2023 Hyundai Santa Cruz

Hyundai Santa Cruz with transmission problems. 5 attempts to repair and manufacture failed to. Last time, vehicle had a sudden transmission failure while driving. Car stop responding to acceleration and transmission was not switching gears, that could had cause loss of control, especially in high-speed or high-traffic situations. Luckily it was very early in the morning, not much traffic and before (0.3 miles) from taking a high-speed interstate. Vehicle is not safe to drive and according to a research I made, other vehicles of same brand, model and year are facing same issues.

The contact owns a 2023 Hyundai Santa Cruz. The contact stated that while hauling a trailer and attempting to accelerate at various speeds, the vehicle was bouncing, and the tires was losing traction before being able to accelerate. The contact stated that the vehicle failed to raise and lower as the shock absorbers needed to perform. The vehicle was taken to the dealer to be diagnosed, and it was determined that the rear shocks had failed to allow the vehicle to self-level. The rear shocks were replaced; however, the failure persisted. The contact reported the persistence of the failure and was advised to go to another dealer, Greg Hubler Hyundai (6200 W Hometown Blvd, Muncie, IN 47304) who also replaced the rear struts. The manufacturer was informed of the failure and opened a case. The failure mileage was approximately 7,000.

The contact owned a 2023 Hyundai Santa Cruz. The contact stated that while exiting the vehicle to go into a store, he looked back and noticed the vehicle was on fire. No warning lights illuminated. The contact mentioned he noticed the fire was coming from the rear driver's side quarter panel. The contact called 911. No injuries were sustained. No medical attention was required. A police report was not filed. The fire department extinguished the fire. The vehicle was taken to a savage yard, and the insurance will then have the vehicle towed to a body shop. The vehicle was not repaired. The manufacturer was notified of the failure, and they informed the contact that they would inspect the vehicle, and they also offered to buy back the vehicle. Recently, he got an email informing him that they are not going to buy back the vehicle. The failure mileage was 18,000.

On [XXX], I went out to start my 2023 Hyundai Santa Cruz (SC) to leave work to go home. It was difficult to start, however, it started. As I entered [XXX] , i was nearly rear ended by another car, because my SC lost all acceleration. I turned on my hazards for SAFETY and then began to try to accelerate again and was only able to get up to 45 MPH and then was turning 4,000 RPM. I limped my SC home where I had it towed to a local Hyundai dealer as it has roughly 38,000 miles. The dealership had it for 3 days, but couldn't duplicate the issue, so no repairs were done. The Hyundai Santa Cruz has KNOWN transmission issues and the fact I was nearly rear ended could've caused a nasty wreck, resulting in more damage or even a fatality. I reported the issue to Hyundai customer service on the 11th of September (Case #[XXX]). However, in the response from Hyundai, basically saying they "experiencing a high e-mail volume" and responses may be delayed. As of 9/13/2025, I have not received a call or email from Hyundai's customer service. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

car flashes transmission low fluid and gives a code of p193b-79. when trans downshifts upshifts will not happened. to clear the problem you have to turn car off and on , and then normal operation resumes, but shifting is now slower. and sluggish. this is the second transmission to have this problem. Seem hyundai has not fixed it from the 2022 recall.

1- Air bag light randomly comes on and off. 2- Today (5.20.25) I brought it to dealer. Dealer said they disconnected the sensor switch and cleaned it, then reconnected and light went off (covered under warranty). 3- I got in the truck, started it, and light was off. 4- I drove one block and airbag light came on again. 5- Returned to dealer, who asked me to leave the car with them. 6- Dealer called and said they will replace air bag (did not specify which one). I hope this solves the problem. 7- I checked a Santa Cruz forum: [XXX] and it looks like A LOT of people have the same problem. Some report it's the sensor assembly underneath the seat. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The system that failed was electrical near or in the Tow Hitch which caused the vehicle fire. Vehicle is available for inspection at Auto Body Evolution Essex MD. The car caught fire in the back of the vehicle while parked in Owner's driveway and engine off. Neighbor pounded on Owner's door at 6:50 am. yelling for the residents to open the door that their vehicle was on fire in their driveway. Fire was dangerously close to the gas cap; parked vehicle was close to the owner's house, two boats in the driveway, and neighbor's house. After the incident, owner googled for any issues with Santa Cruz's. It was then and only then we learned that this vehicle had a fire recall on the Tow Hitch. We NEVER received a recall notice. In fact, we had this vehicle at the dealership approximately 6 weeks ago for another recall issue, thermostat, and the dealership NEVER checked for any additional recalls. Police and Fire Department were called to the scene by using 911. Officer Irwin who arrived on scene, Badge #6560, Police Report #[XXX], had to use his bully stick to bust the window to use a fire extinguisher before the fire department arrived. The car would not unlock and the windows would not operate. If we had been in the vehicle when the fire erupted or any other passengers in the vehicle, we would not have been able to get out of the car due to the electrical fire effecting the operation of the window and doors if the doors were locked. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The emergency brake system comes on while driving 60 - 70 miles an hour on freeway. It has happened twice. It does not happen every time I drive 60 - 70. The light comes on stating Emergency Braking and my vehicle slows down. It does not last for very long then goes away. I took it to the dealership and it did not do it for them. They kept it 3 days.