2025 Hyundai Ioniq 5

I was leaving from a friends' house and got a "Check electric vehicle system" error and the car went into "limp" mode while on the road. I drove to a hotel parking lot and dropped off my family then proceeded the next day to drive the car to a local dealership for service and the car maxed out at 12 mph before crawling to 1 mph while going up a hill before I could find a place on the side of the road to stop. While awaiting a tow truck the car's electrical system fully "died" leaving me stranded on the side of the road without even hazard lights to warn surrounding traffic. The problem has not yet been evaluated by a dealership, manufacturer or any other agencies. Several warning lamps and messages appeared, including the "Check electric vehicle system" error message.

*I received a notification on my screen of the battery malfunctioning after only owning it for 3 1/2 months. *It was unsafe to drive because it was undependable. *I dropped it off at the dealership and was given a loaner a week lateronly after we insisted they owed us one. It has been over 6 months now and I still am driving a Kona loaner which is a downgrade. *No police or insurance reps involved. Consumer Affairs has little to no information. There wasn’t any prior indication before the notification on the screen.

While pulling out of the garage after charging our 2025 Ionic5 we heard a loud “pop”. As soon as we started driving we got a “Check Electrical System” message. We returned home and had our car towed to the Hyundai dealer. We were told that our ICCU failed and would need to be replaced. We are glad this did not happen while we were driving at speed. We are very concerned that Hyundai has a known issue with a critical component and has not resolved the issue.

On October 10, 2025, while driving the car, a turtle suddenly popped up in place of the speedometer. The car's power and speed was drastically reduced. There was a car behind me that started tailgating me and I could not go any faster than about 15 mph. I was able to make it home. Later that night, I tried to charge the car and it started to overheat. The ICCU recall need to be extended to 2025 models. Ours has been replaced, as well as the PCM and many other parts. Our car still sits at the Hyundai service center because they cannot figure out why the car won't charge.

The ICCU (Integrated Charge Control Unit) failed. Fortunately I was in a parking lot at the time, as the vehicle limited its top speed to around 25 mph. Had the failure occurred on a highway it could have caused a collision. While this is a 2025 model year Ioniq 5, the ICCU hardware (part 36400-1XAA0) remains unchanged across all Hyundai/Kia/Gensis vehicles sharing the eGMP platform. NHTSA previously issued recall 24V-868 intended to address such ICCU failures. While the modified software is included from the factory in the 2025 model year Ioniq 5, it appears that the 24V-868 recall is not a complete fix. Indeed, ICCU failure continues to be one of the most commonly reported owner issues, both for vehicles which have already had the “fix” from recall 24V-868 and for newer vehicles outside of the recall’s scope. This can be confirmed from the numerous posts and videos online (YouTube, Reddit, Ioniq forums, etc.). Given that ICCUs continue to fail at a significant rate, resulting in reduced vehicle speed and vehicle shutdown within minutes (as soon as the 12 V battery is exhausted), I strongly urge NHTSA to do the following: 1. Consider the current ICCU software update to be an ineffective remedy for recall 24V-868. 2. Broaden the scope of recall 24V-868 or create a new recall for all Hyundai/Kia/Genesis eGMP platform vehicles to address this defect. 3. Require that Hyundai/Kia/Genesis create and deploy a truly effective remedy for this defect.

Driving a loud bang was heard from the back of the car. Stopped to check, no obvious physical issue. A warning light came on, it was described as an issue with the air flap. Started driving again, it worked for a few 1000 feet. The car went into a limp mode while an arterial road, in the dark, slowing to not more than 20 mph on a 45 mph road putting driver and child passenger as well as other vehicles at risk. Had to limp until a driveway was found about 3/4 mile later. We got DTC P1A9096 code. The dealer confirm this was an ICCU issue and the related fuse was blown.

This morning my new Hyundai Ioniq 5 with 1900 miles made a loud pop noise and suddenly the car acceleration slow to almost a halt. Then the “Check electric vehicle system” warning light came up on the dashboard. From what I have seen from forums, this most likely a ICCU malfunction needing a replacement. This was scary because the car behind me could have crash into us since the car literally almost a full stop without any warning.