2025 Hyundai Santa Fe Hybrid

First Incident – XXX Weekend ([XXX]) Accelerating at an on-ramp to a major highway (I-37S) in [XXX], vehicle suddenly lost power. Speed dropped from 60 mph to 45 mph, then 28 mph, in a 65 mph zone during rush hour traffic. No apparent cause: had ¾ tank of fuel, a clean maintenance history, and no prior issues. Managed to reach the shoulder and, after several minutes, able to exit the highway. Vehicle would not accelerate above 35–45 mph and stayed around 30mph, and the hybrid battery showed less than 25% charge. Notified Red McCombs Hyundai (original seller). When a loaner vehicle became available, we brought the Santa Fe in. After a week, the dealership stated they could not duplicate the problem and returned the vehicle to us. Second Incident – XXX ([XXX]) On a planned trip from [XXX] to [XXX], again experienced a sudden and severe loss of power. While merging onto I‑10W, in [XXX], the vehicle speed dropped from 80 mph to 60, then 50, then 38 mph. Able to avoid a collision because of an unusually wide median where I could safely stop. Used GPS to find a local Hyundai dealer - Casa Hyundai of [XXX] - and drove there, using surface roads only. Turned vehicle in for maintenance and continued trip using a loaner vehicle. Casa Hyundai reported, days later, that despite logged error messages indicating problem with hybrid system and advising user to immediately stop, they were unable to isolate problem. Third Incident – XXX (Unknown location in [XXX]) Entering I-10E after fuel stop (80mph zone) and accelerating hard on a slight incline, again experienced sudden loss of power, slowing to less than 40 mph. Drove on shoulder for two miles to next exit 284 and stopped w/motor running to recharge. No error codes or warnings displayed on dash. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When traveling home from work 8/27/26, my cruise control shut off and my car immediately went into “limp” mode. This almost caused me to get into an accident with a tractor trailer, in which, I may not have survived. Immediately pulled over and tried to find out what had caused this and how to get it fixed. Nothing worked to get it out of “limp” mode. There were no warning lights or messages, except LV3. Which was a completely different issue. This issue I was able to correct. Tried fixing the “limp” mode issue by doing as told by Google AI, turn car off, lock door with key fob, waiting 10-15 minutes for computer to reset. NOTHING. Also tried checking to see if there was a battery dump, in which this case would have been the fuel system not communicating with the hybrid battery system, NOTHING. I do have an appt with the dealership on 9/2/26 to have this looked at and inspected. I have not tried to start and or drive the car again, since. Do not want to be blamed by the dealership or manufacturer, that I did something wrong or caused more issues.

Gas Motor is not engaging to assist electric drivetrain on a hybrid AWD 2025 Santa Fe. This resulted in a dangerous situation crossing a busy road from a stop sign. The Santa Fe rolled into the intersection at the drivers request, but did not accelerate normally (only to a maximum of a few miles per hour) and felt like an eternity to cross the road. Fortunately oncoming drivers from left and right were paying attention and slowed down and in one case honked aggressively to point out we driving badly. Pulling over to the side of the road, turning the vehicle off and then back on again has sometimes made it run normally, but we limited our trips at that point to first getting safely home and then delivering it to the dealer. The 20 mile drive to the dealer required pulling over twice to reset the vehicle so the electric motor would assist. We have had repeated warnings from the onboard system including "Follow up checks required - Engine Management System" and "There may be a problem with the engine management system Contact your Dealer". I will note that we have 11,000 miles and 11 months experience with the vehicle with NO problems. It may not be relevant, but these new faults began 2 days routine service for oil and tire rotation when recall was performed including ECU Software Update for Recall 25-01-028-1. Dealer is uncertain of problem and referring with outside tech assistance from Hyundai but we were told to expect 2 weeks for parts and repair and uncertainty as to whether that would fix it. In the meantime a vehicle with unreliable acceleration and top speed is unsafe and parked. I do note on this NHTSA website 2025 HYUNDAI SANTA FE HYBRID SUV AWD that there are 47 Complaints. 9 relating to this problem all beginning October 2025 and none prior back to the first post of Nov 2024 for this model. Complaints similar to this for engine management and speed and power loss account for 50% of complaints for this vehicle on the NHSTA website since October 2025.

The 2025 Hyundai Santa Fe Hybrid has had multiple occasions, most recently on February 3, 2026 with 12,330 miles on the car, where the gas-powered engine fails to provide any power to the drivetrain. The car experiences vast power loss and enters "limp mode" where only the small hybrid battery is powering the vehicle. Max speed ranges from 10 - 25mph and there is little, if any, acceleration, even when the gas pedal is pegged to the floor. It is necessary to pull over, engage the flashing safety lights and try to find a safe place to park. After turning the vehicle off and on several times, eventually, the gas engines re-engages. The first incident of this type for this vehicle was on August 7, 2025 with approximately 4,400 miles on the vehicle. It was taken to the dealer, Key Hyundai of Salem, who could not find any DTCs and could not replicate the problem. They said "bring it back if it happens again." They next time was on February 3, 2026 where it happened several times on a trip to and from a local restaurant. This time, at DTC code of P088000 POWERTRAIN / POWERLOSS was recorded and reported. However, by the time the car was seen by Key Hyundai of Salem on February 5, 2026, the code has cleared itself. Hyundai's corporate policy is that historical codes can not be used for Warranty claims. So, the dealer tried one potential fix, cleaning the TCM connectors under the driver's seat, and returned the vehicle stating that Hyundai corporate would not authorize warranty work unless/until the car was presented to the dealership with a current / live DTC or visible broken parts. It seems unsafe to put a vehicle back on the road that could lose power and drivability at any time for no apparent reason. I am aware that there have been several other reports of similar POWER LOSS / LIMP MODE situations by owners of 2024-25 Hyundai Santa Fe Hybrids. At the moment, I am told that there is no current Technical Service Bulletin on this from Hyundai.

Sitting at stoplight and attempted to go. Car wouldn’t go above 10mph even with pedal all the way down. Drove for a bit trying to figure out what was wrong. Then flashing red lights and beeping telling me to pull over safely. Pulled over and turned the car off. Restarted and car said charge battery. Apparently this is called “limp mode” and happens when there is something seriously wrong with the car in order to prevent further damage. Very dangerous to not be able to go about 10mph on the highway. Took to dealership. Vehicle isn’t throwing any codes and blue link shows nothing of the incident. Dealership supposedly checked battery and connections. Nothing done

I was stopped at a red light. When the light turned green, I proceeded to apply the gas and accelerate. I quickly noticed that the vehicle began accelerating at a faster rate than I was intending. The vehicle continued to accelerate without me applying my foot to the gas pedal. Nothing would stop the continued acceleration (application of brake). I crashed into the rear of a vehicle in my lane going approximately 50-60mph (estimate). I am unsure what the issue was that resulted in this crash. In doing some internet searching, it seems it could have something to do with the transition from electric to gas when I was stopped temporarily at the intersection. It could have been a faulty sensor (throttle position) or software glitch. These components have not been inspected by the manufacturer, police, or insurance representatives. There were no warning lamps, messages or other symptoms of the problem prior to the failure. The crash resulted in the airbags being deployed, I was taken to the hospital with a likely concussion and moderate injuries to my chest and hand. The vehicle that I rear ended was a [XXX] woman with a [XXX] old in the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)