Consent Order with Hyundai to administratively resolve NHTSA?s assertions of violations of law in connection with RQ17-004. NHTSA?s assertions included that Hyundai may be liable for civil penalties on multiple grounds, including the untimeliness of Recall Nos. 15V-568 and 17V-226, inaccuracies in Hyundai?s recall reports, and that a required report describing potential safety-related issues contained certain inaccuracies or omissions.Under the Consent Order, Hyundai agreed to a total civil penalty of $140,000,000. The total civil penalty included payment of $54,000,000 as a Non-Deferred Amount. Hyundai also agreed to a sum of $46,000,000 as an Abeyance Amount to be deferred and held in abeyance pending its satisfactory completion, as reasonably determined by NHTSA, of the requirements of the Consent Order.Additionally, Hyundai agreed to a $40,000,000 Performance Obligation Amount to be expended by Hyundai to fulfill specified Safety Data Analytics Infrastructure obligations and Test and Inspection Laboratory obligations. The Consent Order also includes other terms designed to enhance Hyundai?s safety practices, and requires Hyundai to retain a Third-Party Auditor who directly reports to NHTSA.Other than RQ17-004, the Consent Order is not intended to affect any other current or future investigation which may involve vehicles equipped with Theta II GDI engines. In particular, Engineering Analysis (EA) 21-003 (which is upgraded from Preliminary Evaluation (PE) 19-003) continues NHTSA?s evaluation of certain performance and design issues relating to the Theta II and other engines.Nothing in the Consent Order discharges Hyundai from any obligation to comply with the Safety Act or regulations thereunder, including the obligation to carry out recalls in accordance with law, and to initiate a recall upon any future determination by Hyundai, or upon any finally adjudicated order from NHTSA, that vehicles equipped with Theta II GDI engines contain a defect related to motor vehicle safety or do not comply with an applicable FMVSS.This RQ is closed. Closure of this RQ has no bearing on the terms of the Consent Order, including Hyundai's ongoing performance obligations, and does not represent a determination by the agency as to Hyundai?s performance under the Consent Order to date.

Additional source detail variants (2)

Engine

PE13025 · Front Axle Shaft Failure

Opened Jul 5, 2013 · Closed Sep 20, 2013

Status: closed (inferred from source dates) · Power Train; Power Train:axle Assembly:axle Shaft

In a letter dated August 9, 2013, Hyundai-Kia America Technical Center, Inc. (Hyundai-Kia) submitted two Defect Information Reports (DIR) to NHTSA identifying a safety defect related to fracture of the right front axle shaft in MY 2013 front wheel drive Hyundai Santa Fe Sport vehicles built from July 13, 2012 through March 12, 2013 and MY 2014 front wheel drive Kia Sorento vehicles built from January 7 through March 12, 2013 (Recall Nos. 13V-355 and 13V-356).According to Hyundai-Kia, the right front axle driveshaft may develop a crack in the area of the stub at the wheel end of the shaft due to problems with the stub supplier's forging process for axles installed in vehicles built prior to March 12, 2013.When moving from a stop, the crack can lead to a separation of the shaft, causing a loud noise and loss of motive power.In addition, should the driver fail to engage the parking brake on an inclined surface, the vehicle may roll.In either case, a crash could result.ODI's review of consumer complaints and data submitted by Hyundai-Kia, identified 21 complaints alleging right-front axle shaft failure and 60 warranty claims related to right front axle replacements.All of the vehicles identified in the complaints and warranty claims were manufactured during the vehicle builds periods identified in the DIR.The Preliminary Evaluation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10524563, 10524274, 10508727, and 10505768.

Additional source detail variants (2)

Power Train:axle Assembly:axle Shaft

Power Train