2025 Hyundai Santa Fe Hybrid

Since February 2026 I have had daily incidents of the hybrid system error where the vehicle is only relying on the hybrid battery to move. I've had a few near miss accidents as my car crawls through an intersection. Was almost rear-end after leaving a stop sign and the hybrid system error popped up and the car doesn't accelerate. In order to temporarily fix the system, the car must be shut off and restarted. There is not always a safe place to be pulled over to perform this shut down. It is a driving hazard and not safe to drive. It has been to the shop now a 3rd time with no resolution. I have reached out direct to Hyundai Corporation with my concerns and they have documentation. The car is a 2025 model and has less than 5,000 miles. I fear a serious accident from this system error and Hyundai needs to resolve ASAP.

I had stopped and put gas in for a full tank. Pulled out onto the Hwy heading towards Houston TX and was accelerating up to speed limit of 50MPH when the warning on the instrument panel displayed HYBRID SYSTEMS DISABLED pull over and stop immediately. Which I did, but I could not accelerate and was losing speed in traffic. I got safely parked and turned the vehicle off. I let the car sit for a few minutes and started it back up. All warnings were gone and the vehicle has performed normally since up to the current mileage of 9374. I took the vehicle to Hyundai today, 4/13/2026 and they hooked it up to the diagnostic system and it showed NOTHING.

The 2025 Hyundai Hybrid Santa Fe SEL has experienced two instances (Nov 2025, 11k miles & Apr 2026, 14k miles) where the combustion engine fails to provide power to the vehicle’s wheels. The engine continues to run, but only enough to maintain a charge to the hybrid battery system. When accelerating to speeds above 30 miles per hour or when traveling up inclines, the combustion engine’s rotations per minute (rpm) spiked, however the vehicle’s power-train still rapidly lost power and the hybrid battery drained significant charge. During one instance in November 2025, while attempting to accelerate to 55 mph up an incline, the hybrid battery drained enough that the vehicle was required to be pulled off the road to allow the battery to charge. During the April 2026 event, while containing a family of four (including to young children under six years of age), the vehicle failed to accelerate to 60 mph up an incline on an interstate freeway bridge. The vehicle rapidly slowed to between 20 and 30 mph, putting the family in grave danger from high-speed collisions. Following both instances, the on-board diagnostics computer was reset, “resolving the issue” and the Hyundai technicians elected to make no further repairs or replacements. The onboard diagnostics code P0191 was reported following the April 2026 event, however no codes or errors were identified by the Hyundai technician following the November 2025 event. No additional follow-up was performed, even though the vehicle remained under the manufacturer’s warranty.

Vehicle experienced a loss of acceleration while driving. When pressing the accelerator, engine RPM increased significantly but the vehicle did not increase speed. The vehicle felt as though it was stuck in one gear and would not upshift or downshift. The issue was most noticeable while driving uphill, where the vehicle was unable to maintain speed despite full throttle input. This created a safety concern as the vehicle could not accelerate normally in traffic conditions. The problem has been progressively worsening over time. Initially there were mild symptoms, but it has become more severe and frequent, culminating in a near-complete inability to accelerate under load. No warning lights or messages were observed prior to or during the failure (if that’s true—adjust if needed). Vehicle has approximately 28,000 miles. The vehicle is currently at a dealership for inspection and diagnosis, but the issue has not yet been confirmed or resolved at the time of this report.

Vehicle went in to limp mode in the middle of driving. Would not accelerate past 30mph. Was able to turn around and pull in to a neighborhood when the vehicle stopped responding altogether and had an additional warning about letting the engine recharge the hybrid system. Restarting the car got it home. This would have been extremely dangerous had it happened on the highway, at highway speeds. Dealership replaced the high pressure fuel pump. Got it back yesterday, we will see if that fixes it.

The 2025 Hyundai Santa Fe Hybrid has had multiple occasions, most recently on February 3, 2026 with 12,330 miles on the car, where the gas-powered engine fails to provide any power to the drivetrain. The car experiences vast power loss and enters "limp mode" where only the small hybrid battery is powering the vehicle. Max speed ranges from 10 - 25mph and there is little, if any, acceleration, even when the gas pedal is pegged to the floor. It is necessary to pull over, engage the flashing safety lights and try to find a safe place to park. After turning the vehicle off and on several times, eventually, the gas engines re-engages. The first incident of this type for this vehicle was on August 7, 2025 with approximately 4,400 miles on the vehicle. It was taken to the dealer, Key Hyundai of Salem, who could not find any DTCs and could not replicate the problem. They said "bring it back if it happens again." They next time was on February 3, 2026 where it happened several times on a trip to and from a local restaurant. This time, at DTC code of P088000 POWERTRAIN / POWERLOSS was recorded and reported. However, by the time the car was seen by Key Hyundai of Salem on February 5, 2026, the code has cleared itself. Hyundai's corporate policy is that historical codes can not be used for Warranty claims. So, the dealer tried one potential fix, cleaning the TCM connectors under the driver's seat, and returned the vehicle stating that Hyundai corporate would not authorize warranty work unless/until the car was presented to the dealership with a current / live DTC or visible broken parts. It seems unsafe to put a vehicle back on the road that could lose power and drivability at any time for no apparent reason. I am aware that there have been several other reports of similar POWER LOSS / LIMP MODE situations by owners of 2024-25 Hyundai Santa Fe Hybrids. At the moment, I am told that there is no current Technical Service Bulletin on this from Hyundai.

While driving at highway speeds (59–75 mph), the vehicle suddenly lost propulsion power and entered a reduced-speed “limp mode,” rapidly decelerating and creating a dangerous traffic situation. The dashboard displayed a “Hybrid Power Control Unit” warning along with audible alarms. During the second incident, the vehicle failed to shut off when the engine stop button was pressed. Multiple adult witnesses were in the vehicle on each dangerous traffic situation.

Supplemental Update – Ongoing Safety Concerns and Extended Loss of Use Since submitting my initial complaint, my leased Hyundai vehicle (VIN [XXX] ) has now been presented for service for the third time for the same unresolved safety-related issues. The vehicle has been held by the dealership for eight (8) consecutive days during this service visit with no resolution and no clear timeline for return. Safety concerns remain unresolved, including: Persistent toxic/chemical odor inside the cabin Random rear hatch opening while vehicle is parked and locked Repeated false “windows open” alerts Electrical/body control system irregularities To date, I have not been provided with documentation confirming that cabin air quality testing, exhaust intrusion testing, or comprehensive electrical diagnostics have been performed. These unresolved conditions present ongoing safety risks and loss of use. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SantaFe Hybrid Calligraphy 2025 with about 9000 miles purchased new from Hyundai dealer. Several times and unpredictably, the vehicle loses power while driving mostly on highway 60-70 mph. operator can push the gas pedal to the floor and the car does not accelerate more than about 25 mph. My wife was on an off ramp with no shoulder to pull off. Very dangerous situation. A message on the dash states to "park and let battery charge". The battery is suppose to charge itself while the gasoline engine is operating.A search engine query reveals many folks are experiencing this same situation.