Illustration2023 Hyundai Palisade Calligraphy less than 3 years old has a leaking factory radiator. Hyundai has TSBs for this on earlier models, but it is still happening.
2023 Hyundai Palisade
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2023 Hyundai Palisade do not stand out strongly from the model-year median of 385.
About this comparison →How this year compares
Owner complaints by model year
Compare all Palisade years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 398 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility/wiper. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports0 fire reports2 injury reports
Power Train complaints
38 reportsI was driving and stopped at the tunnel for traffic. My car shut off and wouldn’t turn back on. It seemed to have overheated. After about ten minutes, it started again. I was told it was told the oil pump controller affecting the stop and go on my car. Priority Hyundaii in [XXX] didn’t didn’t have the part to repair it. Now the…
Read full complaint
I was driving and stopped at the tunnel for traffic. My car shut off and wouldn’t turn back on. It seemed to have overheated. After about ten minutes, it started again. I was told it was told the oil pump controller affecting the stop and go on my car. Priority Hyundaii in [XXX] didn’t didn’t have the part to repair it. Now they are refusing to repair it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I have had 4 appointments for my 2023 Hyundai Palisade to have the recall on the seat belt buckles addressed. Each time, I am told by the dealership that Hyundai hasn't sent the part yet. I was told that Hyundai is only sending 10-15 parts at a time. There are a lot of these vehicles on the road, and at this rate, my car is n…
Read full complaint
I have had 4 appointments for my 2023 Hyundai Palisade to have the recall on the seat belt buckles addressed. Each time, I am told by the dealership that Hyundai hasn't sent the part yet. I was told that Hyundai is only sending 10-15 parts at a time. There are a lot of these vehicles on the road, and at this rate, my car is never going to be fixed. There is also an open warranty for the 3rd row ejection mitigation that there is no fix for yet. I was told not to use the third row, which is not really possible and is part of why I bought a car with 3 rows of seats. I feel uncomfortable driving my car as well as having passengers in the first and second row, as I feel the seat belt might not hold if there was an accident. My safety and the safety of my passengers is potentially being compromised. I feel that we received the seat belt recall 9 months ago and that is plenty of time to address this problem. I am requesting for the NTSB to get involved and require Hyundai to provide a loaner car (of the exact same size and capacity) until my Palisade can be reapired. I was also told at an additional appointment that the rear shocks that leak are also waiting for Hyundai to ship new ones. So, I am currently driving a car that might not have proper working seat belts for the first 2 rows, can potentially eject anyone riding in the 3rd row with leaking shocks.
Two simultaenous problems happened: 1) loud clunking/thudding during low-speed turn. 2) Clunking/knocking/rattling noise from suspensions when going through uneven grounds. This both things happened before 20,000 miles. Had AWD coupling and rear differential unit replaced under warranty regarding problem 1). Had rear shocks rep…
Read full complaint
Two simultaenous problems happened: 1) loud clunking/thudding during low-speed turn. 2) Clunking/knocking/rattling noise from suspensions when going through uneven grounds. This both things happened before 20,000 miles. Had AWD coupling and rear differential unit replaced under warranty regarding problem 1). Had rear shocks replaced under warranty regarding problem 2). Found there has bben TSB issued related to 2), for older models, TSB 25-SS-004H but not for this year of models. Those two exact problems started again at about 40,000 miles. Had vehicle checked at 50,500 miles recently. Regarding problem 1), the dearship found issue with AWD coupling, stating faulty parts, drive shaft seal was 1/8" off and materials are fused. Replaced AWE coupling, and ECU program update. After program update, I do not see the power distribution monitor anymore from my dash. The program update should turned it off for some reason that I do not know. I have no clue that AWD module is working normal as I cannot see the power distribution action anymore. Regarding problem 2), they replaced both rear shocks again. The problem went away for now. This vehicle has been only 50,000 miles and had 4 major issues (2 times of two major identical issues) that alongside with many owners' compaints, and seems highly related to one of Technical Service Bulletin that was previously issued for older models. I would like to request investigation on these services.
Our Hyundai has a powertrain problem that is intermittent and random, and manifests itself in a couple of ways: 1) It drops out of gear while you are driving; there is no forward propulsion at all; the engine will rev when you press the gas, but no forward movement at all. You have to coast to a stop (or panic stop if the traffi…
Read full complaint
Our Hyundai has a powertrain problem that is intermittent and random, and manifests itself in a couple of ways: 1) It drops out of gear while you are driving; there is no forward propulsion at all; the engine will rev when you press the gas, but no forward movement at all. You have to coast to a stop (or panic stop if the traffic allows), put it in reverse, drive backwards, then the transmission will “chunk” back into gear, then you can put it back in drive and continue forward again. This is life-threatening on a busy road or highway. Traffic has to flow around you like water around a rock in a stream while you try to use what’s left of your forward momentum to pull to the side of the road. Absolutely terrifying!!! The dash has also gone completely blank during some of these episodes. Nothing changes the situation: pressing “D”, shifting the paddles, nothing gets the vehicle back in gear. We have video taped these events twice, and provided those videos to our Hyundai Service Center, and to the Hyundai National Consumer Affairs team. They claim that they can’t reproduce it on demand, so they have done NOTHING. We are scared to drive the car. 2) As you start accelerating from a stop, the powertrain will miss the next gear. The engine revs, but you are not in gear, then it will catch a gear and continue to accelerate. These events happen often, but seemingly randomly. After several episodes last year, and no Service Center resolution, we reached out to the Hyundai National Consumer Affairs team, and have continued to be in contact with them, but they have not helped in any way to resolve this. They have assigned numerous Case numbers and Reps, and have emailed me over 20 times instructing me that I should go AGAIN to the Service Center, and then that they have no updates. We are terrified to drive this vehicle, and it is the only one we have. With these issues, we are in danger every time we leave home for our Dr. appointments and necessary trips.
The steering wheel clunks and locks when turning at low speeds or when ISG turns the car back on. At times, it is a hard enough jerk to pull it out of my hands. It was taken to the dealership multiple times. The coupler was replaced, but it still jerked the steering wheel. The dealership in Utah could not replicate the sound, ev…
Read full complaint
The steering wheel clunks and locks when turning at low speeds or when ISG turns the car back on. At times, it is a hard enough jerk to pull it out of my hands. It was taken to the dealership multiple times. The coupler was replaced, but it still jerked the steering wheel. The dealership in Utah could not replicate the sound, even though it occurs multiple times a day at this point. Loss of the ability to steer after sitting at a light poses a huge safety issue between not being able to immediately navigate upon accelerating or when turning left at an intersection.
2023 HYUNDAI PALISADE VIN [XXX] Vehicle rear shock absorbers failed. Steering and drivability adversely impacted. Many many many complaints online document these defective parts and Hyundai's failure to resolve problems and supply properly functioning parts. Hyundai customer service is useless and claims no information on rep…
Read full complaint
2023 HYUNDAI PALISADE VIN [XXX] Vehicle rear shock absorbers failed. Steering and drivability adversely impacted. Many many many complaints online document these defective parts and Hyundai's failure to resolve problems and supply properly functioning parts. Hyundai customer service is useless and claims no information on replacement part availability or time. Now that Hyundai has their newest problem of killing babies in their defective third row seats, I would have thought Hyundai would resolve outstanding issues. NHTSA needs to intervene now. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I am reporting a recurring, life-threatening electronic failure in my 2023 Hyundai Palisade. On [XXX], while turning into an intersection, the vehicle's brakes spontaneously engaged, stalling the car in the path of oncoming traffic. During this event, multiple critical safety systems failed simultaneously, including the headligh…
Read full complaint
I am reporting a recurring, life-threatening electronic failure in my 2023 Hyundai Palisade. On [XXX], while turning into an intersection, the vehicle's brakes spontaneously engaged, stalling the car in the path of oncoming traffic. During this event, multiple critical safety systems failed simultaneously, including the headlights and horn, leaving me unable to warn other drivers. A "violent" surge was required to clear the intersection, risking a high-speed collision. Similar spontaneous recurrences occurred on [XXX] and [XXX], and most recently on [XXX]. These incidents are characterized by "phantom braking," total loss of propulsion, and a complete lack of interior/exterior electronic response. Technical Evidence: Diagnostic scans revealed 16 distinct fault codes (including C161608, C181287, and U012687) involving the Chassis Control Module, Electronic Control Unit (ECU), and communication buses. Despite these logged codes, Hyundai and the dealership have repeatedly returned the vehicle to me, stating they "cannot replicate" the issue, thereby dismissing a documented electronic record of failure. Arbitration Status: I entered into BBB Auto Line Arbitration (Case #[XXX]). Hyundai has contested the claim by attempting to manipulate the "start date" of the defect to February 2024 to avoid Lemon Law statutes, despite dealer records confirming the first occurrence in August 2023. As of January 13, 2026, the dealership is again attempting to force me to take delivery of the unrepaired vehicle. This vehicle is a "phantom" safety hazard. The manufacturer’s inability to replicate a logged electronic fault during a brief test drive does not mitigate the extreme risk of sudden braking and power loss at highway speeds. I am requesting a formal investigation into these specific fault codes and the electronic integrity of this model. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
In compliance with the safety recall issued for my vehicle regarding the defective seat belts, I brought my vehicle in to Vision Hyundai, Canandaigua, NY for the recall work to be completed. Upon the service department's investigation of the seat belt components, they discovered further issues with it, beyond what was initially…
Read full complaint
In compliance with the safety recall issued for my vehicle regarding the defective seat belts, I brought my vehicle in to Vision Hyundai, Canandaigua, NY for the recall work to be completed. Upon the service department's investigation of the seat belt components, they discovered further issues with it, beyond what was initially identified under the recall. Service department advises that it will take minimum of 1 month to obtain parts and make repairs. Service department issued a compact SUV which is not capable of safely installing my child car seat, or carrying the number of passengers which my affected vehicle does, putting a strain on our family's routine needs. Additionally, the affected vehicle was brought into the shop to address a powertrain issue where the vehicle loses all power and will not accelerate over 20mph, posing a serious safety concern. Hyundai has not provided any update on this or how it will be handled.
The vehicle was brought to the dealership at around 17,000 miles with concerns regarding a clunky sound and hesitation in acceleration. The issue is extremely noticeable while turning and accelerating. No warning lights, messages or audible chimes show up when the issue occurs. Due to the vehicle hesitation on acceleration an…
Read full complaint
The vehicle was brought to the dealership at around 17,000 miles with concerns regarding a clunky sound and hesitation in acceleration. The issue is extremely noticeable while turning and accelerating. No warning lights, messages or audible chimes show up when the issue occurs. Due to the vehicle hesitation on acceleration and the clunky / bouncy feeling in the steering wheel, my wife and I think there is a safety concern (e.g. being hit due to unresponsiveness of the vehicle). The problem was reproduced/confirmed by a dealer, and the rear coupling assembly was replaced. Fast forward 18,000 miles (vehicle now has ~35,000 miles) and the exact same issue is occurring again. I am schedule to take the vehicle back into the dealership for this concern, another concern with the ABS system and general maintenance.
Official recalls
526V034000 · Air Bags:side/window:curtain
Jan 22, 2026
Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The side curtain air bags for third-row occupants may deploy improperly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & remedy
Consequence: Improper side curtain air bag deployment increases the risk of injury during a crash.
Remedy: Dealers will install a protective film over the rear window and remove padding, as necessary free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning March 13, 2026. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 292. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 24, 2026.
25V607000 · Seat Belts: Rear/other:buckle Assembly; Seat Belts:front:buckle Assembly
Sep 11, 2025
Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The seat belt buckles in the driver, passenger, and second-row window seats may fail to latch.
Consequence & remedy
Consequence: Seat belt buckles that fail to latch may not properly restrain occupants in a crash, increasing the risk of injury.
Remedy: Passengers are advised to insert the belt firmly into the buckle with a quick and direct motion, pulling on the belt to confirm the seat belt is fully secured, until the recall remedy is performed. Dealers will replace the seat belt buckle assemblies, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning October 23, 2025. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 283. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 13, 2025.
Additional source detail variants (2)
Seat Belts: Rear/other:buckle Assembly
Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The seat belt buckles in the driver, passenger, and second-row window seats may fail to latch.
Consequence: Seat belt buckles that fail to latch may not properly restrain occupants in a crash, increasing the risk of injury.
Remedy: Passengers are advised to insert the belt firmly into the buckle with a quick and direct motion, pulling on the belt to confirm the seat belt is fully secured, until the recall remedy is performed. Dealers will replace the seat belt buckle assemblies, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning October 23, 2025. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 283. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 13, 2025.
Seat Belts:front:buckle Assembly
Hyundai Motor America (Hyundai) is recalling certain 2020-2025 Palisade vehicles. The seat belt buckles in the driver, passenger, and second-row window seats may fail to latch.
Consequence: Seat belt buckles that fail to latch may not properly restrain occupants in a crash, increasing the risk of injury.
Remedy: Passengers are advised to insert the belt firmly into the buckle with a quick and direct motion, pulling on the belt to confirm the seat belt is fully secured, until the recall remedy is performed. Dealers will replace the seat belt buckle assemblies, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning October 23, 2025. Final remedy owner letters will be mailed in phases, beginning in June 2026 and expected to continue through December 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 283. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 13, 2025.
23V526000 · Power Train:automatic Transmission:fluid/lubricant:pump
Jul 27, 2023
Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Palisade Tucson, 2023 Sonata, Elantra, and Kona vehicles. The electronic controller for the Idle Stop & Go oil pump assembly may contain damaged electrical components that can cause the pump controller to overheat.
Consequence & remedy
Consequence: An electric oil pump assembly that overheats increases the risk of a vehicle fire.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect and replace the electric oil pump controller, as necessary, free of charge. Owner notification letters were mailed starting September 7, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 246.
23V415000 · Service Brakes, Hydraulic:power Assist
Jun 8, 2023
Hyundai Motor America (Hyundai) is recalling certain 2023 Palisade vehicles. The brake booster diaphragm may become misaligned and cause an internal vacuum leak, which can result in a loss of power brake assist.
Consequence & remedy
Consequence: A loss of power brake assist can extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the brake booster as necessary, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 245.
23V180000 · Visibility/wiper
Mar 17, 2023
Hyundai Motor America (Hyundai) is recalling certain 2021-2023 Palisade vehicles. The windshield wiper motor may operate intermittently or fail to operate due to snow or ice buildup on the windshield, causing the wipers to fail.
Consequence & remedy
Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will replace the driver-side windshield wiper arm, free of charge. Owner notification letters were mailed May 15, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 243. This recall is an expansion of recall number 22V-627.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24021 · Inadvertent Seat Belt Unlatch
Opened Aug 7, 2024 · Closed Dec 12, 2025
Status: closed (inferred from source dates) · Seat Belts
On August 7, 2024, the Office of Defects Investigation (ODI) opened PE24021 to investigate complaints alleging inadvertent unlatching of seat belts in model year (MY) 2020-2023 Hyundai Palisade vehicles manufactured by Hyundai Motor America. The complaints alleged that, without warning, the seat belts sometimes inadvertently unlatch, increasing the risk of injury due to full loss of seat belt protection in the event of a crash. As a result of information exchanged as part of the investigation, on April 3, 2025, Hyundai initiated a warranty extension policy for seat belt buckles on model year 2020-2025 Palisade vehicles in the U.S. and Canada. Hyundai subsequently initiated a request for warranty parts returns to support further analysis by the buckle supplier, ZF Lifetec. The warranty extension (reference “Z06”) noted that certain 2020 – 2025 model year Palisade vehicles may experience abnormal seat belt buckle(s) operation. Hyundai extended the warranty coverage for the seat belt buckle under this condition to 15 years/150,000 miles (whichever occurs first) from the date of original retail delivery or date of first use. This action is valid for original and subsequent owners. On September 11, 2025, Hyundai filed recall 25V-607 for certain 2020-2025 Hyundai Palisade vehicles. Hyundai explained in its recall filing that the subject vehicles are equipped with seat belt buckle assemblies in the front row and second row outer seating positions that may contain out-of-specification components manufactured by the supplier. These components can cause interference within the latch channel, potentially increasing friction, particularly under cold ambient temperatures. Improperly produced seat belt buckles, combined with slow insertion of the seat belt tongue plate, may prevent the seat belt buckle from fully latching. The recall remedy is currently under development. In view of Hyundai’s recall action, ODI is closing this Preliminary Evaluation, but will continue to monitor the issue as a remedy is developed and implemented. ODI will take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ22005 · Windshield Wiper Failure
Opened Dec 2, 2022 · Closed May 26, 2023
Status: closed (inferred from source dates) · Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On August 15, 2022, Hyundai Motor America (Hyundai) filed a safety recall (NHTSA Recall 22V-627) of 122,919 model year (MY) 2020-2021 Hyundai Palisade vehicles produced from April 10, 2019 to November 30, 2020. This recall addressed windshield wipers that may function intermittently or stop functioning when impeded by the accumulation of snow and/or ice at the bottom of the windshield. Intermittent or inoperative windshield wipers could reduce driver visibility while operating the vehicle in inclement weather, increasing the risk of a crash.On December 2, 2022, the Office of Defects Investigation (ODI) opened this Recall Query (RQ) after receiving 6 consumer complaints alleging windshield wiper failures while driving during wintry precipitation in MY 2021-2023 Hyundai Palisade vehicles (subject vehicles). These vehicles were excluded from Recall 22V-627. At the time of opening the RQ, the root cause and recall remedy were still unknown and under investigation. Thus, the RQ was opened to assess the scope and remedy of Recall 22V-627.In its February 10, 2023 response to ODI's information request on the RQ, Hyundai provided 17 customer complaints and 75 warranty claims related to the alleged defect in the subject vehicles. Hyundai stated that the wiper systems in the subject vehicles are equipped with a different wiper motor design than the earlier-built Palisade vehicles included in Recall 22V-627. Hyundai also stated it does not believe there is an unreasonable risk to motor vehicle safety in the wiper system in subject vehicles.On March 17, 2023, Hyundai filed a new safety recall (NHTSA Recall 23V-180) of 167,085 MY 2021-2023 Palisade vehicles produced from December 1, 2020 to November 22, 2022 when a design change was implemented. The design change, as well as the recall remedy (for both Recalls 22V-627 and 23V-180), is a redesigned driver-side wiper arm that allows for additional snow accumulation between the wiper arm and the cowl, thus reducing the load on the wiper motor and circuit breaker activation.In view of the recall action being taken by Hyundai, ODI is closing this RQ. The agency reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at NHTSA.gov under the following ODI identification numbers:11521365, 11517359, 11512295, 11509965, 11509253, 11508868, 11502146, 11501278, 11497343, 11494119, 11458548, 11450975, 11450045, 11449381, 11443330.
Additional source detail variants (4)
Visibility:windshield Wiper/washer
On August 15, 2022, Hyundai Motor America (Hyundai) filed a safety recall (NHTSA Recall 22V-627) of 122,919 model year (MY) 2020-2021 Hyundai Palisade vehicles produced from April 10, 2019 to November 30, 2020. This recall addressed windshield wipers that may function intermittently or stop functioning when impeded by the accumulation of snow and/or ice at the bottom of the windshield. Intermittent or inoperative windshield wipers could reduce driver visibility while operating the vehicle in inclement weather, increasing the risk of a crash.On December 2, 2022, the Office of Defects Investigation (ODI) opened this Recall Query (RQ) after receiving 6 consumer complaints alleging windshield wiper failures while driving during wintry precipitation in MY 2021-2023 Hyundai Palisade vehicles (subject vehicles). These vehicles were excluded from Recall 22V-627. At the time of opening the RQ, the root cause and recall remedy were still unknown and under investigation. Thus, the RQ was opened to assess the scope and remedy of Recall 22V-627.In its February 10, 2023 response to ODI's information request on the RQ, Hyundai provided 17 customer complaints and 75 warranty claims related to the alleged defect in the subject vehicles. Hyundai stated that the wiper systems in the subject vehicles are equipped with a different wiper motor design than the earlier-built Palisade vehicles included in Recall 22V-627. Hyundai also stated it does not believe there is an unreasonable risk to motor vehicle safety in the wiper system in subject vehicles.On March 17, 2023, Hyundai filed a new safety recall (NHTSA Recall 23V-180) of 167,085 MY 2021-2023 Palisade vehicles produced from December 1, 2020 to November 22, 2022 when a design change was implemented. The design change, as well as the recall remedy (for both Recalls 22V-627 and 23V-180), is a redesigned driver-side wiper arm that allows for additional snow accumulation between the wiper arm and the cowl, thus reducing the load on the wiper motor and circuit breaker activation.In view of the recall action being taken by Hyundai, ODI is closing this RQ. The agency reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at NHTSA.gov under the following ODI identification numbers:11521365, 11517359, 11512295, 11509965, 11509253, 11508868, 11502146, 11501278, 11497343, 11494119, 11458548, 11450975, 11450045, 11449381, 11443330.
Visibility:windshield Wiper/washer:linkages
On August 15, 2022, Hyundai Motor America (Hyundai) filed a safety recall (NHTSA Recall 22V-627) of 122,919 model year (MY) 2020-2021 Hyundai Palisade vehicles produced from April 10, 2019 to November 30, 2020. This recall addressed windshield wipers that may function intermittently or stop functioning when impeded by the accumulation of snow and/or ice at the bottom of the windshield. Intermittent or inoperative windshield wipers could reduce driver visibility while operating the vehicle in inclement weather, increasing the risk of a crash.On December 2, 2022, the Office of Defects Investigation (ODI) opened this Recall Query (RQ) after receiving 6 consumer complaints alleging windshield wiper failures while driving during wintry precipitation in MY 2021-2023 Hyundai Palisade vehicles (subject vehicles). These vehicles were excluded from Recall 22V-627. At the time of opening the RQ, the root cause and recall remedy were still unknown and under investigation. Thus, the RQ was opened to assess the scope and remedy of Recall 22V-627.In its February 10, 2023 response to ODI's information request on the RQ, Hyundai provided 17 customer complaints and 75 warranty claims related to the alleged defect in the subject vehicles. Hyundai stated that the wiper systems in the subject vehicles are equipped with a different wiper motor design than the earlier-built Palisade vehicles included in Recall 22V-627. Hyundai also stated it does not believe there is an unreasonable risk to motor vehicle safety in the wiper system in subject vehicles.On March 17, 2023, Hyundai filed a new safety recall (NHTSA Recall 23V-180) of 167,085 MY 2021-2023 Palisade vehicles produced from December 1, 2020 to November 22, 2022 when a design change was implemented. The design change, as well as the recall remedy (for both Recalls 22V-627 and 23V-180), is a redesigned driver-side wiper arm that allows for additional snow accumulation between the wiper arm and the cowl, thus reducing the load on the wiper motor and circuit breaker activation.In view of the recall action being taken by Hyundai, ODI is closing this RQ. The agency reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at NHTSA.gov under the following ODI identification numbers:11521365, 11517359, 11512295, 11509965, 11509253, 11508868, 11502146, 11501278, 11497343, 11494119, 11458548, 11450975, 11450045, 11449381, 11443330.
Visibility:windshield Wiper/washer:motor
On August 15, 2022, Hyundai Motor America (Hyundai) filed a safety recall (NHTSA Recall 22V-627) of 122,919 model year (MY) 2020-2021 Hyundai Palisade vehicles produced from April 10, 2019 to November 30, 2020. This recall addressed windshield wipers that may function intermittently or stop functioning when impeded by the accumulation of snow and/or ice at the bottom of the windshield. Intermittent or inoperative windshield wipers could reduce driver visibility while operating the vehicle in inclement weather, increasing the risk of a crash.On December 2, 2022, the Office of Defects Investigation (ODI) opened this Recall Query (RQ) after receiving 6 consumer complaints alleging windshield wiper failures while driving during wintry precipitation in MY 2021-2023 Hyundai Palisade vehicles (subject vehicles). These vehicles were excluded from Recall 22V-627. At the time of opening the RQ, the root cause and recall remedy were still unknown and under investigation. Thus, the RQ was opened to assess the scope and remedy of Recall 22V-627.In its February 10, 2023 response to ODI's information request on the RQ, Hyundai provided 17 customer complaints and 75 warranty claims related to the alleged defect in the subject vehicles. Hyundai stated that the wiper systems in the subject vehicles are equipped with a different wiper motor design than the earlier-built Palisade vehicles included in Recall 22V-627. Hyundai also stated it does not believe there is an unreasonable risk to motor vehicle safety in the wiper system in subject vehicles.On March 17, 2023, Hyundai filed a new safety recall (NHTSA Recall 23V-180) of 167,085 MY 2021-2023 Palisade vehicles produced from December 1, 2020 to November 22, 2022 when a design change was implemented. The design change, as well as the recall remedy (for both Recalls 22V-627 and 23V-180), is a redesigned driver-side wiper arm that allows for additional snow accumulation between the wiper arm and the cowl, thus reducing the load on the wiper motor and circuit breaker activation.In view of the recall action being taken by Hyundai, ODI is closing this RQ. The agency reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at NHTSA.gov under the following ODI identification numbers:11521365, 11517359, 11512295, 11509965, 11509253, 11508868, 11502146, 11501278, 11497343, 11494119, 11458548, 11450975, 11450045, 11449381, 11443330.
Visibility/wiper
On August 15, 2022, Hyundai Motor America (Hyundai) filed a safety recall (NHTSA Recall 22V-627) of 122,919 model year (MY) 2020-2021 Hyundai Palisade vehicles produced from April 10, 2019 to November 30, 2020. This recall addressed windshield wipers that may function intermittently or stop functioning when impeded by the accumulation of snow and/or ice at the bottom of the windshield. Intermittent or inoperative windshield wipers could reduce driver visibility while operating the vehicle in inclement weather, increasing the risk of a crash.On December 2, 2022, the Office of Defects Investigation (ODI) opened this Recall Query (RQ) after receiving 6 consumer complaints alleging windshield wiper failures while driving during wintry precipitation in MY 2021-2023 Hyundai Palisade vehicles (subject vehicles). These vehicles were excluded from Recall 22V-627. At the time of opening the RQ, the root cause and recall remedy were still unknown and under investigation. Thus, the RQ was opened to assess the scope and remedy of Recall 22V-627.In its February 10, 2023 response to ODI's information request on the RQ, Hyundai provided 17 customer complaints and 75 warranty claims related to the alleged defect in the subject vehicles. Hyundai stated that the wiper systems in the subject vehicles are equipped with a different wiper motor design than the earlier-built Palisade vehicles included in Recall 22V-627. Hyundai also stated it does not believe there is an unreasonable risk to motor vehicle safety in the wiper system in subject vehicles.On March 17, 2023, Hyundai filed a new safety recall (NHTSA Recall 23V-180) of 167,085 MY 2021-2023 Palisade vehicles produced from December 1, 2020 to November 22, 2022 when a design change was implemented. The design change, as well as the recall remedy (for both Recalls 22V-627 and 23V-180), is a redesigned driver-side wiper arm that allows for additional snow accumulation between the wiper arm and the cowl, thus reducing the load on the wiper motor and circuit breaker activation.In view of the recall action being taken by Hyundai, ODI is closing this RQ. The agency reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at NHTSA.gov under the following ODI identification numbers:11521365, 11517359, 11512295, 11509965, 11509253, 11508868, 11502146, 11501278, 11497343, 11494119, 11458548, 11450975, 11450045, 11449381, 11443330.