NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
386 reportsMileage unknown · Apr 13, 2026
Fuel/propulsion System
While charging my vehicle at home using a level 2 charger, the ICCU failed. When it failed, it caused a power surge and my level 2 charger “exploded.” It also caused the master breaker to trip, cutting the power off to my entire house. The vehicle no longer charges, will not drive over 25mph and has to be towed to a dealership f…
Read full complaint
While charging my vehicle at home using a level 2 charger, the ICCU failed. When it failed, it caused a power surge and my level 2 charger “exploded.” It also caused the master breaker to trip, cutting the power off to my entire house. The vehicle no longer charges, will not drive over 25mph and has to be towed to a dealership for repair. Also, the level 2 charger is fried and no longer works.
NHTSA ODI #11730728
Mileage unknown · Apr 9, 2026
Electrical SystemStructureUnknown Or OtherCrash
On XXXXX, while parked at a campsite approximately two hours from my home, the vehicle displayed an “electrical failure” warning on the dashboard. The vehicle had been parked for less than 20 minutes when this issue occurred. I contacted Hyundai customer support that same evening to report the problem (Case #XXXXXX). On April 4,…
Read full complaint
On XXXXX, while parked at a campsite approximately two hours from my home, the vehicle displayed an “electrical failure” warning on the dashboard. The vehicle had been parked for less than 20 minutes when this issue occurred. I contacted Hyundai customer support that same evening to report the problem (Case #XXXXXX). On April 4, 2026, the vehicle was towed via Hyundai roadside assistance to Winner Hyundai in Dover, Delaware, where Tracy is my current point of contact. This situation left my family of four, along with our belongings and pet, stranded without transportation. Despite significant effort, we were unable to secure a rental vehicle in the Dewey Beach area, even after contacting multiple rental agencies and the dealership directly. This was later resolved, and I am currently in a rental through Enterprise; however, the stress and uncertainty of potentially being stranded was significant and unacceptable. While at the dealership, my wife witnessed the tow operator unloading the vehicle without proper equipment to safely lower it. As a result, the vehicle’s hitch made forceful contact with the pavement and became lodged. Multiple dealership employees observed the incident. After considerable effort to free the vehicle, it was released abruptly and rolled into another vehicle on the lot, causing additional damage. An argument then occurred between the dealership owner and the tow operator, which my wife was forced to witness. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11730289
Mileage unknown · Apr 9, 2026
Electrical SystemPower Train
There was sudden power reduced and turn to the limp mode(Turtle symbol popped up). After pull over my vehicle to highway shoulder, the vehicle became total power loss. Unable to drive anywhere. It was a dangerous situation for my family. We waited tow car and took my vehicle to Hyundai dealership which located close to my house…
Read full complaint
There was sudden power reduced and turn to the limp mode(Turtle symbol popped up). After pull over my vehicle to highway shoulder, the vehicle became total power loss. Unable to drive anywhere. It was a dangerous situation for my family. We waited tow car and took my vehicle to Hyundai dealership which located close to my house. They diagnosed my car and after a day. They told me it needs to be replaced a ICCU assembly and Fuse. There was no ETA for the parts. They provided me a loaner’s car. After about 15 days, they fixed and I was able to take my car.
NHTSA ODI #11730155
Mileage unknown · Apr 7, 2026
Electrical SystemFuel/propulsion SystemPower TrainCrashInjury
7 incidents of electrical drive problem incidents 1-3car would not start despite full battery Incident 4 same thing and car went to dealer, they said know problem and they would fix it overnight by downloading new software and charge about $400 for new 12V battery Incident 5 While on freeway using cruise control card speed varie…
Read full complaint
7 incidents of electrical drive problem incidents 1-3car would not start despite full battery Incident 4 same thing and car went to dealer, they said know problem and they would fix it overnight by downloading new software and charge about $400 for new 12V battery Incident 5 While on freeway using cruise control card speed varied wildly I disabled cruise control and with manual throttle same problem Incident. 6 In middle of traffic car went blank no lights or anything. I tried to restart 3 times and nothing, so I sat back and was in process of calling for tow. I did nothing and car violently accelerated and turned into steel pole. Only injury I had was bump on head that went away. As soon as the ghost mode engaged I hit the brake which likely prevented more damage to me, but front end of car was damage Incident 7 While I was detained someone else drove car to dealer and driver reported felt like driving on ice with rapid direction and speed changes Currently at dealer where neither dealer or Hyundai will take of problem and I get run arround from Hyundai and dealer. Dealer claim the don’t know is the problem. Dealer has had car for approximately 65 days Bottom line, the car is totally unsafe to drive and very dangerous
NHTSA ODI #11729695
Mileage unknown · Apr 7, 2026
Electrical SystemFuel/propulsion SystemPower Train
On 11/7/25 , we were driving my 2023 Hyundai Ioniq 5 to a friend's home in rural [XXX] , a trip of approximately 160 miles. At around 5:00 PM, we stopped about halfway to our destination to charge the battery. The car would not charge above 47%. While we continued to attempt to charge the battery, the console displayed a Check E…
Read full complaint
On 11/7/25 , we were driving my 2023 Hyundai Ioniq 5 to a friend's home in rural [XXX] , a trip of approximately 160 miles. At around 5:00 PM, we stopped about halfway to our destination to charge the battery. The car would not charge above 47%. While we continued to attempt to charge the battery, the console displayed a Check Electrical System Warning message, and we received the DTC P1AA700 via BlueLink. We were concerned about our safety on the drive up to the mountains. We were afraid the car would stop running on the highway and cause an accident. We were also concerned the car would die in a remote area and we would be stranded. However, the dealership was closed for the weekend. We drove carefully to our friend's home. I contacted Stevens Creek Hyundai on 11/10/25 and arranged to bring the car in on 11/11/25. It had 13,652 miles on it at that time. Eventually, the dealer confirmed the DTC P1AA700 and said they would need to order a new EGMP battery. The car was in the shop for 128 days, waiting for Hyundai to "build a battery" in [XXX] . Eventually, Stevens Creek Hyundai replaced the EV battery and I picked up the car. Given the delay in repairing my car and the growing evidence of Hyundai battery failures, we wanted to report this problem to the authorities. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11729574
Mileage unknown · Apr 5, 2026
Electrical SystemPower Train
While driving the vehicle, the ICCU failed. The vehicle shut down in the middle of traffic without any warnings.
NHTSA ODI #11729262
Mileage unknown · Apr 2, 2026
Electrical System
Failure of Integrated Charge Control Unit (ICCU). Vehicle stopped charging 12V service battery from main high voltage battery. Displayed "Check Electric Vehicle System" followed by "Stop vehicle and check power supply". Vehicle to operate normally though Cruise Control stopped working. Continued to drive the few miles to our hom…
Read full complaint
Failure of Integrated Charge Control Unit (ICCU). Vehicle stopped charging 12V service battery from main high voltage battery. Displayed "Check Electric Vehicle System" followed by "Stop vehicle and check power supply". Vehicle to operate normally though Cruise Control stopped working. Continued to drive the few miles to our home. Once home checked service battery with battery monitor. Showed 12.1V and did not show battery being charged with vehicle ON (Ready) or OFF. Had vehicle towed to Hyundai service facility where the ICCU failure was confirmed.
NHTSA ODI #11728787
Mileage unknown · Apr 2, 2026
Fuel/propulsion System
I am writing to notify you of an Integrated Charging Control Unit (ICCU) failure on my 2023 Hyundai Ioniq 5, purchased in October of 2023. While driving home on March 4 2026, the dashboard displayed the warning "Check vehicle electrical system," and then a "pull over safely" warning. I had to leave the vehicle in a parking lot a…
Read full complaint
I am writing to notify you of an Integrated Charging Control Unit (ICCU) failure on my 2023 Hyundai Ioniq 5, purchased in October of 2023. While driving home on March 4 2026, the dashboard displayed the warning "Check vehicle electrical system," and then a "pull over safely" warning. I had to leave the vehicle in a parking lot and walk home. It was towed to a dealer on March 5, 2026 to diagnose and repair the problem. The car has just under 17000 miles on it. I was told the dealer was swamped with Ioniqs with this problem and had no ETA for parts. Fortunately they will be able to repair our car next week. Hyundai claims the replacement part has been redesigned to address the problem. Interestingly, I'm reading that Hyundai has issued a recall for some vehicles of this make and model year for this very serious issue; mind bogglingly we received no such notice.
NHTSA ODI #11728740
Mileage unknown · Apr 2, 2026
Electrical SystemUnknown Or Other
On Mar 29th, I got a 12v battery low voltage warning sign at 4pm. Jumpstarted the car and drove back to the home. On Mar 30th, car would not start so I had it towed to Downey Hyundai by roadside assistance. On Mar 30th, 12:41pm dealer confirmed that the it will need an "ICCU" and have ordered the part, but there are no loaners …
Read full complaint
On Mar 29th, I got a 12v battery low voltage warning sign at 4pm. Jumpstarted the car and drove back to the home. On Mar 30th, car would not start so I had it towed to Downey Hyundai by roadside assistance. On Mar 30th, 12:41pm dealer confirmed that the it will need an "ICCU" and have ordered the part, but there are no loaners and no ETA for the part at this time. Problem has been reproduced and confirmed by dealer. There were no other warning signs prior to the failure.
NHTSA ODI #11728697
Mileage unknown · Mar 27, 2026
Electrical System
My vehicle lost power as I was driving after warnings from the electrical system. The vehicle was towed to a Hyundai dealership where it was diagnosed with ICCU failure. The ICCU system was replaced by dealer.
NHTSA ODI #11727468
Official recalls
4Jul 2, 2026
Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Ioniq 5 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge. Owner notification letters are expected to be mailed August 31, 2026. Owners may contact Hyundai's customer service at 855-371-9460. Hyundai's number for this recall is 305. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 3, 2026.
Nov 18, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Additional source detail variants (2)
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Mar 15, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Feb 1, 2024
Hyundai Motor America (Hyundai) is recalling certain 2023 IONIQ 5, IONIQ 6, and Genesis GV60 vehicles. The rear inner driveshaft may have been improperly heat-treated, allowing it to break under load and resulting in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the rear inner driveshaft, free of charge. Owner notification letters were mailed March 29, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's numbers for this recall are 253(H), 017G(G).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE23011 · Loss Of Motive Power
Opened Jun 8, 2023 · Closed Apr 17, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration