2023 Hyundai Santa Fe Hybrid

Own a 2023 Hyundai Santa Fe Hybrid and have experienced the following issues over the past year and a half. Beginning after maybe 40,000 miles we pulled out onto a roadway and the engine immediately lost power and started flashing a glaring red warning that the hybrid system was failing and to pull over. We luckily were able to and turned the car off and waited. I tried to turn it on and it came back to life as if there was never an issue? We drove off. it left no warning code or did not update my Bluelink App. I took it to the dealership and they could not find any issues. Fast forward another 5 or 6 months and it happens again. Take it to the dealer and they keep it a week to go over it but still nothing. Within a week of getting it back it happens again and this time I am videoing it happening to me. Back to the dealer and provide the video because again the car did not log the event nor did it update my app. They hold it again for a week and try different things. They still cannot figure it out and I get it back.... it happens again.... This time the dealership was able to come up with an answer and that the oil level was too high. I got the car back and it seemed to work. Probably now 6 months go by and then this week I drive over to Jacksonville (5 hr drive) and visit. Again the car scares us on the highway and I have to pull over. Havea friend meet us with tools and we jack up the car and let out enough engine oil to insure we can read between the two marks on the dipstick. We drive off but the engine keeps hestitating and we almost make it back before it completly shuts down. We tow it to the Dealer in Jacksonville. They call the next morning like they can't find anything wrong! I explain everything and remind I don't tow cars for fun - something is wrong with the car and it is leaving us vulnerable and worst is it is not leaving any codes. Not sure but I have lost faith in Hyundai

One two separate occasions while driving the car has lost the ability to accelerate. There is no acceleration power even when completely flooring the gas pedal. The dash displays a red circle warming that states "Check Hybrid system. Stop Safely". I have had to coast to the side of the road and then the car shuts off. It has taken several minutes before it can start again, and then displays a warning "Park with engine On to charge battery" before being able to shift the car into drive. I immediately took the vehicle to the dealership at which I had purchased the car. They have run a diagnostic on it and did not find any error codes stored in the computer. I picked up the vehicle from them and immediately upon pulling out of their lot it happened again. After losing power, coasting to the side of the road, and waiting for the engine to be able to restart I took it immediately back to the dealership. They have had my car for 5 weeks and cannot diagnose the problem or offer any recommendations for repairs.

I am reporting a serious and recurring safety defect with my 2023 Hyundai Santa Fe Hybrid, purchased new in January 2024. The vehicle has suffered from over 30–40 sudden hybrid system failures, including loss of acceleration, “Stop Vehicle” warnings, and check engine lights. These incidents happen without warning, including while driving at legal speeds (40–70 mph), on residential streets and highways. Most recently, the car failed twice in two days, while my teenage son was driving within all road laws, including once with a friend in the car. The vehicle simply stopped accelerating in the middle of traffic, endangering them and everyone around them. These failures have happened at legal speeds ranging from 40–70 mph, on both residential roads and highways. There is no advance warning, just abrupt loss of power and sudden warning messages. We’ve taken the vehicle to the South Charlotte Hyundai dealership multiple times. Each time, they either reset the check engine light or replaced indicators: but never addressed the root hybrid system failure. We filed a lemon law case, and Hyundai responded with only a $2,000 offer including legal fees, requiring us to keep the dangerous vehicle. We rejected the offer. These failures have occurred with children and passengers in the car. We have documented as many incidents as we could, including photos, service records, and communication with Hyundai. The vehicle is available for inspection upon request. I no longer feel safe driving or allowing my family to drive this car. This is a critical hybrid system failure that continues to place lives at risk. I believe this may be part of a wider pattern affecting Hyundai hybrid vehicles, and I am pleading with the NHTSA to open an investigation before someone is seriously injured or worse.

I purchased a 2023 Hyundai Santa Fe Hybrid in November of 2023. Within a couple of months of purchase I had 2 incidents where without warning the car lost power and made a noise sounding like some sort of fan. One of the incidents was on [XXX] in Massachusetts, the heavy traffic cleared, I was in the fast lane, and the car would barely move. It was a safety issue as there was no place to go on the left side of the highway and traffic to my right had already picked up speed. After a minute or so the power again became available. This has happened to me several times but Hyundai has told me there is NO RECORD of this happening with my car model. On occasion I have my grandkids in the car and I am very concerned that Hyundai will not acknowledge this problem. By the way, it happened again this morning as I was pulling away from a Starbucks drive-up window. Can something be done about this? Hyundai should have records of my complaints as I visited the dealership where I bought the care and conversed via email with one of their service representatives that I do have a record of. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Twice, the car refused to switch from EV mode back to gas mode. This resulted in the hybrid battery dying and the car losing power. The first time, I was merging onto the freeway and the gas pedal was all the way at the floor, but I was only maintaining speed (not accelerating). Both times, the car was driveable for approximately one mile on the hybrid battery alone. However, a warning came on the dash, “Check hybrid system. Stop safely.” The second time, I was able to pull into a parking lot before the hybrid battery died. The next day, I was able to drive the car normally. The dealership is unable to pull any codes or replicate the issue. Unfortunately, it only happens intermittently and we have not identified a common theme for the failure.

I am afraid of getting myself or someone else killed because there is a 1-2 second lag after stepping on the gas pedal after coming to a stop. This is extremely dangerous. My street empties onto a county road with a blind curve. I have had several instances when the delay between the car moving after I’ve stepped on the gas has lead to oncoming cars needing to slam on their brakes to avoid hitting me. I even called the county and asked that they put up a “dangerous curve sign. They put up a squiggly arrow instead which has not helped. My previous gas vehicles made this turn safely for 20 years. My nephew told me it’s a new feature in cars called “stop and gol meant to save gas. I think saving my life is more important than saving a little bit of gas. It happens all the time so I will put todays date in the space below.

The engine/ability to accelerate seemed to fail. It would not accelerate past 45mph and then couldn't even maintain that speed, even with the pedal to the floor. The engine sounded like it was revving at high RPMs and wasn't shifting into gear, even though it had just been in drive and operating normally. Yes, it is available for inspection. My safety was put at risk by not being able to accelerate when merging onto the highway, leading me to be going much slower than the traffic around me. I have not asked the dealer to reproduce the problem. The component has not been inspected. There were no warning signs, messages, or alerts of any kind. There was no information about the status of the car whatsoever.

Check engine light and HEV warning light come on and vehicle looses all power. It has been confirmed by myrtle beach Hyundai also they tried fixing the problem gave me back car supposedly fixed just to have same problem within 24 hours.The problem started later part of April and is still ongoing vehicle has been towed 3 times so far.My concern is what happens if I loose all power while driving.