I WAS RIDING DOWN THE ROAD AND FELT THE CAR FEEL AS IF IT WAS FLOATING. THE NEXT THING I KNOW THE CAR FEELS LIKE THE TIRE CAME OFF AND IT HAD. RUSTED COMPLETELY OFF. I HAD TWO CHILDREN IN THE CAR AND CAME VERY CLOSE TO BEING HIT IN THE REAR BECAUSE I LOST CONTROL OF THE VEHICLE. IT SEEMS AS IF IT IS THE CONTROL ARM BAR. THIS …
Read full complaint
I WAS RIDING DOWN THE ROAD AND FELT THE CAR FEEL AS IF IT WAS FLOATING. THE NEXT THING I KNOW THE CAR FEELS LIKE THE TIRE CAME OFF AND IT HAD. RUSTED COMPLETELY OFF. I HAD TWO CHILDREN IN THE CAR AND CAME VERY CLOSE TO BEING HIT IN THE REAR BECAUSE I LOST CONTROL OF THE VEHICLE. IT SEEMS AS IF IT IS THE CONTROL ARM BAR. THIS INCIDENT HAPPENED ON GALL BLVD. ZEPHYRHILLS FL.
NHTSA ODI #11398868
160,000 miles · Feb 5, 2021
Suspension
TL* THE CONTACT CALLED ON BEHALF OF A CLIENT WHO OWNS A 2002 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE HIS CLIENT WAS DRIVING AT 55 MPH, SHE EXPERIENCED WHAT SHE THOUGHT WAS A FLAT TIRE ON THE REAR OF THE VEHICLE. AS THE CLIENT BEGAN TO PULL OVER, THE ENTIRE PASSENGER'S SIDE REAR CONTROL ARM COLLAPSED WITHOUT WARNING. DUE …
Read full complaint
TL* THE CONTACT CALLED ON BEHALF OF A CLIENT WHO OWNS A 2002 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE HIS CLIENT WAS DRIVING AT 55 MPH, SHE EXPERIENCED WHAT SHE THOUGHT WAS A FLAT TIRE ON THE REAR OF THE VEHICLE. AS THE CLIENT BEGAN TO PULL OVER, THE ENTIRE PASSENGER'S SIDE REAR CONTROL ARM COLLAPSED WITHOUT WARNING. DUE TO THE FAILURE, THE CONTACT'S CLIENT HAD THE VEHICLE TOWED TO HIS INDEPENDENT MECHANIC SHOP WHERE HE DISCOVERED THAT THE ENTIRE LOWER REAR CONTROL WAS CORRODED AND HAD DETACHED FROM THE VEHICLE. THE CONTACT LINKED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 09V123000 (SUSPENSION) HOWEVER, UPON SPEAKING WITH TWIN CITY HYUNDAI (3024 ALCOA HWY, ALCOA, TN 37701) THE CONTACT WAS INFORMED THAT THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.*DT*JB
NHTSA ODI #11394833
1,900,000 miles · Nov 10, 2020
Power TrainSuspensionWheels
MY 2002 HYUNDAI SANTA FE IS SHARPLY JERKING TO THE RIGHT ITS ALMOST IMPOSSIBLE TO STOP IT SOUNDS AS IF THE CAR IF GOING TO FALL INTO PEICES IM A DISABLED MOM WITH ONE ONE THE WAY I CAN'T DRIVE FOR FEAR IM GOING TO LOSE THE WHEEL AND CRASH
NHTSA ODI #11374022
150,000 miles · Sep 25, 2020
Suspension
TL* THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. THE CONTACT STATED THAT UPON INSPECTION OF HIS REAR BRAKES, HE NOTICED EXCESSIVE CORROSION ON THE REAR TRAILING ARMS LOCATED BY THE COIL SPRINGS. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 09V123000 (SUSPENSION) WHICH HE LINKED TO THE FAILURE. THE VEHICLE WAS N…
Read full complaint
TL* THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. THE CONTACT STATED THAT UPON INSPECTION OF HIS REAR BRAKES, HE NOTICED EXCESSIVE CORROSION ON THE REAR TRAILING ARMS LOCATED BY THE COIL SPRINGS. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 09V123000 (SUSPENSION) WHICH HE LINKED TO THE FAILURE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC TO BE DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.
NHTSA ODI #11361082
Mileage unknown · Mar 8, 2020
Suspension
THIS SANTA FE HAS A REAR RIGHT TRAILING ARM THAT HAS COMPLETELY RUSTED AND HAS ALSO DISINTEGRATED THE WHEEL BEARING ASSEMBLY, WHEEL HUB, EMERGENCY BRAKE CABLE AND SPRING. I CHECKED THE WEBSITE FOR A RECALL ON THIS VEHICLE, THERE IS A RECALL FOR THE REAR TRAILING ARMS, BUT THIS VIN NUMBER WAS NOT PART OF THE RECALL. THIS VEHICLE …
Read full complaint
THIS SANTA FE HAS A REAR RIGHT TRAILING ARM THAT HAS COMPLETELY RUSTED AND HAS ALSO DISINTEGRATED THE WHEEL BEARING ASSEMBLY, WHEEL HUB, EMERGENCY BRAKE CABLE AND SPRING. I CHECKED THE WEBSITE FOR A RECALL ON THIS VEHICLE, THERE IS A RECALL FOR THE REAR TRAILING ARMS, BUT THIS VIN NUMBER WAS NOT PART OF THE RECALL. THIS VEHICLE HAS BEEN REGISTERED IN THE NORTHEAST "SALT BELT" AND SHOULD HAVE BEEN INCLUDED IN THE RECALL. BECAUSE OF THIS OVERSIGHT BY NOT INCLUDING THIS VIN ON THE RECALL IT HAS CAUSED MASSIVE CORROSION ON ALL ATTACHED PARTS. THE RIGHT REAR SIDE HAS BEEN MORE AFFECTED THAN THE REAR LEFT SIDE. I WOULD GREATLY APPRECIATE ANY ASSISTANCE YOU COULD PROVIDE ME IN PROVIDING A REMEDY FOR THIS SITUATION
NHTSA ODI #11316877
Mileage unknown · Jul 23, 2019
Suspension
FRAME RUSTED THROUGH ON AT LEAST LEFT SIDE WHERE THE CONTROL ARM IS BOLTED.. PREVIOUSLY REAR TRAILING ARM RUSTED THROUGH.
NHTSA ODI #11234120
168,000 miles · May 23, 2019
SteeringSuspensionWheels
WHEN ACCELERATING BETWEEN 30-50 MPH, THE STEERING WHEEL PULLS VIOLENTLY TO THE RIGHT. WHEN THE ACCELERATOR IS RELEASED, THE TENSION ON THE WHEEL GOES AWAY. THE FRONT TIRES WEAR FASTER THEN UNSEAL.
NHTSA ODI #11209445
200,000 miles · May 6, 2019
Suspension
BOTH LOWER CONTROL ARMS ARE RUSTING OUT DUE TO SALT ROADWAYS
NHTSA ODI #11205800
160,000 miles · Sep 27, 2018
EngineFuel/propulsion SystemSteering
TL* THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE STEERING WHEEL WAS DIFFICULT TO TURN AND THERE WAS AN ABNORMAL ODOR OF FUEL INSIDE THE VEHICLE. IN ADDITION, THE CONTACT HAD TO ADD AIR TO THE FOUR TIRES AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATE…
Read full complaint
TL* THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE STEERING WHEEL WAS DIFFICULT TO TURN AND THERE WAS AN ABNORMAL ODOR OF FUEL INSIDE THE VEHICLE. IN ADDITION, THE CONTACT HAD TO ADD AIR TO THE FOUR TIRES AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE SUSPENSION AND AXLE NEEDED TO BE REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 160,000. THE VIN WAS UNKNOWN.
NHTSA ODI #11131973
130,000 miles · Sep 4, 2018
Suspension
TL* THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. WHILE DRIVING 55 MPH, THE CONTACT FELT THAT THE REAR OF THE VEHICLE WAS OUT OF ALIGNMENT. THE CONTACT COASTED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND NOTICED THAT THE REAR PASSENGER WHEEL WAS BENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE …
Read full complaint
TL* THE CONTACT OWNS A 2002 HYUNDAI SANTA FE. WHILE DRIVING 55 MPH, THE CONTACT FELT THAT THE REAR OF THE VEHICLE WAS OUT OF ALIGNMENT. THE CONTACT COASTED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND NOTICED THAT THE REAR PASSENGER WHEEL WAS BENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR TRAILING ARMS WERE CORRODED ALL THE WAY THROUGH AND NEEDED TO BE REPLACED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 09V123000 (SUSPENSION) AND 14V435000 (SUSPENSION). THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
Hyundai Motor Company (Hyundai) is recalling certain model Year 2001-2006 Santa Fe vehicles manufactured from March 31, 2000, through February 15, 2006, that are registered and operated, or which were originally sold and registered, in the following 20 salt belt" states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. The affected vehicles may experience front coil spring corrosion from road salt, causing the coil spring to fracture and make contact with the tire.
Consequence & remedy
Consequence: If the front coil spring fractures due to corrosion it could cause the coil spring to make contact with the tire, possibly puncturing the tire and increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will inspect and if necessary replace the coil spring, free of charge. The recall began on October 24, 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 124.
HYUNDAI IS RECALLING 83,355 MY 2001-2003 SANTA FE VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE REAR TRAILING ARMS, WHICH COULD LEAD TO THINNING OR PERFORATION OF THE REAR TRAILING ARM STEEL. OWNERS MAY SEE OR FEEL SLIGHT TO MODERATE CHANGES IN VEHICLE OPERATION WHICH WILL INCREASE IF THE VEHICLE IS NOT REPAIRED. THESE CHANGES INCLUDE A LOWERING OF VEHICLE HEIGHT THAT CAN LEAD TO TIRE MISALIGNMENT AND STEERING PULL. OWNERS MAY ALSO NOTICE A CREAKING SOUND.
Consequence & remedy
Consequence: IF THE CORROSION IS ALLOWED TO PROGRESS, THE REAR TRAILING ARM MAY FRACTURE WHILE DRIVING, THEREBY INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE REAR TRAILING ARMS FOR INTERNAL CORROSION DAMAGE. IF SPECIFIED LEVELS OF CORROSION DAMAGE ARE FOUND, THE REAR TRAILING ARMS WILL BE REPLACED. REAR TRAILING ARMS THAT DO NOT REQUIRE REPLACEMENT WILL HAVE DRAINAGE HOLES ADDED AND WILL BE TREATED WITH RUST-PROOFING MATERIAL TO ARREST THE CORROSION PROCESS. INSPECTION, TREATMENT AND REPLACEMENT PROCEDURES WILL BE CONDUCTED AT NO COST TO OWNERS. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: THE TIRE PRESSURE LABELS DO NOT CONTAIN THE INFORMATION REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECT LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON OCTOBER 29, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 2.7 LITER V-6 ENGINES, IMPROPERLY MANUFACTURED CRANKSHAFT POSITION SENSORS (CPS) WERE INSTALLED. THE CPS CASES WERE IMPROPERLY MANUFACTURED AND DID NOT MEET DIMENSIONAL SPECIFICATIONS. INTERNAL GAPS WITHIN THE CASES ALLOWED EPOXY TO CONTACT THE PRINTED CIRCUIT BOARD, WHICH RESULTED IN CRACKING OF THE PRINTED CIRCUIT BOARD CAPACITOR.
Consequence & remedy
Consequence: A DAMAGED CPS CAPACITOR COULD RESULT IN ENGINE STALLING.
Remedy: DEALERS WILL REPLACE THE CPS. OWNER NOTIFICATION BEGAN ON MARCH 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-829-9956.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA08023 · Rear Trailing Arm Corrosion Failure
Opened Oct 28, 2008 · Closed Apr 17, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (2)
Suspension
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.
Suspension:rear
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.
2002 Hyundai Santa Fe Problems, Complaints & Recalls | Skip That Year
Illustration