2017 Hyundai Elantra

While operating my 2017 Hyundai Elantra under normal driving conditions at approximately 70,000 miles, the engine suffered a sudden, catastrophic loss of motive power and stalled completely while moving in active traffic without any prior warning. This severe stalling event occurred despite the vehicle being strictly and meticulously maintained according to all manufacturer guidelines and scheduled service intervals. Prior to the stall, the Check Engine Light illuminated. A comprehensive diagnostic scan completed at an authorized Hyundai dealership confirmed active trouble codes P0014 (Exhaust Camshaft Position Timing Over-Advanced) and P0017 (Crankshaft-Camshaft Position Correlation Error). The internal physical engine timing assembly and Variable Valve Timing (VVT) components slipped out of synchronization, forcing an abrupt, automatic engine shutdown while navigating active roadways. This failure created an immediate, severe safety hazard and high collision risk due to the sudden loss of vehicle propulsion, power steering assist, and vacuum brake booster pressure, leaving me vulnerable in traffic. This structural timing deviation caused chronic engine misfires and forced raw, unburned fuel directly into the exhaust stream. This unburned fuel completely fouled and destroyed the primary Oxygen (O2) Sensor due to heavy carbon contamination and extreme thermal stress. The failed sensor and incorrect valve timing totally disrupted the electronic control unit's air-fuel management, inducing the unpredictable stalling hazard and causing an immediate, automatic state emissions/smog inspection failure. Repairing this underlying manufacturing and metallurgical defect at the official Hyundai dealership required an extensive mechanical teardown and replacement of the timing components, costing approximately $2,500 out of pocket. This exact failure pattern, cascading O2 sensor damage, and diagnostic trouble codes match hundreds of existing complaints with NHTSA.

1. The engine architecture suffered a catastrophic mechanical failure. Specifically, severe, systemic internal oil consumption/vaporization starved the hydraulic timing chain tensioner of critical hydrostatic pressure. This caused the tensioner to collapse, creating slack in the steel timing chain, which then "jumped time" (skipped a tooth on the camshaft sprockets), causing the engine to instantly seize and lose all motive power. The vehicle and engine are fully intact and available for inspection at Pohanka Hyundai of Fredericksburg. 2. The vehicle suffered a sudden, complete loss of motive power and engine seizure while being driven at night on an unlit, dark secondary roadway. The driver (my daughter) was left suddenly stranded without power in a highly vulnerable, pitch-black location with passing traffic, presenting an immediate collision hazard and a severe personal safety risk before emergency assistance could arrive. 3. Yes. The vehicle was towed to an authorized Hyundai dealership (Pohanka Hyundai of Fredericksburg), where service technicians officially diagnosed that the engine had "jumped timing" and suffered a complete failure of the timing system, alongside a noted lack of engine oil volume due to vaporization. 4. The vehicle has been formally inspected and diagnosed by the authorized Hyundai dealership service department under Hyundai Motor America Corporate Case #[XXX]. No police or insurance inspections were required as no collision occurred. 5. No dash lights or warnings before failure. However, for a year prior, the engine exhibited severe internal oil vaporization, requiring constant top-offs between scheduled oil changes to maintain safe levels. There were zero external fluid leaks on the engine or ground; oil burned entirely internally. This chronic volumetric oil loss directly caused the sudden drop in pressure, hydraulic tensioner collapse, and catastrophic engine seizure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

What component or system failed or malfunctioned, and is it available for inspection upon request? How was your safety or the safety of others put at risk? The ignition coil in my 2017 Hyundai Elantra Limited has failed multiple times over the past several years. This recurring issue has caused the vehicle to malfunction unexpectedly, creating safety concerns due to reduced engine performance, misfiring, and the potential for sudden loss of power while driving, which puts both myself and others on the road at risk. The failed component is available for inspection upon request. Has the problem been reproduced or confirmed by a dealer or independent service center? This issue has occurred multiple times with my vehicle. After researching online consumer reports and owner complaints, I found that ignition coil failures appear to be a common and recurring issue reported by other 2017 Hyundai Elantra Limited owners. Based on these repeated failures and similar reports, this appears to be a known issue affecting this model. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? I have reported this issue to Hyundai multiple times. Rather than addressing the root cause or issuing a recall for this recurring defect, Hyundai has repeatedly provided credits to assist with repair costs when the ignition coil fails. Despite the repeated failures and safety concerns, the underlying issue has not been permanently resolved. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? Prior to failure, the vehicle would experience rough starts, engine misfires, and poor performance. After these symptoms began, the check engine light would eventually illuminate. Once the warning light appeared, the vehicle became increasingly unreliable and would stall or shut off unexpectedly. On one occasion, the vehicle shut off completely while I was driving.

While driving, pressing the accelerator pedal, the vehicle hesitated and stalled. No warning lights came on until after I attempted to turn the vehicle back on then the check engine light and low oil light were illuminated. My vehicle was towed to a local mechanic and I was informed that the engine was blown and to tow my car to a Hyundai dealership as I was still under the 10 year/100k mile warranty. After getting my car to Hyundai, I was told I had to get a combustion cleaning for $800 whether the cleaning worked or not before any warranty work could be completed. The cleaning did not work and it was then found that a pin was sheared off inside the engine. My engine was then replaced under warranty but I still had to pay for the cleaning. A second mechanic looked over my paperwork after getting my car back 2 months later and noted that the engine failure could have been diagnosed without the cleaning as the cleaning would not have affected where the pin was sheared off. My 2017 Elantra had 90,315 at the time of this incident.

The vehicle has experienced ongoing powertrain and electrical malfunctions over several months. The most common symptoms include being stuck in 4th gear (limp mode), complete loss of RPM and speedometer readings, and illumination of the check engine and ESC lights. Most recently, while traveling at approximately 10 mph, the vehicle experienced a sudden loss of both acceleration and braking. The brake pedal became stiff and unresponsive, and the car had to coast to a stop without driver control. This posed a serious safety risk to myself and nearby traffic. These issues have persisted across multiple service visits to Ricart Hyundai in Groveport, Ohio. That dealership has replaced the crankshaft position sensor three times, the powertrain control module (PCM), and the battery, but the underlying problems remain unresolved. A technician at the dealership was able to reproduce the stalling event during a test drive. Despite that, the dealership has refused to proceed with further diagnostics unless I pay for an oil change, even though previous inspections by their own staff found no visible leaks and confirmed the oil level was sufficient at the time. They have also revoked complimentary access to a loaner vehicle despite the unresolved and unsafe condition of the car. The vehicle remains available for inspection. The problem has been confirmed by a dealership, has occurred repeatedly, and continues to pose a safety concern. Warning lights and gauge failures typically appear when the issue occurs.

Timing chain looseness, Sudden loss of engine power/motive power. Vehicle was sold, unknown if available for inspection. Engine failure on and in the middle of the interstate/highway, and this caused a major crash risk, and safety hazard. This make and model of vehicle has multiple reports of similar incidents. The repairs would’ve cost over 3 times the value of the car. As stated by the vehicle manufacturer, the entire engine would need to be replaced, with a factory built engine in order to comply with NHTSA and safety regulations. I’m no longer in possession of the vehicle. It was sold. While the vehicle was operating, and drivable there would be a chime and a flashing check engine light/indicator on occasion. Although no codes were present at maintenance center, therefore unable to identify the exact cause.

My car has been stalling and shaking for months on acceleration. This has put me in unsafe situations where vehicles are going very fast on the highway and I am going 20 miles under the speed limit, or I am accelerating to merge and my car fails to accelerate, or I'm on the regular road and my car slows to a crawl while people are coming in fast behind me. The Error Code is: Cylinder 3 misfire. Took it to the dealer, they said they couldn't find anything wrong with it because the light was not on, they updated the software, as soon as I drove home the problem came back. They still charged me $200 for service, even thought the vehicle is under powertrain warranty which covers the cylinder block head and all internal parts. Online research shows this is a common problem in 2017 Hyundai Elantras. Many tried replacing coils and spark plugs only for the problem to return again a few months later. One successful fix found the computer needed to be replaced with a new one.

My 2017 Elantra with 107,000 miles (it has a 100,000 mile powertrain warranty) on it has just experienced the same issue as all of the other Hyundais that have been recalled. I was driving on Xmas evening 2024 and started hearing my engine making noises I had not heard before when excellerating but then they would go away. On my way home the check engine light went on for a couple of minutes but then went off and I was able to get home although the car did not seem to be riding well. The next day, the check engine light went on again and so I brought it in to my mechanic. He said that there were metal fragments/shavings in my oil that were clogging my engine, etc. He said that I need a new engine and said he had several other Elantras with the same issue and that I should take it to a Hyundai dealer because of all of their recalls/Class Action Lawsuits which extend warrantees, etc. for the same exact issue. I was able to drive the car there but it was not a safe drive. Their assessment was basically that I need most of my powertrain replaced to the tune of $4100.00 but once they get in there, it might be more extensive and end up having to be replaced. However, they did not say anything about the metal fragments and when I brought it up to them, they acted like they didn't see them. However, my mechanic (with no skin in the game) said they were all over the place in my car's oil. So, I am a little wary that they decided to skate that issue, since it is the basis for all of their Class Actions, etc. I'm kind of stuck, Hyundai has my car and it really isn't drivable. I've checked many Elantra forums and have seen that this is happening to Many other 2017 Hyundi Elantra SE even though they have not yet been added to the recalls/Class Actions, etc. I really think that the Hyundai engine issue is more widespread than just the cars on the current list and I hope that this is looked into as it is extremely dangerous and comes on very quickly without warning.