2018 Hyundai Elantra

We were heading back to Ohio at Mile marker 8 75N Kentucky when we heard a boom. Then we saw smoke as my husband was pulling over. We jump out to get our child out of the car seat and at the same time a pickup truck pulls up with two guys. They yell that our cars on fire and began putting the fire out with a fire extinguisher. We had an oil change before we left Ohio by Valvoline. This area of the hwy isn't really patrolled and only has a volunteer fire department. A constable just happened to pass by US on the way to Indiana.

The engine of my 2018 Hyundai Elantra has a rod bearing defect covered under a safety recall. The vehicle has not been repaired yet, and the issue prevents the car from being safely operated. I have incurred towing expenses due to the inability to use the vehicle, and I am concerned about potential engine failure or safety hazards if the defect is not addressed promptly.

The dealership replaced my engine and spark plugs when the pistons were grinding metal causing a catastrophic failure in November of 2024. In July of 2025 I started experiencing the same issues and the dealership stated that Hyundais ignition coils have a high rate of failure because they changed the design and used my old ones from my engine replacement. It is now I brought my car into the dealership July 18th and they stated that was their best guess but they didn’t now forsure. I was never informed of the high rate of failure until I was experiencing it.

I purchased a 2018 Hyundai Elantra on April 3, 2024, from CarMax. At the time of purchase, I was not told about any recalls. Later, I discovered that my vehicle is covered by Hyundai Service Campaign 993 (Anti-Theft Software Upgrade), issued February 13, 2023, which addressed the lack of an immobilizer in 2011–2022 Hyundai vehicles. On May 29, 2025, my vehicle was stolen due to this defect. When it was recovered, it had a blown engine and was completely inoperable. Hyundai acknowledges that my VIN is included in the recall, but they have only offered to install the software update now. That does not remedy the damages caused by the theft and resulting engine failure. CarMax has denied responsibility, claiming they were not aware of the recall. I am now left with a financed vehicle that is not drivable and has lost significant value due to Hyundai’s defective design.

I started my vehicle and it was running sluggish and low idle. I had an engine light and when I tried to drive there was a clanking sound. When I had the engine light tested I received the following codes: P0017 - Crankshaft Position Correlation Bank 1 Sensor B, P0303 - Cylinder 3 Misfire Detected, P0302 - Cylinder 2 Misfire Detected, P0301, P0014 - Exhaust Camshaft Position Timing - Over Advanced (Bank 1), P0030 H02S Heater Control Circuit (Bank 1, Sensor 1) I had it towed to my nearest Hyundai dealer in Tacoma, WA. After they did a diagnostic they said that they would have to replace the engine due to a shearing of a pin, leading to the belt jumping and causing issues. I am the only owner of the vehicle, I have had all my oil changes on time and my vehicle is 137,000 miles. This should not be happening in a vehicle with such low mileage. In reading online, this is an issue that Hyundai is aware of but not concerned with. There was no warning beforehand. This could have led to my engine stalling on the the freeway at freeway speeds and thus could have caused a great accident and bodily harm to myself and others. Hyundai has denied responsibility but knows this is an ongoing issue with it's poorly manufactured engines. I was not informed of all the problems of Hyundai vehicles before I purchased mine. I have yet to receive help from Hyundai Customer Service or the Hyundai Dealer.