2017 Hyundai Ioniq Hybrid

I was driving my two young daughters (ages [XXX] and [XXX]) to school, in clear conditions, when we suddenly heard a static-like noise. Instantly, the car's check engine light and check EV battery light came on, and I realized I could no longer accelerate. I immediately pulled off to a safe shoulder and turned the car off and then back on. The car would not move. I exited the vehicle and THANKFULLY left my car door open. I walked around the vehicle and immediately called my husband for help. Within seconds, my [XXX] daughter, who was sitting directly behind me in the rear driver's seat, told me she saw smoke. I went to open her door and realized it was locked. My key fob and door lock would not unlock her door. I reached through my seat to open her door and instantly saw the smoke coming from a vent just to the left of her legs. I unbuckled her and pulled her out, and climbed through the vehicle to get my [XXX] unbuckled and safely out of the vehicle. I cannot stress enough how grateful I am that my car door was left open because I don't believe I would have been able to break the glass to get my daughters out. The could have easily died. Within a minute of the smoke starting from my daughter's vent, the flames began from the same vent. I got both daughters away from the vehicle asap. While trying to grab what I could from the vehicle, my fires on my right hand were caught in the fire. The vehicle became fully engulfed in fire and was a total loss. Two volunteer fire departments responded. I have both the fire incident report as well as the police incident report. The police report only mentioned one daughter but witnesses can attest that I had to get BOTH daughters out. Following the incident, I went to the doctor to receive care for my burns and received a chest x-ray due to smoke inhalation. My [XXX] daughter has been traumatized and keeps thinking something is wrong with her. She told me her bottom felt very warm just before I pulled her out. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMA

The vehicle has suffered a catastrophic failure of the hybrid drive motor rotor, transmission, and engine clutch, resulting in a $14,993 repair quote. This is a direct consequence of a failed remedy for NHTSA Recall 18V260 (Hyundai Campaign 176).In February 2020, a dealer performed an 'inspection/cap' remedy under Campaign 176. However, this did not permanently fix the manufacturing burrs on the hydraulic clutch actuator housing. Over time, the inner oil seals degraded exactly as warned in the original defect report. Hydraulic fluid leaked into the electric stepper motor, causing an electrical short circuit that destroyed the entire hybrid powertrain. The vehicle lost propulsion and threw a severe Hybrid Warning Light on the dashboard. This represents a complete failure of a mandated safety recall remedy, introducing an active electrical short circuit and a severe vehicle fire hazard.

The contact owns a 2017 Hyundai Ioniq Hybrid. The contact stated while at a complete stop at a red traffic light, the vehicle stalled. The vehicle failed to restart and was towed to an independent mechanic, where it was diagnosed that the power relay assembly (PRA) located underneath the rear seat had failed and needed to be replaced; however, the part was not available. The vehicle was not repaired, but the mechanic overrode the computer system. The mechanic related the failure to NHTSA Campaign Number: 22V459000 (Hybrid Propulsion System). The contact stated that the VIN was previously included in the recall; however, the recall was marked as complete after the vehicle passed the inspection test. The contact stated while driving 20-25 MPH, the failure recurred. The vehicle was towed to the dealer, where the contact was informed that the vehicle could not be repaired under the recall. The vehicle was then towed to a second dealer, Keyes Hyundai of Mission Hills(10240 Sepulveda Blvd, Mission Hills, CA 91345), where it was diagnosed that the power relay assembly (PRA) located underneath the rear seat and the 12-Volt battery had failed and needed to be replaced; however, the part was on backorder. The manufacturer was notified of the failure and advised the contact that a goodwill discount could be provided at the dealer's discretion. A case was filed. The contact stated that after the manufacturer contacted the dealer, the dealer doubled the cost of the repair and provided a goodwill discount. The vehicle was not repaired due to the cost. The failure mileage was approximately 153,000.

I own a 2017 Hyundai Ioniq Hybrid VIN: [XXX] that is covered under Recall 232 (NHTSA 22V-459) related to a defective Power Relay Assembly that poses a fire risk. I brought this issue to Hyundai 3 years ago and was told my vehicle was serviced. That turned out to be false. Recently, my car stalled on the road due to the exact electrical issue covered in Recall 232. I had it diagnosed by an independent mechanic, who confirmed it’s tied to the recall. I had the vehicle towed to a Hyundai dealership to have it repaired, but they: •Refused to prioritize the recall inspection •Attempted to charge me $230 for diagnostics •Told me it would take a week or more just to inspect the vehicle •Denied the urgency of the recall, despite the known fire hazard I informed the dealership service manager Tom Swire I was recording, and he still refused to put his denial in writing. I have the recording. Due to their refusal, I was forced to tow the vehicle to a second dealership at my own expense. Hyundai Corporate has opened a case file, but told me I must wait 2–3 days just to speak with a case manager despite this being a federally mandated safety recall tied to real-world safety fire risk. I am requesting NHTSA review this case and hold Hyundai and its dealership accountable for failing to honor Recall 232 within a reasonable and safe timeframe. I am also seeking reimbursement for towing and other out-of-pocket costs caused by their mishandling of this urgent safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have had issues with the car losing speed and start to flutter. The last time it did this it locked up my steering wheel and engine cut off this has been an ongoing issue with this car only had it less than a year and the dealership cannot remedy the issue there is some kind of electrical issue because all lights come on car has less than 50k moles on it this is my 5 visit to the dealership with no resolution have contacted the manufacturer

HELLO MY VEHICLE VIN NUMBER IS : [XXX] I IMPORT MY CAR FROM USA TO JORDAN AND THERE ARE TWO ITEMS FOR RECALL . THERE'S A FIRE SMELL IN THE VECHICLE AND MY CAR IS BROKEN AT THE CURRENT FOR THE SECOND REASON OF THE RECALL . THE AGENT REFUSED TO REPLACE THE PARTS BECAUSE IT'S IMPORTED. NOTE THAT THIS RECALL IS FOR MANUFACTURERS ?FAILURE AND FOR ALL VEHICLES AROUND THE WORLD. PLEASE HELP AND GIVE AN OPINION. WITH MANY THANKS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

HAD REQUIRED RECALL (#178) FOR A PRA TO BE REPLACED PERFORMED 4/6/19, UPON DRIVING IT NOTICED ELECTRONIC, ACID SMELL THAT WENT AWAY. TODAY (4/7/19), UPON DRIVING IT, THE CAR'S CABIN FILLED WITH SMOKE THAT WAS COMING FROM THE REAR SEAT. I IMMEDIATELY PULLED OVER, SHUT THE CAR OFF, REMOVED AS MUCH ITEMS FROM THE CAR AS POSSIBLE AND CALLED MY WIFE, 2 MILES DOWN THE ROAD AT HOME TO BRING A FIRE EXTINGUISHER. UPON HER ARRIVING ROUGHLY 5 MINS LATER, FLAMES BEGAN EMERGING FROM THE BACKSEAT, WHICH I QUICKLY EXTINGUISHED AND PROCEEDED TO CALL 9-1-1. UPON THE POLICE AND FIRE DEPARTMENT ARRIVING, FLAMES WERE STILL EMERGING AND STILL SMOKING UNTIL THEY WERE ABLE TO DOUSE IT WITH WATER, FLAME RETARDANT, AND ALSO DISCONNECT THE BATTERIES TO PREVENT FUTURE DAMAGE. THE CAR WAS EVENTUALLY TOWED TO THE DEALERSHIP AND NOW AWAITING.