2025 Hyundai Santa Fe Hybrid

First Incident – XXX Weekend ([XXX]) Accelerating at an on-ramp to a major highway (I-37S) in [XXX], vehicle suddenly lost power. Speed dropped from 60 mph to 45 mph, then 28 mph, in a 65 mph zone during rush hour traffic. No apparent cause: had ¾ tank of fuel, a clean maintenance history, and no prior issues. Managed to reach the shoulder and, after several minutes, able to exit the highway. Vehicle would not accelerate above 35–45 mph and stayed around 30mph, and the hybrid battery showed less than 25% charge. Notified Red McCombs Hyundai (original seller). When a loaner vehicle became available, we brought the Santa Fe in. After a week, the dealership stated they could not duplicate the problem and returned the vehicle to us. Second Incident – XXX ([XXX]) On a planned trip from [XXX] to [XXX], again experienced a sudden and severe loss of power. While merging onto I‑10W, in [XXX], the vehicle speed dropped from 80 mph to 60, then 50, then 38 mph. Able to avoid a collision because of an unusually wide median where I could safely stop. Used GPS to find a local Hyundai dealer - Casa Hyundai of [XXX] - and drove there, using surface roads only. Turned vehicle in for maintenance and continued trip using a loaner vehicle. Casa Hyundai reported, days later, that despite logged error messages indicating problem with hybrid system and advising user to immediately stop, they were unable to isolate problem. Third Incident – XXX (Unknown location in [XXX]) Entering I-10E after fuel stop (80mph zone) and accelerating hard on a slight incline, again experienced sudden loss of power, slowing to less than 40 mph. Drove on shoulder for two miles to next exit 284 and stopped w/motor running to recharge. No error codes or warnings displayed on dash. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving, the vehicle suddenly lost motive power on the highway and would not accelerate beyond approximately 20 mph despite accelerator input. There were no warning lights or check-engine light. The condition created a safety hazard because the vehicle could not maintain normal traffic speed. Hyundai dealer has been unable to determine the cause on other vehicles with the same problem, and was trying to discourage me from reporting this. They also said that they'd keep the car for 3 days, and likely return it with no diagnosis, so do I really want to go through this? They seemed unconcerned that this is a very dangerous issue in a highway.

Our family was driving on the highway at 55mph (I-495 in Alexandria, VA), the car instantly began to decelerate, despite having my foot completely on the accelerator and we had to limp over to the side of the road onto the shoulder. We had to wait multiple times for the hybrid motor to re-power itself to get off an exit at 10-15 mph. The car is now in "limp mode" and will not drive above 35 mph. This is the 4th time that we have had the same issue occur. Hyundai has provided a different fix each time, but they have yet to find an answer as to why this instant loss of acceleration keeps occuring. In the wrong circumstance. This instant loss of acceleration could be deadly and cause severe injuries to the individuals in the vehicle.

On XXX, at approximately 6:30 PM, my wife was driving our 2025 Hyundai Santa Fe Hybrid on [XXX] when the vehicle suddenly lost propulsion power. It would not accelerate past approximately 55 mph. With the accelerator pedal pressed fully to the floor, the vehicle did not gain speed. I drove the vehicle myself the same day, immediately after she arrived home, to verify the problem, and I reproduced the identical condition. The vehicle accelerates normally from a stop, but at approximately 40 to 50 mph it stops accelerating and will not exceed approximately 50 to 55 mph regardless of accelerator input. No warning lamps illuminated and no messages appeared on the instrument cluster before, during, or after either event. The vehicle health check in the official Hyundai application reports the vehicle status as normal. The driver receives no indication that anything is wrong. This is a serious safety hazard. Sudden inability to accelerate in traffic creates a substantial risk of a rear-end collision and makes it dangerous to merge onto a highway, pass, or clear an intersection. Because there is no warning, the driver cannot anticipate it. The vehicle has approximately 13,741 miles and was purchased new on XXX. Scheduled maintenance was performed at the selling dealer on XXX at 7,924 miles. The vehicle has not been driven since XXX and is available for inspection on request. It is scheduled for dealer inspection on XXX. The problem has not yet been reproduced or confirmed by a dealer. I am aware of numerous owner reports of a similar loss-of-power condition in 2025 Santa Fe Hybrid vehicles in which the gasoline engine reportedly fails to engage and the vehicle operates on hybrid battery power alone. In several of those reports the trouble code cleared itself before the dealer inspected the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle has gone into a limp mode unexpectedly while driving on the highway at 60+ mph. The car immediately stopped driving and went into limp mode and cannot go over 30 mph. It was taken to a service dealer. They could not replicate the problem, therefore the vehicle was given back as undiagnosed. This next incident occurred and almost caused an accident, and that was on, again driving on the beltway around Columbus, OH. The car went from 70 mph to 30 mph. The vehicle stayed at 25 to 30 mph the entire time. Could not get it to do anything else. Drove cautiously on the side of the road and got to the dealership after driving 30 minutes at 25 mph. Dealership ended up saying the transmission needed replaced. It has been at the dealer for 3 weeks waiting on a transmission

My 2025 Hyundai Santa Fe Hybrid AWD was serviced under warranty on 4/22/2026 for a driveability concern after experiencing a loss of power while driving. The service history shows part HY35326-2M500 was replaced. On or about 5/25/2026, the same issue occurred again while driving at highway speed. The vehicle suddenly lost motive power and dropped from approximately 70 mph to approximately 30 to 40 mph, creating a serious safety risk because the vehicle could not maintain speed with surrounding highway traffic. No warning lamps, dashboard messages, or diagnostic codes appeared during the failure. The vehicle is currently at a Hyundai dealership for inspection and repair for the repeat issue and should be available for inspection upon request. The prior dealer record appears to describe the issue generally as a “driveability concern,” but the current repair diagnosis and full repair notes are still pending. It is unknown whether the dealer has reproduced or confirmed the failure during the current visit. I am reporting this as a sudden loss of motive power at highway speed involving the fuel/propulsion system, engine, and/or powertrain.

Driving home from church this morning, the vehicle experiences a sudden loss of power and the car went into “limp mode”. Even the pedal floored and the engine rpms high, the car would barely go about 25 or 30 mph. A message from the dash board told me to pull over and leave the engine running to charge the EV batteries. The batteries would charge enough for what I thought would get me home but quickly drained leaving repeat the action until I could limp the six miles home with flashers on and cars passing me to get around. No warning lights and no indication there was a problem until it happened leaving me baffled and frustrated. I was just thankful that I wasn’t going faster when it happened. If I had been going faster when this happened, it could have created a major accident. Dangerous! Since this happened on Sunday, the dealer wasn’t open. I hope to get it to the dealer tomorrow to find out what is going on and how to fix it. The car has only 14850 miles on it.

The contact owns a 2025 Hyundai Santa Fe. The contact stated that while driving approximately 65 MPH, the vehicle unexpectedly decelerated to 25 MPH with a “Vehicle Will Shut Down” warning message displayed. The contact stated that the engine then began to shut down, and although the accelerator pedal was depressed, the vehicle failed to accelerate and stalled. The failure occurred on multiple occasions, requiring the vehicle to be towed each time. The vehicle was towed to the dealer; the vehicle was not diagnosed or repaired and the contact was informed that the failure could not be duplicated. The manufacturer was made aware of the failure and multiple cases were opened, The failure mileage was approximately 3,300.

I had stopped and put gas in for a full tank. Pulled out onto the Hwy heading towards Houston TX and was accelerating up to speed limit of 50MPH when the warning on the instrument panel displayed HYBRID SYSTEMS DISABLED pull over and stop immediately. Which I did, but I could not accelerate and was losing speed in traffic. I got safely parked and turned the vehicle off. I let the car sit for a few minutes and started it back up. All warnings were gone and the vehicle has performed normally since up to the current mileage of 9374. I took the vehicle to Hyundai today, 4/13/2026 and they hooked it up to the diagnostic system and it showed NOTHING.