Illustration2007 HYUNDAI ENTOURAGE. CONSUMER WRITES IN REGARD TO BROKEN POWER STEERING BELT.
2007 Hyundai Entourage
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Entourage years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
350–25K
2925–50K
2750–75K
3475–100K
29100–150K
21150K+
175 reports with mileage · 38 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports2 fire reports7 injury reports
Steering complaints
11 reportsThe contact owns a 2007 Hyundai Entourage. The contact stated while driving 5 MPH in a parking lot and making a left turn, he heard an abnormal noise coming from the front passenger’s side tire and the steering wheel became difficult to turn. The contact stated no warning light was illuminated. The contact was able to park the v…
Read full complaint
The contact owns a 2007 Hyundai Entourage. The contact stated while driving 5 MPH in a parking lot and making a left turn, he heard an abnormal noise coming from the front passenger’s side tire and the steering wheel became difficult to turn. The contact stated no warning light was illuminated. The contact was able to park the vehicle safely. The vehicle was not drivable. The contact towed the vehicle to the insurance facility and then towed to an independent mechanic. The contact was informed that the front passenger’s side control arm, the front driver’s side control arm, and the constant velocity axle needed to be replaced. The vehicle was repaired. A dealer was not contacted. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 13V556000 (Suspension) however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 154,000.
MY WIFE WAS DRIVING WITH CHILDREN IN THE CAR AND RIGHT HAND SIDE SUSPENSION CONTROL ARM SNAPPED IN HALF. CAR WAS ABLE TO BE DRIVEN HOME BUT WHEEL WAS PUSHED UP AGAINST THE WHEEL WELL.
WHILE DRIVING TO WORK YESTERDAY MORNING, I WAS TURNING OFF A SIDE ROAD ONTO A MAIN ROAD. AS SOON AS I TURNED ON TO THE MAIN ROAD THE VAN SOUNDED LIKE MAYBE IT HAD A FLAT, IT DID NOT. BOTH ESC LIGHTS CAME ON AND STAYED ON. THE STEERING AND BRAKING WAS ERRATIC AND THERE WAS NO PICK UP. I COULD NOT GET THE WHEELS TO TURN THE SAME …
Read full complaint
WHILE DRIVING TO WORK YESTERDAY MORNING, I WAS TURNING OFF A SIDE ROAD ONTO A MAIN ROAD. AS SOON AS I TURNED ON TO THE MAIN ROAD THE VAN SOUNDED LIKE MAYBE IT HAD A FLAT, IT DID NOT. BOTH ESC LIGHTS CAME ON AND STAYED ON. THE STEERING AND BRAKING WAS ERRATIC AND THERE WAS NO PICK UP. I COULD NOT GET THE WHEELS TO TURN THE SAME DIRECTION AS THE STEERING WHEEL FOR A SHORT PERIOD OF TIME MOVING INTO ON COMING TRAFFIC. LUCKILY I WAS ABLE TO GET SHORT PERIOD OF CONTROL, ENOUGH TO BARLEY TURN INTO A PARKING LOT. I AM SO FORTUNATE THIS DIDN'T HAPPEN ON THE HIGHWAY AT 55MPH OR COULD HAVE BEEN HORRIFIC. I DID CALL HYUNDAI AND THERE ARE SEVERAL RECALLS FOR THE VAN INCLUDING THE FRONT CONTROL ARMS. I ASKED IF THEY CAN TOW TO THE NEAREST DEALER CONSIDERING I JUST AVOIDED AN ACCIDENT AND HAD NO CONTROL. HYUNDAI WILL NOT TOW TO THE DEALER. THEY DID OFFER TO REIMBURSE ME IF I TOW IT, BUT THAT DOES NOT HELP ME CURRENTLY. THIS IS A VERY SERIOUS SITUATION AND NEEDS TO BE RECTIFIED BY HYUNDAI BEFORE A DRIVER IS NOT ABLE TO AVOID AN ACCIDENT DUE TO HAVING NO PICK UP OR CONTROL OF THE STEERING.
WHILE DRIVING APPROX. 30 MPH (MOVING STRAIGHT; NOT TURNING) A NOISE WAS HEARD, THE FRONT OF THE VEHICLE SEEMED TO DROP, AND BOTH STEERING AND BRAKES BECAME ERRATIC. THE VAN, STILL ACTING UP, MADE IT TO A PARKING LOT, WHERE A VISUAL INSPECTION OF THE FRONT DRIVER'S SIDE WHEEL WELL INDICATED WHAT I BELIEVE TO BE A BROKEN CONTROL …
Read full complaint
WHILE DRIVING APPROX. 30 MPH (MOVING STRAIGHT; NOT TURNING) A NOISE WAS HEARD, THE FRONT OF THE VEHICLE SEEMED TO DROP, AND BOTH STEERING AND BRAKES BECAME ERRATIC. THE VAN, STILL ACTING UP, MADE IT TO A PARKING LOT, WHERE A VISUAL INSPECTION OF THE FRONT DRIVER'S SIDE WHEEL WELL INDICATED WHAT I BELIEVE TO BE A BROKEN CONTROL ARM (SEE PHOTO). THIS IS A KNOWN ISSUE WITH THIS VEHICLE, AND LATE IN 2013 THERE WAS A RECALL (# 13V556000). VEHICLE OWNERS WERE ADVISED TO TAKE THE VEHICLE TO THE DEALER FOR AND INSPECTION AND EITHER RUSTPROOFING OR REPLACEMENT OF THE CONTROL ARMS. ON 1/20/14, THE VEHICLE UNDERWENT THIS PROCESS AND REPORTED "INSPECTED, WAXED, AND UNDERCOATED AS PER CAMPAIGN" (SEE EXCERPT FROM INVOICE). NO DAMAGE TO THE CONTROL ARMS WAS REPORTED BY THE DEALER'S SERVICE SHOP. HAD I BEEN INFORMED OF A DAMAGED PART DURING THE "INSPECTION", I WOULD HAVE CHOSEN TO REPLACE IT, AS THIS IS APPARENTLY VITAL TO KEEPING CONTROL OF THE VEHICLE. OVER THE PAST SEVERAL WEEKS, I HAVE DONE A LOT OF HIGHWAY DRIVING. HAD THIS HAPPENED AT 65 OR 70 MPH, RATHER THAN AT THE 30 MPH IN THE CITY, THE OUTCOME COULD HAVE BEEN DISASTROUS. A POLICE OFFICER SHOWED UP TO HELP AND TOOK DOWN MY NAME - I DO NOT KNOW IF A FORMAL REPORT WILL BE FILED..
WILD DRIVE IN THE CITY IF I DRIVE OVER A MANHOLE IT SOUNDS HORRIBLE WHAT CAN BE INSTALLED NEW SKERKENSHOWBERS AND IT STILL DOES THE SAME THING I AM A NEW OWNER OF THIS VEHICLE ARE THERE ANY RECALLS ON THIS VEHICLE THANK YOU MY NAME IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 55…
Read full complaint
WILD DRIVE IN THE CITY IF I DRIVE OVER A MANHOLE IT SOUNDS HORRIBLE WHAT CAN BE INSTALLED NEW SKERKENSHOWBERS AND IT STILL DOES THE SAME THING I AM A NEW OWNER OF THIS VEHICLE ARE THERE ANY RECALLS ON THIS VEHICLE THANK YOU MY NAME IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNS A 2007 HYUNDAI ENTOURAGE. THE CONTACT STATED THAT THE SUB-FRAME WAS RUSTED. IN ADDITION, THE RACK AND PINION SHIFTED WHICH CAUSED THE POWER STEERING TO LEAK. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUB FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS M…
Read full complaint
TL* THE CONTACT OWNS A 2007 HYUNDAI ENTOURAGE. THE CONTACT STATED THAT THE SUB-FRAME WAS RUSTED. IN ADDITION, THE RACK AND PINION SHIFTED WHICH CAUSED THE POWER STEERING TO LEAK. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUB FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 132,000.
TL*THE CONTACT OWNS A 2007 HYUNDAI ENTOURAGE. WHILE DRIVING 55 MPH AND GETTING OFF AN EXIT RAMP, THE VEHICLE SUDDENLY ACCELERATED, PULLED TO THE LEFT AND BECAME OUT OF CONTROL. THE VEHICLE CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. THE DRIVER AND PASSENGER WERE INJURED AND TRANSPORTED TO THE HOSPITAL. A POLICE REPORT WAS …
Read full complaint
TL*THE CONTACT OWNS A 2007 HYUNDAI ENTOURAGE. WHILE DRIVING 55 MPH AND GETTING OFF AN EXIT RAMP, THE VEHICLE SUDDENLY ACCELERATED, PULLED TO THE LEFT AND BECAME OUT OF CONTROL. THE VEHICLE CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. THE DRIVER AND PASSENGER WERE INJURED AND TRANSPORTED TO THE HOSPITAL. A POLICE REPORT WAS FILED. THE MANUFACTURER STATED THAT THEY WOULD SEND SOMEONE TO INSPECT THE VEHICLE. PRIOR TO THE FAILURE, THE VEHICLE HAD NOT BEEN REPAIRED ON THE FRONT SUSPENSION AND STEERING MECHANISM; WHEN THE CONTACT WENT TO PICK THE VEHICLE UP, HE WAS TOLD THAT THE TIE ROD, BALL JOINTS AND CONTROL ARM WERE ALSO REPLACED. OTHER PARTS NEEDED TO BE REPAIRED BUT WERE ON BACKORDERED. THE FAILURE MILEAGE WAS APPROXIMATELY 32,000.
MY 2007 ENTOURAGE LIMITED HAS SEVERAL QUALITY DEFICIENCY ISSUES AND RECURRING MAINTENANCE ISSUES. THE REAR SLIDING DOORS (BOTH) HAVE BEEN WORKED ON SEVERAL TIMES, YET THEY CONTINUE TO MALFUNCTION, I.E COME UNDONE/RE-OPEN, NOT FULLY LATCH, AND CONSISTENTLY BEEP AS A NOTICE OF FAILURE. THIS IS WHERE MY BABIES SIT, BOTH OF THEM. TH…
Read full complaint
MY 2007 ENTOURAGE LIMITED HAS SEVERAL QUALITY DEFICIENCY ISSUES AND RECURRING MAINTENANCE ISSUES. THE REAR SLIDING DOORS (BOTH) HAVE BEEN WORKED ON SEVERAL TIMES, YET THEY CONTINUE TO MALFUNCTION, I.E COME UNDONE/RE-OPEN, NOT FULLY LATCH, AND CONSISTENTLY BEEP AS A NOTICE OF FAILURE. THIS IS WHERE MY BABIES SIT, BOTH OF THEM. THE DVD SCREEN HAS BEEN REPLACED BECAUSE IT QUIT FUNCTIONING PROPERLY. THE VAN SHIMMIES OR RATTLES AT SPEED AROUND 70 MPH. IT CAUSES THE CENTER CONSOLE TO SHAKE VIGOROUSLY. THE WHEELS WERE BALANCED ON A SPECIAL WHEEL BALANCER BUT THIS ONLY REDUCED THE PROBLEM. THE TIRE PRESSURE MONITORING SYSTEM HAS HAD MALFUNCTIONS MULTIPLE TIMES. THERE IS A WHINE FROM THE STEERING COLUMN WHEN THE WHEEL IS TURNED, THE ALTERNATOR IS CREATING A WHINE OVER THE STEREO SYSTEM INTERMITTENTLY(REALLY ANNOYING), THE SIDE MIRRORS HAVE BOTH HAD PROBLEMS WITH THE REVERSE/ANGLE FUNCTION WHERE THE MIRRORS' MOTOR FAILS TO RETURN THE MIRROR TO ITS USER PRESET SETTING WHEN TRANSMISSION IS PLACED OUT OF REVERSE(DRIVERS SIDE) OR FAILS TO TILT THE SPECIFIED DEGREE IN REVERSE(PASSENGER SIDE). THE ROOF LEAKED WHEN THE VAN WAS COMPLETELY SHUT AND HAD TO BE RESEALED BY A SPECIALIST TO CORRECT AN EXISTING DEFICIENCY, THE SEAL AROUND THE GLASS FOR THE SUNROOF IS DEGRADING AND CRACKING. THE SLIDING REAR DOOR ON THE DRIVERS SIDE HAS A CRIMPED WINDOW CHANNEL SEAL. THIS SHOP ALSO STATED THAT THEY "HAD NOT SEEN ONE OF THESE [ENTOURAGE] VANS WITH SO MANY PROBLEMS". THE DOOR HANDLES AND REAR HIGH MOUNT STOP LIGHT HAD TO BE REPLACED DUE TO THE PACKING/SHIPPING POLY WRAP RUINING THE CHROME AND PLASTIC LENS. THE GASKET FOR THE HIGH MOUNT STOP LIGHT HAD TO BE REPLACED LATER DUE TO WORKMANSHIP OR MATERIAL QUALITY. THE WINDSHIELD CRACKED/FAILED (1/2" CHUNK OF THE WINDSHIELD) WHEN MY WIFE ADJUSTED THE REAR VIEW MIRROR. THE IDLER PULLEY HAS BEEN REPLACED BECAUSE THE BEARING FAILED. STRIPPING AROUND THE SLIDING DOORS ARE FADING ALREADY AND YELLOWING. MORE NOT ENOUGH SPACE. *TR
TL*THE CONTACT OWNS A 2007 HYUNDAI ENTOURAGE. THE CONTACT STATED THAT THE SLIDING DOORS ON HER VEHICLE WOULD NOT REMAIN CLOSED. ON ONE OCCASION, THE DRIVER'S DOOR OPENED WHILE DRIVING AT AN UNKNOWN SPEED. SHE PUSHED VARIOUS BUTTONS ON THE DOOR IN AN ATTEMPT TO KEEP IT CLOSED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES…
Read full complaint
TL*THE CONTACT OWNS A 2007 HYUNDAI ENTOURAGE. THE CONTACT STATED THAT THE SLIDING DOORS ON HER VEHICLE WOULD NOT REMAIN CLOSED. ON ONE OCCASION, THE DRIVER'S DOOR OPENED WHILE DRIVING AT AN UNKNOWN SPEED. SHE PUSHED VARIOUS BUTTONS ON THE DOOR IN AN ATTEMPT TO KEEP IT CLOSED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES AND THEY REPLACED THE LATCHING MECHANISMS AND SLIDING DOOR LOCK MODULES; HOWEVER, THE FAILURE CONTINUED TO PERSIST. THE MANUFACTURER STATED THAT THEY WOULD BRING IN A MECHANIC FROM CALIFORNIA WHO WOULD DETERMINE THE CAUSE OF THE FAILURE AND THEY WOULD NOT RETURN THE VEHICLE UNTIL IT WAS REPAIRED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 23,017 AND FAILURE MILEAGE WAS APPROXIMATELY 100. UPDATE 10/01/08 *CW THE POWER SLIDING DOOR, DID NOT OPEN OR CLOSE. THE STEERING WHEEL VIBRATED AT HIGHWAY SPEED. UPDATED 10/02/08. *JB
Official recalls
620V061000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Feb 4, 2020
Hyundai Motor America (Hyundai) is recalling certain 2007-2010 Elantra and 2009-2011 Elantra Touring vehicles. On February 21, 2020 Hyundai expanded the recall to include 46,425 model year 2007-2008 Entourage and 2007 Santa Fe vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence & remedy
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the car is turned off, increasing the risk of an injury.
Remedy: Hyundai will notify owners, and dealers will install a relay in the vehicle's main junction box to prevent the risk of an ABS short-circuit while the car is turned off, free of charge. The recall began April 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 188.
16V843000 · Latches/locks/linkages:hood:latch
Nov 21, 2016
Hyundai Motor America (Hyundai) is recalling certain model year 2007-2008 Entourage vehicles manufactured February 16, 2006, to June 30, 2008. In the affected vehicles, the secondary hood latch may corrode and bind and remain in the unlatched position when the hood is closed.
Consequence & remedy
Consequence: If the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy: Hyundai will notify all of the owners. For vehicles originally sold, or ever registered, in Alaska, Connecticut, Delaware, Illinois, Indiana, Iowa, Kansas, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, Nebraska, New Hampshire, New Jersey, New York, North Dakota, Ohio, Pennsylvania, Rhode Island, South Dakota, Utah, Vermont, West Virginia, Wisconsin, and the District of Columbia, dealers will replace the secondary latch. For vehicles in any other state, dealers will inspect and either lubricate or replace the secondary latch, as necessary, free of charge. Owners may contact Hyundai customer service at 1-800-633-5151. The recall began January 2017. Hyundai's number for this recall is 154.
13V556000 · Suspension:front:control Arm:lower Arm
Nov 6, 2013
Hyundai America Technical Center, Inc. (Hyundai) is recalling certain model year 2007-2008 Hyundai Entourage vehicles manufactured from February 16, 2006, through June 30, 2008 and sold in, or currently registered in, Massachusetts, Maryland, Michigan, New Hampshire, New York, Pennsylvania, Vermont, Wisconsin, Connecticut, Delaware, Iowa, Illinois, Indiana, Maine, Minnesota, Missouri, New Jersey, Ohio, Rhode Island, West Virginia and the District of Columbia. In the affected vehicles, the front lower control arms may fracture due to corrosion resulting from exposure to road salt and water.
Consequence & remedy
Consequence: A fractured control arm can result in the loss of control of the vehicle, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will inspect the degree of corrosion of the front lower control arms, and will either rustproof or replace them, free of charge. The recall began on January 3, 2014. Owners may contact Hyundai at 1-800-633-5151 or by email at consumeraffairs@hmausa.com. Hyundai's recall number is 115.
13V113000 · Exterior Lighting:brake Lights:switch
Apr 1, 2013
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
09V122000 · Exterior Lighting:brake Lights:switch
Apr 15, 2009
HYUNDAI IS RECALLING 532,633 MY 2006-2007 ACCENT, ENTOURAGE, SONATA, MY 2007 AZERA, ELANTRA AND SANTA FE, MY 2005-2007 TUCSON AND MY 2007-2008 VERACRUZ VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
06V356000 · Electrical System:wiring
Sep 19, 2006
ON CERTAIN MINIVANS EQUIPPED WITH ADJUSTABLE BRAKE PEDALS, THE STOP LAMP SWITCH WIRING HARNESS MAY BE OUT OF POSITION. AN IMPROPERLY POSITIONED STOP LAMP SWITCH WIRING HARNESS COULD MAKE CONTACT WITH THE U-JOINT ASSEMBLY OF THE STEERING COLUMN. REPEATED CONTACT MAY EVENTUALLY CAUSE THE WIRING HARNESS INSULATION TO CHAFE.
Consequence & remedy
Consequence: CHAFED INSULATION COULD CAUSE A SHORT OF THE WIRING HARNESS RESULTING IN THE LOSS OF BRAKE LIGHTS, ENGINE STALLING, OR AN INABILITY TO START THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE WIRING HARNESS FOR CHAFING AND REPAIR IT IF NECESSARY. ALSO, THE DEALER WILL SECURE THE WIRING HARNESS TO PREVENT FUTURE CONTACT WITH THE U-JOINT ASSEMBLY.THE RECALL BEGAN ON OCTOBER 9, 2006. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE09003 · Stop Lamp Switch Failure
Opened Jan 14, 2009 · Closed Apr 24, 2009
Status: closed (inferred from source dates) · Electronic Stability Control; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Power Train:automatic Transmission:lever And Linkage:column Shift; Power Train:automatic Transmission:lever And Linkage:floor Shift; Power Train:manual Transmission:column Shift Assembly; Power Train:manual Transmission:floor Shift Assembly; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:pedals And Linkages; Vehicle Speed Control:cruise Control
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (10)
Electronic Stability Control
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights:switch
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:automatic Transmission:lever And Linkage:column Shift
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:automatic Transmission:lever And Linkage:floor Shift
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:manual Transmission:column Shift Assembly
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Power Train:manual Transmission:floor Shift Assembly
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Service Brakes, Hydraulic:pedals And Linkages
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Vehicle Speed Control:cruise Control
BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.