NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
23 reportsClear category filterMileage unknown · Dec 6, 2023
Electrical SystemForward Collision AvoidanceService Brakes
The following is an incident that happened yesterday to my wife, who is an experienced driver: Whilst driving south on I5 from Seatac toward Tacoma in heavy rain with surface spray the screen above the steering wheel mentioned collision avoidance was not working and radar was not working. When I applied the brakes to slow down…
Read full complaint
The following is an incident that happened yesterday to my wife, who is an experienced driver: Whilst driving south on I5 from Seatac toward Tacoma in heavy rain with surface spray the screen above the steering wheel mentioned collision avoidance was not working and radar was not working. When I applied the brakes to slow down no response from the brakes. I then let off the brake and tried several times to apply the brakes each time with no success. I still had full control of the steering and could still steer the car. This lasted for about 30s then the brakes started working again. The error messages regarding collision avoidance and radar not working would continue to pop up even after the brakes were working. After stopping the car and turning it off and restarting several hours later the car no longer displayed any error messages. No vehicle or passenger were hurt in this incident, however if the traffic had slowed or stopped this outcome could have been very different.
NHTSA ODI #11558818
Mileage unknown · Aug 1, 2023
Electrical SystemService Brakes
When driving in I Pedal mode (which is the one-pedal mode), the brake lights do not light up when decelerating, and it almost caused us to be rear-ended yesterday. Drivers pull aside me and tell me my brake lights don't properly come on when I slow down. Apparently this defect was on the national news several months ago and Hy…
Read full complaint
When driving in I Pedal mode (which is the one-pedal mode), the brake lights do not light up when decelerating, and it almost caused us to be rear-ended yesterday. Drivers pull aside me and tell me my brake lights don't properly come on when I slow down. Apparently this defect was on the national news several months ago and Hyundai promised a software fix by mid-July. I was just at the Carlsbad, CA Hyundai Service Center this morning and was told they do not have a software fix for this issue. This car should officially be recalled by Hyundai and the NHTSA and owners should be warned officially they are driving a dangerous, defective car.
NHTSA ODI #11535750
Mileage unknown · Jul 5, 2023
Exterior LightingService Brakes
When using the one pedal driving or "iPedal" mode, the brake lights do not illuminate when braking unless your foot is completely off of the accelerator pedal. This is very dangerous because the vehicle can be stopped very hard without completely removing your foot from the gas pedal. I have stopped using this mode after almost …
Read full complaint
When using the one pedal driving or "iPedal" mode, the brake lights do not illuminate when braking unless your foot is completely off of the accelerator pedal. This is very dangerous because the vehicle can be stopped very hard without completely removing your foot from the gas pedal. I have stopped using this mode after almost being rear-ended three times within a week due to the car behind me not realizing that I am braking. This issue is gaining media attention. After doing research online, I have learned that there are lots of other people that have noticed the same behavior and have stopped using this mode as a result.
NHTSA ODI #11530475
Mileage unknown · May 29, 2023
Service BrakesVehicle Speed Control
brake lights do not come on when the car is in regenerative braking or driving mode and the driver is touching the gas pedal. Drivers following the car are not aware the car is actually braking not coasting. This is causing a rearending hazard. Mfr needs to correct issues so brake lights come on when car is in regenerative braki…
Read full complaint
brake lights do not come on when the car is in regenerative braking or driving mode and the driver is touching the gas pedal. Drivers following the car are not aware the car is actually braking not coasting. This is causing a rearending hazard. Mfr needs to correct issues so brake lights come on when car is in regenerative braking mode and the car is deaccellerating regardless of gas pedal activity
NHTSA ODI #11524271
Mileage unknown · May 28, 2023
Electrical SystemService Brakes
The Ioniq 5 has a braking system that does not engage the brake lights on deceleration when in certain regenerative braking settings. This is dangerous as the car will quickly decelerate and not warn drivers behind you potentially causing a crash because they are unaware the Ioniq is stopping quickly. Please have Hyundai addre…
Read full complaint
The Ioniq 5 has a braking system that does not engage the brake lights on deceleration when in certain regenerative braking settings. This is dangerous as the car will quickly decelerate and not warn drivers behind you potentially causing a crash because they are unaware the Ioniq is stopping quickly. Please have Hyundai address the issue for recall.
NHTSA ODI #11524188
Mileage unknown · May 26, 2023
Exterior LightingService BrakesVehicle Speed Control
The Ioniq 5 when using level 2 regen, level 3 regen, and i-pedal (one pedal driving), does not turn on the break light when decelerating, even if coming to a full stop unless the driver removes their foot completely from the pedal or hits the break pedal. These driving modes allow the driver to perform regenerative breaking al…
Read full complaint
The Ioniq 5 when using level 2 regen, level 3 regen, and i-pedal (one pedal driving), does not turn on the break light when decelerating, even if coming to a full stop unless the driver removes their foot completely from the pedal or hits the break pedal. These driving modes allow the driver to perform regenerative breaking almost to a complete stop without turning on the break lights and warning other drivers behind you. With i-pedal specifically, the driver can 100% perform all stop and go traffic maneuvers without using the break and never have the break lights activate. This appears to be the default behavior of all Ioniq 5 vehicles and is controlled via software. The vehicle does not appear to measure rate of deceleration so even if the driver were to decelerate rapidly, the brakes would not activate. This has been extensively demonstrated on youtube and the best video example of this problem can be found here: https://www.youtube.com/watch?v=U0YW7x9U5TQ
NHTSA ODI #11524021
Mileage unknown · May 26, 2023
Service Brakes
The brakes lights do not illuminate when slowing down using regen braking. This has cause cars to stop very close to rear-ending me. This video explains this issue in great detail https://www.youtube.com/watch?v=U0YW7x9U5TQ
NHTSA ODI #11523948
Mileage unknown · May 25, 2023
Service Brakes
Brake lights do not lit while decelerating using regen braking system without letting foot off of accelerator. There is no indication for vehicle behind mine to decelerate which can result in collision
NHTSA ODI #11523916
Mileage unknown · May 25, 2023
Service Brakes
Brake lights do NOT come on when decelerating in I-PEDAL mode and Level 3 regen brake modes, perhaps more. The car should instead generously apply brake lights by default anytime deceleration occurs via regen braking.
NHTSA ODI #11523904
Mileage unknown · May 25, 2023
Service Brakes
When using most of the regenerative braking levels, including the one-pedal driving mode named “i-Pedal,” the brake lights will not illuminate until the drivers foot is fully off the gas pedal, or manually applying the brakes. This can create a dangerous, life threatening scenario leaving surrounding drivers unaware the vehicle …
Read full complaint
When using most of the regenerative braking levels, including the one-pedal driving mode named “i-Pedal,” the brake lights will not illuminate until the drivers foot is fully off the gas pedal, or manually applying the brakes. This can create a dangerous, life threatening scenario leaving surrounding drivers unaware the vehicle is slowing. This has not been reproduced by the automaker not inspected by them, police, insurance, etc but has been verified on video. No warning lamps appeared.
NHTSA ODI #11523888
Official recalls
4Jul 2, 2026
Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Ioniq 5 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge. Owner notification letters are expected to be mailed August 31, 2026. Owners may contact Hyundai's customer service at 855-371-9460. Hyundai's number for this recall is 305. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 3, 2026.
Nov 18, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Additional source detail variants (2)
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.
Mar 15, 2024
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Electrical System:propulsion System:charging:module:software
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: This recall is replaced by NHTSA recall number 24V-868. Vehicles already repaired under this recall will need to have the new remedy completed. Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed April 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 257/021G.
Feb 1, 2024
Hyundai Motor America (Hyundai) is recalling certain 2023 IONIQ 5, IONIQ 6, and Genesis GV60 vehicles. The rear inner driveshaft may have been improperly heat-treated, allowing it to break under load and resulting in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the rear inner driveshaft, free of charge. Owner notification letters were mailed March 29, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's numbers for this recall are 253(H), 017G(G).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE23011 · Loss Of Motive Power
Opened Jun 8, 2023 · Closed Apr 17, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:dc/dc Converter
On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) may be subject to various conditions such as overcurrent, overvoltage induced at the end of charging, and certain thermal loading during operation that can damage its internal components and open the ICCU fuse, resulting in an inability to charge the 12-volt battery. The vehicle could eventually lose all motive power, increasing the risk of a crash. In July 2023, Hyundai issued a service campaign to address certain MY 2022-2023 Ioniq 5 and MY 2023 Ioniq 6 vehicles that may have low 12V auxiliary battery charging occurrences due to an ICCU fault and may set the DTC P1A9096 “DC/DC Converter Input Voltage Sensor Fault”. On March 15, 2024, Hyundai filed Safety Recall 24V-204 for 98,878 MY 2022-2024 Hyundai Ioniq 5 vehicles and MY 2023-2024 Hyundai Ioniq 6, Genesis GV60, Genesis GV70 “Electrified” and Genesis G80 “Electrified” vehicles. The recall remedy provides an inspection, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Hyundai, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration