NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,313 reports40,000 miles · Nov 9, 2016
Electronic Stability Control (esc)EngineUnknown Or Other
AROUND 40,000 MILES THE CAR RANDOMLY WOULD NOT START, LEAVING ME STRANDED. I TOOK THE CAR IN SEVERAL TIMES AND DEALERSHIP COULD NOT DETECT AN ISSUE. 2ND TIME I DROPPED OFF, A MISFIRE WAS DETECTED AND IGNITION COILS WHERE REPLACED DUE TO DEFECTED COILS. I PICKED UP MY CAR AND 11 DAYS LATER THE CAR WOULDN'T START UP AGAIN. ITS BEE…
Read full complaint
AROUND 40,000 MILES THE CAR RANDOMLY WOULD NOT START, LEAVING ME STRANDED. I TOOK THE CAR IN SEVERAL TIMES AND DEALERSHIP COULD NOT DETECT AN ISSUE. 2ND TIME I DROPPED OFF, A MISFIRE WAS DETECTED AND IGNITION COILS WHERE REPLACED DUE TO DEFECTED COILS. I PICKED UP MY CAR AND 11 DAYS LATER THE CAR WOULDN'T START UP AGAIN. ITS BEEN IN THE SHOP FOR 3 WEEKS NOW. LAST I HEARD THEY ARE REPLACING: THE SHIFTER ASSEMBLY, TRANSMISSION RANGE SWITCH, AND BRAKE SWITCH. I HAVE YET TO HEAR IF THE PARTS CAME IN AND IF THIS WILL FIX THE ISSUE. I RECEIVED A CALL ON 11/3/2016 AND NOW THE ENGINE NEEDS TO BE REPLACED. THERE IS A SERIOUS ISSUE WITH THE CAR FAILING TO START AND HYUNDAI CANT EVEN FIGURE IT OUT, AS OF TODAY THEY HAD MY CAR FOR A TOTAL OF 25 DAYS AND STILL NO RESOLUTION. SOMETHING NEEDS TO BE DONE AND RECALLED. IVE CONTACTED HYUNDAI CONSUMER AFFAIRS DIRECTLY AND HAVE A CASE WITH THEM GOING ON. I SEE SEVERAL COMPLAINTS OF THIS SAME ISSUE HAPPENING ON THIS MODEL, I HOP THIS WILL SOMEWHAT HELP. BE CONSISTENT AND DON'T TAKE NO FOR ANSWER, I AM STILL MAKING CAR PAYMENTS ON SOMETHING THAT IS NOT WORKING NOR I HAVE IS UNFAIR. SINCE THE CAR IS LESS THAN 60,000 MILES THIS WILL BE COVERED UNDER WARRANTY, IT SHOULD OF HAD TO TAKE ME 3 TIMES, CALLING A MANGER AND GOING TO CONSUMER AFFAIRS FOR THEM TO FINALLY TAKE MY ISSUE SERIOUS.
NHTSA ODI #10925221
85,000 miles · Nov 2, 2016
Electrical System
PUSH BUTTON START. CAR WILL NOT START RIGHT AWAY AFTER DEPRESSING THE START BUTTON. WHEN START BUTTON IS DEPRESSED, INDICATING LIGHTS ON THE DASH WILL ILLUMINATE, AND APPROXIMATELY 10 SECOND LATER, THE RADIO AND THE AIR CONDITIONING WILL KICK IN. AT THIS POINT I HAVE APPROXIMATELY 10 SECONDS TO ATTEMPT TO START THE CAR AND 75…
Read full complaint
PUSH BUTTON START. CAR WILL NOT START RIGHT AWAY AFTER DEPRESSING THE START BUTTON. WHEN START BUTTON IS DEPRESSED, INDICATING LIGHTS ON THE DASH WILL ILLUMINATE, AND APPROXIMATELY 10 SECOND LATER, THE RADIO AND THE AIR CONDITIONING WILL KICK IN. AT THIS POINT I HAVE APPROXIMATELY 10 SECONDS TO ATTEMPT TO START THE CAR AND 75% OF THE TIME THE CAR WILL START; OTHERWISE, I HAVE TO TURN THE CAR OFF AND ATTEMPT TO RESTART AGAIN. THIS ISSUE HAS BEEN GOING ON FOR APPROXIMATELY TWO MONTHS NOW. TOOK IT INTO THE DEALERSHIP AND THEY STATED THEY COULD NOT RECREATE THE PROBLEM AS THE CAR STARTED FOR THEM EVERY TIME APPARENTLY AND COULD NOT DO ANYTHING TO SOLVE MY ISSUE, EVEN THOUGH THEY ADMITTEDLY TIGHTENED UP TERMINALS FOR THE BATTERY. THE CAR SEEMED TO START EVERY SINGLE TIME FOR ABOUT A WEEK AFTER THE VISIT, AND NOW IT'S DOING IT AGAIN. CALLED HYUNDAI AND THEY KNEW NOTHING ABOUT ISSUE. I'VE RESORTED TO TAKING VIDEO TO HELP DESCRIBE THE ISSUE TO TECHNICIANS, AND THE LATEST DEALERSHIP BASICALLY TOLD ME THAT THEY STILL WOULD NOT BE ABLE TO USE MY VIDEO BUT WOULD HAVE TO RECREATE THE PROBLEM THEMSELVES. THIS IS GOING TO BE REALLY BAD IF I'M STUCK IN SOMEWHERE BECAUSE MY CAR WON'T START AND HYUNDAI CLAIMING THEY CANT DO ANYTHING ABOUT IT.
NHTSA ODI #10923787
7,000 miles · Oct 28, 2016
Engine
CAR SMOKES HEAVILY LIKE EVERY 10,000 MILES WHEN ACCELERATING FAST AND SUDDENLY, LIKE WHEN GOING ON THE FREEWAY ON RAMP OR TRYING TO OVERPASS ANOTHER VEHICLE. IT BLOWS A HUGE , BIG , WHITE CLOUD OF SMOKE THAT IMPAIRS VISIBILITY OF OTHER DRIVERS. IT IS A HAZARD AGAINST SAFETY AND CONTAMINETS THE ENVIROMENT . OIL LEVEL SEEMS T…
Read full complaint
CAR SMOKES HEAVILY LIKE EVERY 10,000 MILES WHEN ACCELERATING FAST AND SUDDENLY, LIKE WHEN GOING ON THE FREEWAY ON RAMP OR TRYING TO OVERPASS ANOTHER VEHICLE. IT BLOWS A HUGE , BIG , WHITE CLOUD OF SMOKE THAT IMPAIRS VISIBILITY OF OTHER DRIVERS. IT IS A HAZARD AGAINST SAFETY AND CONTAMINETS THE ENVIROMENT . OIL LEVEL SEEMS TO BE FINE BETWEEN SERVICES. IT HAS BEEN HAPPENING SINCE NEW. AT 7000 MILES, 15000 MILES AND TODAY AT 40,000 MILES . THERE ARE MANY COMPLAINS ABOUT THAT. READ HERE : HTTP://WWW.HYUNDAI-FORUMS.COM/MD-2011-2016-ELANTRA-SEDAN-COUPE/137770-SMOKE-ACCELERATION.HTML
NHTSA ODI #10919746
59,000 miles · Oct 19, 2016
Exterior Lighting
TL* THE CONTACT OWNS A 2013 HYUNDAI ELANTRA. THE CONTACT STATED THAT BOTH TAIL LIGHTS FAILED TO ILLUMINATE. THE CONTACT HAD TO TAP THE TAIL LIGHTS IN ORDER FOR THE LIGHTS TO ILLUMINATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 59,000.
NHTSA ODI #10917363
67,000 miles · Oct 18, 2016
Electronic Stability Control (esc)EngineExterior Lighting
ENGINE FAILURE. ZERO COMPRESSION CYLINDER #1. SECOND TIME THIS HAS HAPPENED SINCE PURCHASE ON 10/18/2016. ALSO, TIRE PRESSURE PROBLEM, ESC LIGHT COMES ON, DASHBOARD GAUGES INOPERATIVE. FUEL MILEAGE BELOW WHAT IS ADVERTISED. NEITHER HUNDAI NOR ENTERPRISE WILL FIX THE PROBLEM AFTER REPEATED DEMANDS. ALSO, THERE IS A RECALL REGARDI…
Read full complaint
ENGINE FAILURE. ZERO COMPRESSION CYLINDER #1. SECOND TIME THIS HAS HAPPENED SINCE PURCHASE ON 10/18/2016. ALSO, TIRE PRESSURE PROBLEM, ESC LIGHT COMES ON, DASHBOARD GAUGES INOPERATIVE. FUEL MILEAGE BELOW WHAT IS ADVERTISED. NEITHER HUNDAI NOR ENTERPRISE WILL FIX THE PROBLEM AFTER REPEATED DEMANDS. ALSO, THERE IS A RECALL REGARDING "STOPPER PAD" AND STOP LAMP SWITCH. BOUGHT VEHICLE, CASH, FROM ENTERPRISE CAR SALES IN MONTCLAIR, CA. IT WAS A "CERTIFIED" USED CAR, SUPPOSEDLY. IMMEDIATELY I NOTICED THAT THE ENGINE SOUNDED "TINNY". SOUNDED LIKE A SEWING MACHINE, IT WAS KNOCKING. ALSO, WHEN I LIFTED THE OIL STICK, SMOKE CAME OUT OF ENGINE. THIS WAS WITHIN 2 WEEKS AFTER PURCHASE. THE CAR COMPLETELY LOST COMPRESSION ON INTERSTATE 10 IN APRIL, 2015. I TOLD BOTH HYUNDAI AND ENTERPRISE WHO IGNORED MY COMPLAINTS. FINALLY, AFTER SEVERAL COMPLAINTS AND THREATS, ENTERPRISE TOOK THE CAR IN AND SENT IT TO HYUNDAI DEALERSHIP WHO CLAIMED THERE WAS NO PROBLEM. THE CAR BEGAN LOSING POWER AGAIN IN SEPTEMBER, 2016 AND FINALLY STOPPED IN THE MIDDLE OF THE STREET IN ARCADIA, CA. NO COMPRESSION. IT HAD TO BE TOWED TO MY HOUSE. I TOOK IT TO PRIVATE SHOP WHO SAID "ZERO COMPRESSION IN CYLINDER #1, POSSIBLE BURNED OUT VALVE '. SEE ATTACHED. CALLED HYINDAI AND ENTERPRISE AGAIN. BOTH DENIED RESPONSIBILITY, AND REFUSED TO DO ANYTHING. I HAVE TO NOW PAY OVER $1,000 TO GET ENGINE REBUILT. THIS CAR IS A LEMON AND I AM ENTTIED TO REFUND OR A NEW CAR.
NHTSA ODI #10917176
129,000 miles · Oct 18, 2016
Air BagsService Brakes
MY AIRBAG LIGHT WAS OFF AND ON FOR ABOUT A MONTH AND NOW IT IS A STEADY LIGHT. THE REPAIR SHOP I TOOK IT TO SAID I NEEDED A CLOCK SPRING AND A NEW DRIVER AIR BAG. THEY ALSO SAID I MIGHT NEED ANOTHER PART. TOTAL COST OF ALL OF THIS WILL BE AROUND $1600. SINCE MY CAR HAS OVER 100,000 MILES, IT IS NOT UNDER WARRANTY. I'VE NOTI…
Read full complaint
MY AIRBAG LIGHT WAS OFF AND ON FOR ABOUT A MONTH AND NOW IT IS A STEADY LIGHT. THE REPAIR SHOP I TOOK IT TO SAID I NEEDED A CLOCK SPRING AND A NEW DRIVER AIR BAG. THEY ALSO SAID I MIGHT NEED ANOTHER PART. TOTAL COST OF ALL OF THIS WILL BE AROUND $1600. SINCE MY CAR HAS OVER 100,000 MILES, IT IS NOT UNDER WARRANTY. I'VE NOTICED OTHER PEOPLE ARE COMPLAINING ABOUT THE AIRBAG LIGHT.
NHTSA ODI #10916739
57,000 miles · Oct 17, 2016
Air BagsService BrakesSuspension
1. AIRBAG LIGHT HAS BEEN TURNING ON. NO APPARENT REASON BUT I WAS TOLD THAT IF IN AN ACCIDENT WILL NOT DEPLOYED. SINCE 10/12/2016 2. SUSPENSION IS NOT THE GREATEST, CAR WILL SWIRLED SOMETIMES IF EXCEEDING 40MPH HELLO I LIVE IN PUERTO RICO THERE IS NO SUCH THING AS 40MPH IN OUR ROADS... 3. TIRE SENSORS ARE CONSTANTLY BRA…
Read full complaint
1. AIRBAG LIGHT HAS BEEN TURNING ON. NO APPARENT REASON BUT I WAS TOLD THAT IF IN AN ACCIDENT WILL NOT DEPLOYED. SINCE 10/12/2016 2. SUSPENSION IS NOT THE GREATEST, CAR WILL SWIRLED SOMETIMES IF EXCEEDING 40MPH HELLO I LIVE IN PUERTO RICO THERE IS NO SUCH THING AS 40MPH IN OUR ROADS... 3. TIRE SENSORS ARE CONSTANTLY BRAKING. 4. FRONT HEADLIGHTS SEEMS GET HUMIDITY WHEN IT RAINS OR GET TOO COLD. 5. BRAKES SOMETIMES DO NOT WORK AS THEY SHOULD, I STOP AND IT SEEMS TO KEEP GOING I WOULD HAVE TO BRAKE AGAIN TO MAKE IT STOP AND THESE IS NOT GOING MORE THAN 40 MPH.
NHTSA ODI #10916464
Mileage unknown · Oct 12, 2016
Service BrakesVehicle Speed ControlCrashInjury
TL* THE CONTACT OWNS A 2013 HYUNDAI ELANTRA. WHILE DRIVING 10 MPH WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE INDEPENDENTLY ACCELERATED AND CRASHED INTO A CONCRETE PATIO. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED INJURIES TO THE NECK AND BRUISES TO THE ARMS AND LEGS. MEDICAL ATTENTION WAS …
Read full complaint
TL* THE CONTACT OWNS A 2013 HYUNDAI ELANTRA. WHILE DRIVING 10 MPH WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE INDEPENDENTLY ACCELERATED AND CRASHED INTO A CONCRETE PATIO. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED INJURIES TO THE NECK AND BRUISES TO THE ARMS AND LEGS. MEDICAL ATTENTION WAS NOT REQUIRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND REPAIRED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
NHTSA ODI #10915620
75,887 miles · Oct 12, 2016
Latches/locks/linkages
TL* THE CONTACT OWNS A 2013 HYUNDAI ELANTRA. WHILE DRIVING 40 MPH, THE TRUNK OPENED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 75,887.
NHTSA ODI #10915573
28,000 miles · Oct 12, 2016
Electrical SystemEngineUnknown Or Other
VEHICLE WAS STATIONARY. CHECK ENGINE LIGHT AND LACK OF DIGITAL ENGINE TEMPERATURE GAUGE ALERTED DRIVER TO ISSUE. UPON INSPECTION AT AUTHORIZED HYUNDAI SERVICE CENTER, IT WAS NOTED THAT RODENTS HAD GNAWED THROUGH WIRING AND CONNECTORS LOCATED IN THE ENGINE BAY. PER SERVICE CENTER'S RECOMMENDATION, VEHICLE WAS CONSIDERED UNSAFE T…
Read full complaint
VEHICLE WAS STATIONARY. CHECK ENGINE LIGHT AND LACK OF DIGITAL ENGINE TEMPERATURE GAUGE ALERTED DRIVER TO ISSUE. UPON INSPECTION AT AUTHORIZED HYUNDAI SERVICE CENTER, IT WAS NOTED THAT RODENTS HAD GNAWED THROUGH WIRING AND CONNECTORS LOCATED IN THE ENGINE BAY. PER SERVICE CENTER'S RECOMMENDATION, VEHICLE WAS CONSIDERED UNSAFE TO DRIVE, AND VEHICLE WAS LEFT AT SERVICE CENTER PENDING APPROPRIATE REPAIRS/REPLACEMENTS. IT WAS NOTED THAT THE WIRES THAT WERE CHEWED THROUGH WERE COATED WITH SOY-BASED MATERIALS INSTEAD OF PLASTIC WHICH HAD BEEN USED IN EARLIER MODELS. SERVICE CENTER CLAIMS TO SEE THIS ISSUE AT LEAST A FEW TIMES PER MONTH. RODENT DETERRENT TAPE IS BEING PURCHASED FROM HONDA (WHO ALREADY ACKNOWLEDGES THIS ISSUE AND IS CURRENT THE SUBJECT OF A CLASS ACTION LAWSUIT). TAPE WILL BE WRAPPED AROUND WIRES FOLLOWING REPAIRS.
NHTSA ODI #10915549
Official recalls
4Sep 22, 2023
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
Nov 30, 2017
Hyundai Motor Company (Hyundai) is recalling certain 2013-2014 Elantra sedan, coupe and GT vehicles. The brake pedal stopper pad can deteriorate allowing the brake light switch plunger to remain extended when the brake pedal is released. This will allow the brake lights to remain illuminated continuously. It can also allow the shift lever to be moved without depressing the brake pedal, or activate the engine management brake pedal override feature.
Consequence & remedy
Consequence: If the brake light switch plunger does not retract as it should when the brake pedal is not being pressed, the brake lights may stay illuminated preventing accurate communication to following vehicles that the vehicle is slowing or stopping. Additionally, if the brake switch plunger is not retracted, then the transmission can be shifted out of PARK without depressing the brake pedal. Either condition increases the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the brake pedal stopper pad, free of charge. The recall is expected to begin February 8, 2018. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 170. This campaign expands recall 16V574.
Aug 2, 2016
Hyundai Motor America (Hyundai) is recalling certain model 2013 Elantra vehicles manufactured December 1, 2012, to April 30, 2013. The brake pedal stopper pad can deteriorate allowing the brake light switch plunger to remain extended when the brake pedal is released.
Consequence & remedy
Consequence: If the brake light switch plunger does not retract as it should when the brake pedal is not being pressed, the brake lights may stay illuminated preventing accurate communication to following vehicles that the vehicle is slowing or stopping. Additionally, if the brake switch plunger is not retracted, then the transmission can be shifted out of PARK without depressing the brake pedal. Either condition increases the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the brake pedal stopper pad with an improved part, free of charge. The recall is expected to begin on September 30, 2016. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 146.
Apr 1, 2013
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence & remedy
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Additional source detail variants (2)
Structure
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Air Bags:side/window
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
EA21003 · Engine Fires
Opened Dec 22, 2021 · Closed Feb 5, 2024
Status: closed (inferred from source dates) · Engine
On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V-568, 17V-226, 20V-746, and 21V-727; and Kia recalls 17V-224, 19V-120, 20V-750, and 21V-844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V-877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines. The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS. It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
EA12008 · Headliner Bracket Detachment
Opened Sep 13, 2012 · Closed Dec 9, 2013
Status: closed (inferred from source dates) · Air Bags:side/window; Structure:body:roof And Pillars; Unknown Or Other
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Additional source detail variants (3)
Air Bags:side/window
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Structure:body:roof And Pillars
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Unknown Or Other
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Illustration