2024 Hyundai Santa Fe Hybrid

While driving on the highway the vehicle lost power and then lowered the transmission gear and would not accelerate over 17mph regardless of pressure on accelerator. I switched from auto hybrid mode over to sport mode so the gasoline engine could be used yet the transmission would not increase power to the tires. I stopped several times and restarted with no corrections. Vehicle battery drained quickly and vehicle alarm told me to pull over to charge battery. Sat for a few minutes to charge battery, put in drive and vehicle went forward to 17-20 mph and would not go any faster. Pedal was to the floor. The vehicle then gave several alarm lights and system failures. I limped the car home and called roadside assistance. Tried to put car in reverse for an easy tow and the car wouldn't move in reverse.

While driving on the highway, my 2024 Santa Fe Hybrid suddenly and without warning lost propulsion power. The loss of power was immediately accompanied by multiple simultaneous warning lights across the instrument cluster, glitching and abnormal behavior of the cluster display, and then a complete electrical shutdown of the vehicle. After the shutdown, the vehicle would not restart. The failure occurred in connection with a software update on the vehicle. At the time of the incident the vehicle had approximately 12,828 miles on it. Losing motive power while traveling at highway speed created a serious crash risk, as the vehicle was unable to maintain or recover speed in moving traffic. No crash, injury, or fire resulted. The vehicle was towed to an authorized Hyundai dealer for diagnosis. I have photographs of the instrument cluster taken at the time of failure showing numerous warning indicators illuminated at once. The symptoms I experienced — progressive or sudden loss of drive power, 12-volt/charging-related faults, and failure to restart — appear consistent with charging-control and DC-to-DC converter failures that have been the subject of prior recalls and complaints on Hyundai electrified vehicles. I am filing this report to document the incident as a safety concern.

Original letter to Hyundai below. The car is currently at a dealer again for repair of the same issue. Fuel pump replaced in Nov 2025 but issue has returned in March 2026. Videos of the issue recently occurring are available. Good morning, We had our 2024 Santa Fe Hybrid lose power while merging onto the freeway in November 2025. I was pressing the accelerator and it did not do anything, just kept rapidly decelerating. Pulled the car to the shoulder and turned it off completely and back on, and the car started up with the engine running which was unusual- typically the car starts up in silent electric mode. It would not accelerate past a few miles per hour. This has now happened on multiple occasions, disappearing for a few days only to return. It has gotten very dangerous to lose speed and acceleration into a busy freeway and almost caused an accident yesterday. We were thankfully close to a dealer (Glassman Hyundai in Southfield, MI) and were able to limp it a mile down the shoulder at low speed to drop it off. However, they are telling us they have no loaners available to provide us which seems unacceptable with a car under warranty with 18k miles on it. Is there anything you’re able to do to assist? Are there any known fixes for the issue that can be reported to the dealer? Thanks, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When accelerating from a stop, the transmission fails to engage causing the engine to rev but not allow for movement until the gas pedal is disengaged then engaged again. This happens sporadically and I have not been able to find a pattern or reason for this issue. I have reported this to Hyundai and taken the vehicle in but the dealership was unable to reproduce the issue after driving the vehicle for 20 miles. This is a safety issue as the vehicle does not always accelerate as expected from a stop and could potentially cause an accident.

Brand new vehicle purchased through Clement Hyundai. Within a couple hundred miles, multiple times vehicle goes into neutral on its own while driving. Have to stop the vehicle and turn off engine to try to get it into drive to get off the road. Takes several attempts to get into drive. Major safety hazard! Repaired once by Jefferson City Hyundai. Same problem happening again. Car not drivable as it is a safety concern. Have found multiple online forums wherein people are having the exact same problem.