Fuel/propulsion System. Review the 121 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

30 crash reports8 fire reports16 injury reports

What owners actually said

683 reports

67,694 miles · May 10, 2013

Power TrainSteeringStructureCrash

Read full complaint

THE HYUNDAI SANTA FE WAS PARKED WITHOUT THE KEY IN THE IGNITION ON A SLIGHT INCLINE. MY 7 YEAR OLD GRANDSON GOT IN THE VEHICLE FIRST. HE KNOCKED THE VEHICLE OUT OF PARK. WHEN THE VEHICLE STARTED ROLLING, I TRIED TO GET IN BUT I COULDN'T WITH IT ROLLING. IT HIT A VAN AND MY DRIVERS DOOR CAUGHT ON THE FRONT OF THE VAN PUSHING MY DRIVERS DOOR COMPLETELY BACK. I WAS CAUGHT BETWEEN THE TWO VEHICLES. MY 4 YEAR OLD GRANDKIDS (TWINS) COULD HAVE BEEN BEHIND THE SANTA FE OR ANOTHER CHILD SINCE WE WERE AT A BALL FIELD. NOW WE NOTICE THE SANTA FE CAN BE EASILY PULLED OUT OF PARK WITHOUT THE KEY IN THE IGNITION. *TR

NHTSA ODI #10511388

87,245 miles · May 8, 2013

Electronic Stability Control (esc)Vehicle Speed Control

Read full complaint

WHEN I WOULD BEGIN ACCELERATION THE VEHICLE WOULD HESITATE THEN TAKE OFF RAPIDLY THEN I WOULD LOOSE POWER TO A SPEED OF @ 15 MILES PER HOUR AND THE ESC OFF SWITCH WOULD APPEAR ON THE DASHBOARD FOLLOWED BY THE CHECK ENGINE LIGHT. I SAFELY PULLED OVER AND TURNED THE VEHICLE OFF FOR ABOUT 30 SECONDS. ONCE I TURNED THE VEHICLE BACK ON, THE DASHBOARD LIGHTS WOULD GO OUT AND I WOULD REPEAT THIS CYCLE 8-9 TIMES BEFORE BEING ABLE TO DRIVE NORMALLY. ON SEVERAL OCCASIONS AFTER DRIVING NORMALLY FOR ABOUT 10 MILES THE ESC OFF LIGHT WOULD REAPPEAR ON THE DASHBOARD AND I WOULD LOOSE POWER WHILE DRIVING SOMETIMES ON A HIGHWAY WHICH WAS EXTREMELY DANGEROUS TO GO FROM 60 MPH TO COASTING AT @ 15 MPH. DIAGNOSIS FROM THE CAR DEALER IS THE THROTTLE POSITION CENSOR AND THROTTLE BODY PART. IN MY OPINION THIS IS A SERIOUS MALFUNCTION AND CERTAINLY DANGEROUS COMBINATION AND SHOULD BE LABELED AS A RECALL. HYUNDAI SHOULD VALUE THE SAFETY AND EXPECTATIONS OF THEIR CAR BUYERS. WHEN WE AS CONSUMERS PURCHASE A VEHICLE WE EXPECT AN EXCELLENT QUALITY PRODUCT. I RESEARCHED THIS VEHICLE BEFORE PURCHASING AND WAS LED TO BUY IT BECAUSE OF THE MANY SOLID QUALITIES I FOUND. AS A CONSUMER, I AM DISAPPOINTED IN THIS MALFUNCTION AND EQUALLY DISAPPOINTED IN HYUNDAI FOR NOT STEPPING UP TO THE PLATE TO CORRECT THIS MAJOR SAFETY, QUALITY AND IMPORTANT ISSUE. FURTHERMORE, I WAS IN THE MARKET TO UPGRADE MY SANTE FE, HOWEVER NOW I WILL BE LOOKING INTO ANOTHER VEHICLE TO PURCHASE. *TR

NHTSA ODI #10511064

75,000 miles · Apr 26, 2013

Vehicle Speed ControlCrash

Read full complaint

WHILE ACCELERATING TO PASS A CAR, MY ACCELERATOR GOT STUCK AND I COULDN'T GET MY CAR TO STOP WITH THE BRAKES. THIS HAD HAPPENED ONCE BEFORE, A COUPLE OF YEARS AGO AND I WAS ABLE TO GET IT 'UNSTUCK' BY PUMPING BRAKE AND ACCELERATOR. I TOOK THE CAR IN TO BE CHECKED AND THE DEALER SAID THEY COULDN'T 'RECREATE' THE ISSUE AND THAT IT WAS PROBABLY MY FLOOR MATS. I BASICALLY CHALKED IT UP AS A FLUKE, ALTHOUGH I NEVER AGREED WITH THE FLOOR MAT SCENARIO. WHEN IT HAPPENED THIS TIME, I TRIED PUMPING BRAKES, ACCELERATOR, DOWNSHIFTING, ETC. AND THE CAR SLOWED DOWN SOME, BUT WOULDN'T ACTUALLY STOP UNTIL I RAN INTO THE BACK OF ANOTHER CAR. EVEN THEN, THE ENGINE WAS REVVING AND THE ONLY WAY I COULD GET IT TO STOP WAS TO TURN IT OFF. I WAS TOO AFRAID TO DRIVE IT AGAIN SO IT WAS TOWED AND IS BEING CHECKED FOR MECHANICAL MALFUNCTION. I SEE THAT THERE ARE NUMEROUS COMPLAINTS ABOUT THIS ISSUE AND DON'T UNDERSTAND WHY THERE HASN'T BEEN A RECALL!! *TR

NHTSA ODI #10509683

69,000 miles · Apr 23, 2013

Electrical SystemPower TrainVehicle Speed Control

Read full complaint

WHILE TRAVELING ON THE INTERSTATE AT APPROXIMATELY 70 MPH, I ATTEMPTED TO DEACTIVATE THE CRUISE CONTROL BY TAPPING ON THE BRAKE PEDAL. THE CRUISE CONTROL DID NOT TURN OFF EVEN WITH HOLDING THE BRAKE DOWN HARDER. I WAS ABLE TO SHUT OFF THE CRUISE CONTROL USING THE OFF SWITCH ON THE STEERING WHEEL. UPON EXITING THE INTERSTATE AND REACHING MY DESTINATION, I COULD NOT GET THE SHIFTER TO GO INTO PARK. AFTER SHUTTING THE CAR OFF AND ON SEVERAL TIMES, I GOT IT TO GO INTO PARK. IT HAS ONLY DONE THIS ONE TIME AND NEVER HAPPENED SINCE THEN. FORTUNATELY, I WAS DRIVING AND NOT MY TEENAGE DAUGHTER WHO NORMALLY DRIVES THIS VEHICLE. HER LACK OF EXPERIENCE MAY HAVE CAUSED HER TO PANIC WHEN THE CRUISE CONTROL FAILED TO DEACTIVATE WITH THE BRAKE PEDAL. *TR

NHTSA ODI #10509276

37,975 miles · Apr 11, 2013

Electronic Stability Control (esc)Service Brakes

Read full complaint

MY 2007 HYUNDAI SANTA FE WILL RANDOMLY APPLY THE BRAKES WHILE DRIVING. VERY DANGEROUS.THE BRAKES WILL APPLY MAKING THE CAR PULL TO THE RIGHT OR LEFT MAY CAUSE THE CAR TO VEER INTO THE NEXT LANE. I WOULD NEED TO PRESS ON THE BRAKES TO MAKE THEM RELEASE.THE FIRST TIME THIS HAPPENED I THOUGHT IT WAS THE BRAKE PADS NEEDING TO BE REPLACED WE REPLACED THE BRAKES AND THE PROBLEM DID NOT OCCUR AGAIN FOR MAYBE A YEAR.IT HAPPEN SO MUCH IN 2011& 2012 I DID NOT FEEL SAFE DRIVING THE CAR.I TOOK MY CAR TO HARDIN HYUNDAI 6/09/12 EXPLAINED IN DETAIL THAT THE BRAKES WOULD APPLY WHEN I WAS DRIVING, AND THE ESC LIGHT WAS COMING ON. I TOLD THE DEALERSHIP THAT WE HAD CHANGED THE BRAKE PADS HOPING THIS WOULD RESOLVE THE ISSUE IT DID NOT. THE DEALER RECOMMENDED 3 TIRES, ALIGNMENT AND PINS WERE MISSING WHEN WE DID THE BRAKE JOB AND THAT WAS CAUSING THE BRAKES TO STICK. WE DID WHAT WAS SUGGESTED.THIS DID NOT CORRECT THE PROBLEM.THE DEALERSHIP DID NOT PUT IT ON THE COMPUTER TO DIAGNOSIS THE ISSUE.THE CAR IS OUT OF WARRANTY NOW SO I TOOK IT TO AN INDEPENDENT MECHANIC HE DID DIAGNOSIS IT WITH THE COMPUTER. THE ESC MODULE IS BAD. NOW I A'M DRIVING WITH THE ESC OFF.WHEN DRIVING WITH THE ESC OFF IT DOESN''T RANDOMLY BRAKE BUT WILL SOMETIMES MAKE A HORRIBLE GRINDING SOUND AND THE BRAKES STICK WHEN THE BRAKES ARE APPLIED.THIS IS NOT GOOD EITHER.WHY REQUIRE THIS SAFETY FEATURE IN EVERY CAR IF IT WILL FAIL AND CAUSE AN ACCIDENT AND IF THE DEALERSHIP CAN NOT DIAGNOSIS IT CORRECTLY. SOME HYUNDAIS HAVE BEEN RECALLED FOR THIS PROBLEM SO I FEEL THE DEALERSHIPS SHOULD BE WELL AWARE OF THIS ISSUE.THE WORK ORDER DOES NOT MENTION BRAKES NOR DID THEY TRY TO DIAGNOSIS IT CORRECTLY. WAS THIS AN INTENTIONAL MOVE BY HYUNDAI SO THEY DO NOT HAVE TO ACKNOWLEDGE THAT THEIR ESC MODULES ARE STILL FAILING. I FEEL EXTREMELY LUCKY THAT I HAVE NOT BEEN INJURED DUE TO THIS MALFUNCTION. HYUNDAI FAILED ON THIS ISSUE. *TR

NHTSA ODI #10505962

100,195 miles · Apr 10, 2013

Vehicle Speed Control

Read full complaint

CAR BEGAN ACCELERATING AS IF CRUISE CONTROL WAS ON. I PUT MY FOOT ON THE BRAKE AND THE CAR HESITATED FOR A SECOND. MY FOOT THEN RETURNED TO THE GAS PEDAL AND AGAIN THE CAR BEGAN TO ACCELERATE AT A VERY FAST PACE. MY FOOT THEN RETURNED TO THE BRAKE AND THE SPEED CONTINUED TO INCREASE. I THEN PUT THE CAR INTO PARK AND SHUT OFF THE IGNITION. PRIOR TO TURNING OFF THE CAR THE SPEEDOMETER SHOWED SPEED OF 90 MILES PER HOUR. MY VEHICLE THEN ROLLED TO A STOP. WHEN THE TOW TRUCK DRIVER ATTEMPTED TO START THE VEHICLE THE STEERING COLUMN WAS LOCKED AND HE WAS NOT ABLE TO TURN THE KEY IN THE IGNITION. THE CAR WAS TOWED TO THE HYUNDAI DEALERSHIP. THE FOLLOWING MORNING THEY CLAIMED THEY COULD NOT FIND ANYTHING WRONG WITH THE VEHICLE AND SUGGESTED THAT THE INCIDENT WAS CAUSED BY MY FLOOR MAT. *TR

NHTSA ODI #10505887

90,000 miles · Apr 4, 2013

Electrical System

SUV WILL START BUT ESC LIGHT STAYS ON AND THEN THE SUV FAILS TO ACCELERATE. SUV MUST THEN BE RESTARTED FOR A CYCLE OF 10-15 TIMES UPON WHICH TIME THE ESC LIGHT TURNS OFF AND SUV WILL THEN ACCELERATE WHEN GOING UP A HILL. SYSTEM FAILURE HAS OCCURRED DAILY SINCE MARCH 2013. DEALERSHIP KNOWS HYUNDAI IS RECALLING 2007 SANTA FE B…

Read full complaint

NHTSA ODI #10507185

61,000 miles · Mar 29, 2013

Vehicle Speed ControlCrash

Read full complaint

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE PARKED, SHE SHIFTED INTO DRIVE WHEN THE VEHICLE SUDDENLY ACCELERATED AND CRASHED INTO A PARKING SIGN. THE CONTACT SHUT THE IGNITION OFF IN ORDER TO STOP THE VEHICLE AND AVOID CRASHING INTO OTHER VEHICLES. THE POLICE REPORTED TO THE SCENE AND FILED A REPORT. THERE WERE NO INJURIES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 61,000. *TR

NHTSA ODI #10504927

75,450 miles · Mar 26, 2013

Vehicle Speed Control

Read full complaint

WHILE ATTEMPTING TO ACCELERATE ON AN INTERSTATE TO PASS A VEHICLE, THE ACCELERATOR PEDAL BECAME STUCK AND THE VEHICLE QUICKLY SPED UP TO 80 MPH IN A MATTER OF SECONDS. THANKFULLY DUE TO RECENT ACCELERATOR ISSUES/RECALLS FOR OTHER MANUFACTURES, I WAS ABLE TO SHIFT THE VEHICLE INTO NEUTRAL. THE ENGINE WAS PEGGED AT MAX RPMS WHILE I FRANTICALLY TRIED TO GET OVER THROUGH THE LANES WITH THE CAR IN NEUTRAL. WITH THREE CHILDREN ABOARD, THIS WAS A VERY HARROWING EXPERIENCE. I WAS ULTIMATELY ABLE TO REACH DOWN, GRAB THE ACCELERATOR PEDAL, AND YANK IT BACK. AFTER DOING THIS, IT AGAIN DROVE NORMALLY. I IMMEDIATELY LOOKED AT THE PEDAL, FLOOR MAT, AND CARPET ONCE ARRIVING HOME. IT IS CLEARLY OBVIOUS THAT THE FLOOR CARPET ITSELF (NOT THE MAT, THE ACTUAL VEHICLE'S CARPETING) JUST UNDER THE PEDAL HAS HARDENED AND DEVELOPED A BULGE SUCH THAT THE PEDAL WILL GET STUCK IN IT IF DEPRESSED TO FAR. THIS WAS BROUGHT TO THE IMMEDIATE ATTENTION OF THE HYUNDAI DEALERSHIP WHO INDICATED THE WARRANTY WAS NO LONGER VALID AS THE VEHICLE WAS PAST 60K MILES (75K), AND A CALL PLACED TO HYUNDAI USA AGAIN YIELDED THE SAME RESULTS, THAT THE OWNER WOULD NEED TO PAY $1400 TO REPLACE THE FLOORING. THERE IS CLEARLY A DESIGN FLAW IN THE FLOOR CARPET AND RAISED SECTION DIRECTLY UNDER THE ACCELERATOR PEDAL THAT LEAD TO THIS UNINTENDED ACCELERATION, PUTTING MY SAFETY AT RISK, AND HYUNDAI IS WILLING TO HIDE BEHIND THE WARRANTY TO AVOID KEEPING ITS ONCE LOYAL CUSTOMER SAFE. *TR

NHTSA ODI #10504613

100,000 miles · Mar 21, 2013

Electronic Stability Control (esc)Fuel/propulsion SystemVehicle Speed Control

CRUISE CONTROL WOULD TURN ON BUT NOT ALLOW A SPEED TO BE SET. ALSO ESC OFF LIGHT REMAINED ON DASH SOLID. WE NEVER RECEIVED ANY NOTICE OF A RECALL FROM HYUNDAI. I SEE NUMEROUS OTHER HYUNDAI OWNERS WHO HAVE HAD THIS PROBLEM.ALSO THE CHECK ENGINE LIGHT HAS BEEN ON AND WON'T TURN OFF NO MATTER HOW MANY TIMES THE CAP IS TAKEN OFF THE…

Read full complaint

NHTSA ODI #10503902

Official recalls

20V061000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Feb 4, 2020

Hyundai Motor America (Hyundai) is recalling certain 2007-2010 Elantra and 2009-2011 Elantra Touring vehicles. On February 21, 2020 Hyundai expanded the recall to include 46,425 model year 2007-2008 Entourage and 2007 Santa Fe vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.

Consequence & remedy

Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the car is turned off, increasing the risk of an injury.

Remedy: Hyundai will notify owners, and dealers will install a relay in the vehicle's main junction box to prevent the risk of an ABS short-circuit while the car is turned off, free of charge. The recall began April 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 188.

13V113000 · Exterior Lighting:brake Lights:switch

Apr 1, 2013

Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.

Consequence & remedy

Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.

12V354000 · Air Bags:frontal:sensor/control MODULE-INACTIVE

Jul 25, 2012

Hyundai is recalling certain model year 2007 through 2009 Santa Fe vehicles manufactured from April 19, 2006, through July 7, 2008. The occupant classification system (OCS) may need recalibration to accurately detect small statured adults.

Consequence & remedy

Consequence: Improper classification or detection may cause the front passenger airbag not to deploy in the event of a crash, increasing the risk of injury to the front passenger.

Remedy: Hyundai will notify owners, and dealers will update the classification software free of charge. The safety recall began on September 7, 2012. Owners may contact Hyundai at 1-800-633-5151.

11V472000 · Air Bags:frontal

Sep 9, 2011

HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2007-2008 HYUNDAI VERACRUZ VEHICLES MANUFACTURED FROM DECEMBER 26, 2006, THROUGH MARCH 21, 2008, AND MODEL YEAR 2007-2008 HYUNDAI SANTA FE VEHICLES MANUFACTURED FROM APRIL 19, 2006 THROUGH MARCH 20, 2008. THE CLOCK SPRING CONTACT ASSEMBLY FOR THE DRIVER'S AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) MAY BECOME DAMAGED THROUGH USAGE OVER TIME. THE DRIVER'S AIR BAG ELECTRICAL CIRCUIT WILL EXPERIENCE A HIGH RESISTANCE CONDITION, POTENTIALLY CAUSING THE DRIVER'S AIR BAG TO NOT DEPLOY.

Consequence & remedy

Consequence: IF THE CLOCK SPRING DEVELOPS HIGH RESISTANCE, IN THE EVENT OF A CRASH, THE DRIVERS AIR BAG WILL NOT DEPLOY AND WILL NOT BE ABLE TO PROPERLY PROTECT THE DRIVER, INCREASING THE RISK OF INJURIES.

Remedy: HYUNDAI DEALERS WILL REPLACE THE VEHICLE'S DRIVER'S AIR BAG CLOCK SPRING CONTACT ASSEMBLY FREE OF CHARGE. THE SAFETY RECALL BEGAN IN NOVEMBER 2011. OWNERS MAY CONTACT HYUNDAI CUSTOMER CONNECT CENTER AT 1-800-633-5151.

09V122000 · Exterior Lighting:brake Lights:switch

Apr 15, 2009

HYUNDAI IS RECALLING 532,633 MY 2006-2007 ACCENT, ENTOURAGE, SONATA, MY 2007 AZERA, ELANTRA AND SANTA FE, MY 2005-2007 TUCSON AND MY 2007-2008 VERACRUZ VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.

Consequence & remedy

Consequence: ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.

Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.

08V272000 · Equipment:other:labels

Jun 19, 2008

HYUNDAI IS RECALLING 88,943 MY 2007-2008 HYUNDAI SANTA FE VEHICLES EQUIPPED WITH P235/60R18 TIRES. THESE VEHICLES FAIL TO COMPLY WITH THE LABELING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110 "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES." THE BLACK CERTIFICATION LABEL AFFIXED TO THE DRIVER'S SIDE CENTER PILLAR, INCORRECTLY LISTS THE GROSS AXLE WEIGHT RATINGS (GAWR).

Consequence & remedy

Consequence: OVERLOADING YOUR VEHICLE MAY ADVERSELY AFFECT HANDLING AND BRAKING AND MAY CAUSE TIRE DAMAGE, RESULTING IN TIRE FAILURE AND A CRASH WITHOUT WARNING.

Remedy: HYUNDAI WILL MAIL CORRECTED CERTIFICATION LABELS ALONG WITH THE INSTRUCTIONS TO THE AFFECTED OWNERS. THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 5, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.

06V317000 · Fuel System, Gasoline:storage

Aug 31, 2006

ON CERTAIN SPORT UTILITY VEHICLES, THE WALL THICKNESS OF THE RIGHT FORWARD BAFFLE OF THE FUEL TANK MAY BE BELOW SPECIFICATIONS.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE FUEL TANKS AND, IF NECESSARY, REPLACE THEM. ALL VEHICLES ARE EITHER STILL AT THE MANUFACTURING PLANT OR IN DEALERSHIPS. NO VEHICLES HAVE BEEN SOLD TO CONSUMERS.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP21003 · Throttle Control System Vulnerabilities

Opened Nov 12, 2021 · Closed Jun 20, 2023

Status: closed (inferred from source dates) · Vehicle Speed Control:throttle

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.

PE09003 · Stop Lamp Switch Failure

Opened Jan 14, 2009 · Closed Apr 24, 2009

Status: closed (inferred from source dates) · Electronic Stability Control; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Power Train:automatic Transmission:lever And Linkage:column Shift; Power Train:automatic Transmission:lever And Linkage:floor Shift; Power Train:manual Transmission:column Shift Assembly; Power Train:manual Transmission:floor Shift Assembly; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:pedals And Linkages; Vehicle Speed Control:cruise Control

BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.

Additional source detail variants (10)

Electronic Stability Control

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Power Train:automatic Transmission:lever And Linkage:column Shift

Power Train:automatic Transmission:lever And Linkage:floor Shift

Power Train:manual Transmission:column Shift Assembly

Power Train:manual Transmission:floor Shift Assembly

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Service Brakes, Hydraulic:pedals And Linkages

Vehicle Speed Control:cruise Control